GAS COOKER SIG 233 GB
CONTENTS Instructions for the User Instructions for the Installer Warnings 4 Technical Features 18 Use and care 5 Use of the appliance Using the Oven Using the Grill Using the Hob 6 6 8 9 Advice for safety Gas connection Electrical connections 19 19 19 Installation 20 Gas connection 21 Hints and tips 12 Conversion of gas 23 Maintenance and cleaning 13 Oven bulb replacement 14 Something Not Working 15 Service and spare parts 16 Guarantee Conditions 17 How to read the instruction
IMPORTANT SAFETY INFORMATION You MUST read these warnings carefully before installing or using the appliance. If you need assistance, contact our Customer Care Department on 08705 950950. Installation • This cooker must be installed by qualified personnel, according to the manufacturer’s instructions and to the relevant British Standards. • This cooker is heavy. Take care when moving it. • Any gas installation must be carried out by a registered CORGI installer.
INSTRUCTIONS FOR THE USER USE AND CARE Control panel Model : SIG 233 7 BACK LEFT 1 1. 2. 3. 4. FRONT LEFT 2 FRONT RIGHT 3 Back left burner control knob Front left burner control knob Front right burner control knob Back right burner control knob SELECTOR BACK RIGHT 4 5 6 5. Oven light 6. Oven/Grill burner control knob (selector) 7. Ignition switch Hob 1 4 2 3 1. Back left burner (auxiliary) 2. Front left burner (rapid) 3. Front right burner (semi-rapid) 4.
USE OF APPLIANCE Before the First Use of the Cooker Remove all packaging both inside and outside of the cooker, before using it. Before first use, the oven should be heated without food. During this time, an unpleasant odour may be emitted. This is quite normal. 1. Remove the oven accessories and ensure all packaging has been removed. 2. Ignite the oven burner (see instructions) and turn the control knob to maximum. 3. Open a window for ventilation. 4.
Ignition Attention: when turning on the oven and grill burner the oven door has to be opened. • Open the oven door, push and turn the control knob to the left to position 8, keeping the control knob pressed. • At the same time, push the electronic ignition knob (see fig). Keep it pushed until the gas ignites (1 spark / second). • Release the knob after 10 seconds and check that the burner is ignited through the holes in the burner cover.
Using the Grill When grilling, the accessible parts of the appliance are hot and the appliance should not be left unattended. Take care that children do not play near it. While the grill is operating leave the oven door half open and put the grill deflector “A” into place. Grill burner ignition Attention: when turning on the oven and grill burner the oven door has to be opened. • • • Open the oven door push and turn the control knob to the right to the “grill symbol” and keep the control knob pressed.
Heat comes from the top of the oven. It is suitable for grilling meat (beef bacon, pork bacon …) that remains tender, for toast or to brown dishes already cooked dishes. Grilling meat When using the grill it has to be supervised, the oven door opened and the grill deflector “A” in its place. • Prepare the meat to be grilled, lightly brush it with oil on both sides. • Place it on the roasting grid. • Turn the oven/grill control knob to position “grill”.
Ignition of the burners • Push the knob and turn it left to the “large flame“ symbol. • At the same time, push the electronic ignition knob (see fig). Keep it pushed until the gas ignites (1 spark / second). • Release the knob and watch that the burner has ignited. • Upon ignition, adjust the flame as required. OR Power Cut • Push the corresponding knob in completely and turn it left to the “large flame“ symbol and ignite with a match.
Accessories appliance delivered with the The following accessories are supplied with your appliance. • Grill Deflector To be used when the grill is operation. • Shelf for placing dishes on (roast, pastry mounds) The dish should be put in the middle of the shelf to balance the weight. • A roasting tray with roasting grid on it. It is used to collect juice when cooking in it, place it on the shelf 2. If you do not use the roasting tray, remove it from the oven.
Hints and Tips Condensation and steam When food is heated it produces steam in the same way as a boiling kettle. The oven vents allow some of this steam to escape. However, always stand back from the oven when opening the oven door to allow any build up of steam or heat to release. If the steam comes into contact with a cool surface on the outside of the oven, e.g. a trim, it will condense and produce water droplets. This is quite normal and is not a fault with the oven.
MAINTENANCE AND CLEANING The oven should be kept clean at all times. A build-up of fats or other foodstuffs could result in a fire. Before cleaning, ensure all control knobs are in the OFF position, and the appliance has cooled completely. Before any maintenance or cleaning can be carried out, you must DISCONNECT the cooker from the electricity supply.
