User Guide

ManualsBrandsPeerless ManualsBoilersPF-80 - 64,000 BTU Output PUREFIRE High Efficiency Residential Boiler (LP Gas)

USER’S INFORMATION MANUAL

PUREFIRE

OILERS

TO THE INSTALLER:

This manual is the property of the owner and must be affixed near the boiler for

future reference.

TO THE OWNER:

This boiler should be inspected annually by a Qualified Service Agency.

TO BE COMPLETED BY THE INSTALLER

Service Agency Phone No.

Address

Boiler Model No. Serial No. Date of Installation:

If the information in this manual is not followed

exactly, a fire or explosion may result causing

property damage, personal injury or loss of life.

WARNING

– Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

– WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

• If you cannot reach your gas supplier, call

the fire department.

–Installation and service must be performed by

a qualified installer, service agency or the gas

supplier.

PB HEAT, LLC

131 S. CHURCH ST • BALLY, PA 19503

PF8147 R1 (10/13-1.5M)

Printed in U.S.A.

Négliger de suivre ces instructions à la lettre pourrait

provoquer un incendie ou une explosion causant

des dégâts matériels, des blessures ou la mort.

MISE EN GARDE

– Ne pas ranger ou utiliser de la gazoline ou

d’autres liquides ou gaz inflammables à proximité

de cet appareil ou d’un autre du même type.

– QUE FAIRE SI VOUS DÉTECTEZ UNE ODEUR

DE GAZ

• Ne pas tenter d’allumer l’appareil.

• Ne toucher à aucun interrupteur électrique ;

n’utiliser aucun appareil téléphonique dans

l’immeuble.

• Contacter immédiatement votre fournisseur

de gaz à partir du téléphone d’un voisin.

Suivre les instructions données par votre

fournisseur de gaz.

• S’il est impossible de rejoindre le fournisseur

de gaz, appeler le service des incendies.

– L’installation et l’entretien doivent être effectués

par un installateur qualifié, une société

d’entretien ou le fournisseur de gaz.

Summary of content (8 pages)

PAGE 1
USER’S INFORMATION MANUAL PUREFIRE GAS BOILERS ® TO THE INSTALLER: This manual is the property of the owner and must be affixed near the boiler for future reference. TO THE OWNER: This boiler should be inspected annually by a Qualified Service Agency. WARNING MISE EN GARDE If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
PAGE 2
Basic Operation WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. CAUTION Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to the pump. Instead, shut off the gas supply at a location external to the appliance. En cas de surchauffe ou si l’alimentation ne se coupe pas, ne pas éteindre manuellement ni couper l’alimentation électrique de la pompe.
PAGE 3
Figure 2: Control & Safety Device Locations – PF-210/399 Figure 1: Control & Safety Device Locations – PF-50 through PF-140 Models Figure 3: Control & Safety Device Locations – PF-850/1000/1500 C. Instructions for operation and shutting down your boiler are shown on the Operating and Lighting Instructions Label posted on the back of the boiler cover. The instructions are also shown in Figure 4. D. The sequence of operation is shown in Figure 5.
PAGE 4
Figure 4: Lighting and Operating Instructions 4
PAGE 5
BLOWER 6 Figure 5: Sequence of Operation 5
PAGE 6
User Maintenance WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. Inspections should be performed at intervals specified in the Installation, Operation and Maintenance Manual and this User’s Information Manual. Maintain manuals in a legible condition. Keep boiler area clear and free of combustible materials, gasoline and other flammable vapors and liquids.
PAGE 7
C. Inspect Pressure Relief Valve (Monthly) 1. Inspect the pressure relief valve outlet for signs of leakage. 2. Notify a qualified service contractor immediately if there are signs of leakage. (If the problem persists, it may be the result of a malfunctioning expansion tank or improper system design). D. Inspect Condensate Drain System (Monthly) 1. With the boiler in operation with a call from the thermostat, check that condensate is flowing in the condensate tubing.
PAGE 8
H.