User Guide

ManualsBrandsPeerless ManualsBoilersMI-04 - 75,000 BTU Output Intermittent Ignition Packaged Residential Water Boiler (Nat Gas)

USER’S INFORMATION MANUAL

SERIES MI85

™

/MIH

™

/MI

™

GAS BOILERS

TO THE INSTALLER:

This manual is the property of the owner and must be affixed near the boiler

for future reference.

TO THE OWNER:

This boiler should be inspected annually by a Qualified Service Agency.

TO BE COMPLETED BY THE INSTALLER

Service Agency Phone No.

Address

Boiler Model No. Serial No. Date of Installation:

– Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

– WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your

building.

• Immediately call your gas supplier

from a neighbor’s phone. Follow the

gas supplier’s instructions.

• If you cannot reach your gas supplier,

call the fire department.

– Installation and service must be

performed by a qualified installer,

service agency or the gas supplier.

If the information in this manual is not

followed exactly, a fire or explosion

may result causing property damage,

personal injury or loss of life.

– Ne pas ranger ou utiliser de la gazoline ou

d’autres liquides ou gaz inflammables à

proximité de cet appareil ou d’un autre du

même type.

– QUE FAIRE SI VOUS DÉTECTEZ UNE

ODEUR DE GAZ

• Ne pas tenter d’allumer l’appareil.

• Ne toucher à aucun interrupteur électrique ;

n’utiliser aucun appareil téléphonique dans

l’immeuble.

• Contacter immédiatement votre fournisseur

de gaz à partir du téléphone d’un voisin.

Suivre les instructions données par votre

fournisseur de gaz.

• S’il est impossible de rejoindre le

fournisseur de gaz, appeler le service

des incendies.

– L’installation et l’entretien doivent être effectués

par un installateur qualifié, une société

d’entretien ou le fournisseur de gaz.

Négliger de suivre ces instructions à la lettre

pourrait provoquer un incendie ou une

explosion causant des dégâts matériels, des

blessures ou la mort.

PB HEAT, LLC

131 S. CHURCH ST • BALLY, PA 19503

MI8082 R2 (11/14-5M)

Printed in U.S.A.

WARNING

MISE EN GARDE

Summary of content (9 pages)

PAGE 1
USER’S INFORMATION MANUAL SERIES MI85 /MIH II /MI GAS BOILERS ™ ™ ™ TO THE INSTALLER: This manual is the property of the owner and must be affixed near the boiler for future reference. TO THE OWNER: This boiler should be inspected annually by a Qualified Service Agency. MISE EN GARDE WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
PAGE 2
Basic Operation WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. L’entretien de cette chaudière doit être effectué seulement par des employés qualifiés et d’expérience appartenant à une société d’entretien reconnue. CAUTION Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to the pump. Instead, shut off the gas supply at a location external to the appliance.
PAGE 3
5. Gas Valve. The gas valve regulates gas flow to the burners and pilot. See Figure 1. 6. Safety Relief Valve. A device which protects the boiler against excessive pressure. The safety relief valve can discharge a large amount of hot water - the installer should provide piping to discharge water near floor at a floor drain. If the safety relief valve discharges water, follow instructions TO TURN OFF GAS TO APPLIANCE (see Figures 2 & 3), and contact a qualified service agency. Figure 1: Control Locations B.
PAGE 4
Figure 2: Intermittent Ignition Operating Instructions 4
PAGE 5
Figure 3: Intermittent Ignition Operating Instructions 5
PAGE 6
Figure 4: Intermittent Ignition Sequence of Operation 6
PAGE 7
User Maintenance WARNING Product Safety Information Refractory Ceramic Fiber Product This appliance contains materials made from refractory ceramic fibers (RCF). Airborne RCF, when inhaled, have been classified by the International Agency for Research on Cancer (IARC), as a possible carcinogen to humans. After the RCF materials have been exposed to temperatures above 1800°F (980°C), they can change into crystalline silica, which has been classified by the IARC as carcinogenic to humans.
PAGE 8
WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. Inspections should be performed at intervals specified in the Installation, Operation and Maintenance Manual and this User’s Information Manual. Maintain manuals in a legible condition. Keep boiler area clear and free of combustible materials, gasoline and other flammable vapors and liquids.
PAGE 9
7. Check main burner flames. See Figure 5. The flames should have clearly defined inner cones approximately 1-1/2" (40 mm) high and should have a very sharp blue color characteristic. If the flame is yellow and lazy, follow instructions TO TURN OFF GAS TO APPLIANCE (see Figures 2 & 3) and contact qualified service agency. 8. Adjust all thermostats to lowest setting to shut down boiler. 9. Replace burner observation cover and control access panel. 10. Adjust thermostats to normal setting. D.