DO NOT clean the oven door while the glass panels are warm. If this precaution is not observed the glass panel may shatter. If the door glass panel becomes chipped or has deep scratches, the glass will be weakened and must be replaced to prevent the possibility of the panel shattering. Contact your local Service Centre who will be pleased to advise further.
SOMETHING NOT WORKING If the appliance is not working correctly, please carry out the following checks, before contacting your local Service Force Centre. IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee. Symptoms Solutions 1.
SERVICE AND SPARE PARTS In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your local Service Force Centre by telephoning:- 08705 929929 Your telephone call will be automatically routed to the Service Force Centre covering your post code area. For the address of your local Service Force Centre and further information about Service Force, please visit the website at www.serviceforce.co.
GUARANTEE CONDITIONS Standard Guarantee Conditions We Parkinson Cowan undertake that if, within 12 months of the date of the purchase, this Parkinson Cowan appliance or any part thereof is proved to be defective by any reason only of faulty workmanship or materials, we will, at our option, repair or replace the same FREE OF ANY CHARGE for labour, materials or carriage on condition that: • The appliance has been correctly installed and used only on the electricity supply stated on the rating plate.
INSTRUCTIONS FOR THE INSTALLER TECHNICAL FEATURES Free standing Hob Class 1 Lid Pan support Front right burner Back right burner Front left burner Back left burner Hob ignition Oven Oven Oven burner power Grill Grill burner power Oven lamp Oven ignition Cleaning Cavity dimensions Height Width Depth Oven volume Accessories Oven shelf Roasting tray Roasting grid + handle Grill deflector Dimensions Height Width Depth This appliance complies with the following EEC Directives : 93/68 ; 73/23 (Low Volta
ADVICE FOR SAFETY Gas connections Electrical connections • Before installation ensure that the local distribution conditions (gas type and pressure) and the pre-setting of the appliance are consistent. • This appliance must be installed only in a room with good ventilation. • This appliance must not connected to a chimney. It has to be installed and connected in accordance with the rules in force. Special attention should be paid to the applicable disposal concerning ventilation.
INSTALLATION 61 cm The appliance must be set on a heatproof floor. The adjustable feet must not be removed. L.P.G. cookers or ovens MUST NOT be installed below ground level, i.e. in a basement, or aboard any boat, yacht or other vessel. This appliance is approved to class “1” regarding overheating of surrounding surfaces. It is mandatory to keep 20mm distance to the adjacent furniture.
Levelling The appliance is provided with adjustable small feet placed in the back and front corners of the base. By adjusting the small feet it is possible to change the height of the appliance so as to ensure a better levelling with other surfaces and a uniform distribution of the liquids contained in pans or pots. GAS CONNECTIONS Gas connection must be carried out according to the rules in force. Your cooker is delivered adjusted for the kind of gas stated on the rating plate.
Connection shall be by means of an appliance flexible connector for use with a self-sealing plugin device, complying with: Flexible hoses, end fittings and sockets for gas burning appliances – BS 669; - - The appliance flexible connector should not be subjected to undue forces either in normal use or whilst connected or disconnected; The socket which the plug of the appliance flexible connector fits should be permanently attached to a firmly fixed gas installation pipe and positioned such that the applian
CONVERSION OF GAS Your cooker is designed to work with natural gas, propane or butane. It is not designed for butane or propane air. The LPG conversion kit is available from your Service Force Centre and must be fitted by a Corgi Registered engineer.
Replace the nozzles of the hob burners Before any modifications or conversion to a kind of different gas, you must DISCONNECT the cooker from the electricity supply and ensure that all control knobs are in the OFF position, and the appliance has cooled completely. Hob burners • • • Remove the pan supports; Remove the caps and the burner crowns; Using a No 7 socket spanner unscrew the nozzles and replace them with those required for the type of gas in use (see table no. 1).
Replace the nozzles of the oven burners Oven burner To replace the gas oven nozzle, follow this procedure: • Check the table no.1 for diameter of nozzle; • Remove the oven removable base panel; • Remove the screw 1 on the oven burner • Remove the oven burner by pulling it forwards. • Replace the nozzle by means of a No 7 socket spanner; Reassemble the parts following the same procedure in reverse.
