Installation Manual

ManualsBrandsPanasonic ManualsDuctless Mini Splits9,000 BTU 3/4 Ton Exterios XE High SEER Ductless Mini Split Air Conditioner with Heat Pump - 208-230V/60Hz

Table Of Contents

Order No: PAPAMY1601004CE

Air Conditioner

Indoor Unit Outdoor Unit

CS-XE9SKUA

CS-XE12SKUA

CU-XE9SKUA

CU-XE12SKUA

Destination

U.S.A.

Canada

CLOCK

AIRCO NDITIONER

OFF/ON

SET CHECK RESET

OFF

SET

123

TIMER

AUTO

COMFORT

POWERFUL /

QUIET

MODE

TEMP

FAN SPEED

AIR SWING

ECONAV I

RFP

MODE

FF/

CANCEL

IMPORTANT SAFETY NOTICE

There are special components used in this equipment which are important for safety. These parts are marked by in the Schematic

Diagrams, Circuit Board Diagrams, Exploded Views and Replacement Parts List. It is essential that these critical parts should be replaced

with manufacturer’s specified parts to prevent shock, fire or other hazards. Do not modify the original design without permission of

manufacturer.

This service information is designed for experienced repair technicians only and is not designed for use by the general public.

It does not contain warnings or cautions to advise non-technical individuals of potential dangers in attempting to service a product.

Products powered by electricity should be serviced or repaired only by experienced professional technicians. Any attempt to service

or repair the products dealt with in this service information by anyone else could result in serious injury or death.

WARNING

PRECAUTION OF LOW TEMPERATURE

In order to avoid frostbite, be assured of no refrigerant leakage during the installation or repairing of refrigerant circuit.

Installation Manual

Summary of content (10 pages)

PAGE 1
Order No: PAPAMY1601004CE Installation Manual Air Conditioner Indoor Unit CS-XE9SKUA CS-XE12SKUA Destination U.S.A. Canada A IR C O N D IT IO N E R M O DE ECO NAV I O FF/O N Outdoor Unit CU-XE9SKUA CU-XE12SKUA AU TO C O M FO RT M OD E RFP TEMP POWERFUL/ QUIET A IR SW IN G FANSPEED T IM E R O N 1 SET 2 3 CANCEL O FF AC SET CHECK CLOCK RC RESET WARNING This service information is designed for experienced repair technicians only and is not designed for use by the general public.
PAGE 2
11. Installation Instruction 11.1 Select the Best Location Do not install the unit in excessive oil fume area such as kitchen, workshop and etc. There should not be any heat source or steam near the unit. There should not be any obstacles blocking the air circulation. A place where air circulation in the room is good. A place where drainage can be easily done. A place where noise prevention is taken into consideration. Do not install the unit near the door way.
PAGE 3
11.2 Indoor Unit The mounting wall shall be strong and solid enough to prevent it from vibration. Wall Wall Wall More than 1 More than 1 More than 2 2 screw 5 1/16" (128 mm) DISTANCE TO PIPE HOLE CENTER 128 mm 9 17/32" (241.5 mm) Measuring Tape PIPEHOLECENTER 5 1/16" (128 mm) DISTANC E TO PIP E HO LE CEN TER 128 m m PIPE HOLE CENTER 5 1/16" (128 mm) Dimension Model XE9SKUA, XE12SKUA 9 17/32" (241.
PAGE 4
Indoor Unit Installation pull o ut the Do not turn over the unit without it’s shock absorber during pulling out the piping. It may cause intake grille damage. pip in g pull o ut the pip in g Use shock absorber during pulling out the piping to protect the intake grille from damage. Piping Piping PUSH 11.2.2 PUSH PUSH Shock absorber PUSH Intake grille 11.2.2.
PAGE 5
Replace the drain hose Rear view for left piping installation Connection cable Piping Drain hose Drain cap Connection cable Drain hose Drain hose Sleeve for piping hole Adjust the piping slightly downwards. • How to pull the piping and drain hose out, in case of embedded piping. Apply putty or caulking material to seal the wall opening. n tha re Mo 9 /32" m) 45 50 m (11 Connection cable More than 45 9/32" (1150 mm) • How to insert the connection cable and drain hose in the case of left piping.
PAGE 6
11.2.3 1 2 3 Connect the Cable to the Indoor Unit The inside and outside connection cable can be connected without removing the front grille. Unscrew the conduit cover and fix the conduit connector to conduit cover with lock nut, then secure it against chassis. Connection cable between indoor unit and outdoor unit should be UL listed or CSA approved 4 conductor wires minimum AWG16 in accordance with local electric codes.
PAGE 7
11.3 Outdoor Unit 11.3.1 Install the Outdoor Unit After selecting the best location, start installation according to Indoor/Outdoor Unit Installation Diagram. 1 Fix the unit on concrete or rigid frame firmly and horizontally with a bolt nut ø13/32" (ø10 mm). 2 When installing at roof, please consider strong wind and earthquake. Please fasten the installation stand firmly with bolt or nails. B Model A B C D XE9SKUA, XE12SKUA 24-1/8" (613 mm) 5-5/32" (131 mm) 5/8" (16 mm) 14-3/16" (360.
PAGE 8
11.3.3 Evacuation of the Equipment WHEN INSTALLING AN AIR CONDITIONER, BE SURE TO EVACUATE THE AIR INSIDE THE INDOOR UNIT AND PIPES in the following procedure. Indoor unit Liquid side Two-way valve Outdoor unit Close Gas side Three-way valve Close Vacuum pump 1 2 3 4 5 6 7 8 Connect a charging hose with a push pin to the Low side of a charging set and the service port of the 3-way valve. Connect the micron gauge between vacuum pump and service port of outdoor units.
PAGE 9
Disconnect Switch Field supply Indoor Unit Terminal Outdoor Unit Terminal 208/230V min AWG16 1 2 1 2 208/230V min AWG16 208/230V min AWG16 3 3 Grounding wire min AWG16 Disconnect Switch Field supply L1 L2 Grounding wire Secure the wire onto the control board with the holder (clamper). 10 After completing wiring connections, reattach the particular plate and control board cover (metal and resin) to the original position with the screws.
PAGE 10
11.3.6 Disposal of Outdoor Unit Drain Water The unit should be mounted on a stand that suits to a local environmental requirement. When the Drain elbow being used, please ensure to:o Provide a minimum clearance of 2" (50mm) to access the bottom of base pan. o Seal the four 25/32" (20mm) diameter holes with Rubber caps (refer to illustration below).