MAINTENANCE/SERVICE EH3500 Series Environmental Enclosure C478SM-A (4/07)
C478SM-A (4/07)
Contents Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Models . . . . . . . . . . . . . . . . . . . . . . . . . . .
Important Safety Instructions 1. Installation and servicing should only be done by qualified service personnel and conform to all local codes. 2. Unless the unit is specifically marked as a NEMA Type 3, 3R, 3S, 4, 4X, 6, or 6P enclosure, it is designed for indoor use only and it must not be installed where exposed to rain and moisture. 3. Only use replacement parts recommended by Pelco. 4.
Description The EH3508/EH3512/EH3515 Series are indoor/outdoor light-duty camera enclosures designed for use with various cameras on the market and accommodate fixed focal length lenses or motorized zoom lenses, with or without auto-iris operation. The lid of the enclosure is hinged in the front providing easy access during installation and when camera/lens adjustments are necessary. The camera sled itself serves as an elevation block. You can remove, flip, and then reinstall the sled to elevate the camera.
Maintenance Regularly scheduled maintenance prolongs the operational life and appearance of the equipment. Clean the window regularly with a soft cloth using a mild, nonabrasive detergent and water to maintain picture clarity. EXPLODED ASSEMBLY AND WIRING DIAGRAMS EH3500 SERIES ENCLOSURE G Figure 1.
Table A. EH3500 Series Enclosure Exploded Assembly Parts List Item 1 2 3 4 Qty 1 2 2 1 5 6 7 Description Lid attachment pin Type E clip Gland Body 8-inch enclosure 37004001ASSY 12-inch enclosure 37004000ASSY 15-inch enclosure Bulb seal gasket 35154000ASSY 27 in. 8-inch enclosure 36 in. 12-inch enclosure 42 in.
ACCESSORIES FOR THE EH3508/EH3512/EH3515 SERIES 19 14 (3) (3) M O 22 N (1) (2) 19 19 21 J (2) P L 14 20 18 20 I 20 17 J 17 K Figure 2.
Table B.
Table C.
Table D.
0 VAC MODEL DEFROSTER INPUT, AC HIGH INPUT, AC LOW (NEUTRAL) 1 2 3 4 5 6 7 8 9 10 BLOWER (EH3512-1 AND EH3515-1 ONLY) FRONT HEATER REAR HEATER (EH3515 SERIES ONLY) 24 VAC MODEL DEFROSTER 1 2 3 4 5 6 7 8 9 10 INPUT, AC HIGH INPUT, AC LOW (NEUTRAL) RED BLK DIODE BRIDGE RED BLK BLOWER CAP (EH3512-2 AND EH3515-2 ONLY) FRONT HEATER REAR HEATER (EH3515 SERIES ONLY) 230 V AC MODEL DEFROSTER 1 2 3 4 5 6 7 8 9 10 INPUT, AC HIGH INPUT, AC LOW (NEUTRAL) RESISTOR 120 VAC BLOWER (EH3512-3 AND
EH3515 LEGACY SERIES ENCLOSURE G Figure 4. EH3515L Legacy Series Exploded Assembly Diagram Table E. EH3515L Legacy Series Exploded Assembly Parts List Item 1 2 3 4 5 6 7 8 9 10 11 12 13 NS NS NS NS A B C D E F G H NS=Not Shown C478SM-A (4/07) Qty 1 2 2 1 42 in.
ACCESSORIES FOR THE EH3515L LEGACY SERIES 19 14 (2) (2) M L (1) 19 21 J (1) 14 20 I J 17 17 K (1) USED ONLY ON MODELS EH3515L-1/-2/-3 (2) USED ONLY ON MODELS EH3515L-1HD/-2HD/-3HD Figure 5.
Table F. EH3515L Legacy Series Accessories Exploded Assembly Parts List Item I J Qty 1 120 VAC HT21-0201-0100 2 24 VAC HT02-1022-4310 K 230 VAC Defroster, continuous-duty 120 VAC HT21-1201-0100 1 24 VAC HT02-0322-4306 1 230 VAC Blower HT23-1201-0100 1 120 VAC MM750010003 1 24 VDC ED210005 1 1 4 6 6 2 4 2 230 VAC* Rear heater bracket Screw, 6-32 x 3/8-inch, Phillips, type F, pan head MM750010003 MF01-3500-018A ZH6-SFX.
Figure 6.
Figure 7. EH3515L Legacy Series Circuit Board Component Locations Figure 8.
PRODUCT WARRANTY AND RETURN INFORMATION WARRANTY Pelco will repair or replace, without charge, any merchandise proved defective in material or workmanship for a period of one year after the date of shipment. Exceptions to this warranty are as noted below: • Five years on fiber optic products and TW3000 Series unshielded twisted pair transmission products. • Three years on Spectra® IV products. • Three years on Genex® Series products (multiplexers, server, and keyboard).
Worldwide Headquarters 3500 Pelco Way Clovis, California 93612 USA USA & Canada Tel: 800/289-9100 Fax: 800/289-9150 International Tel: 1-559/292-1981 Fax: 1-559/348-1120 www.pelco.
