IntelliChlor™ Power Center IntelliChlor™ (For use with model IC20 and IC40) Installation Guide Patents pending IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS
© 2006 Pentair Water Pool and Spa, Inc. All rights reserved This document is subject to change without notice 1620 Hawkins Ave., Sanford, NC 27330 • (919) 566-8000 10951 West Los Angeles Ave., Moorpark, CA 93021 • (805) 553-5000 Trademarks and disclaimers IntelliChlor, IntelliTouch, EasyTouch and the Pentair Water Pool and Spa logo are trademarks of Pentair Water Pool and Spa, Inc.
i Contents IMPORTANT SAFETY PRECAUTIONS ....................................................................................................... ii Installation Steps Summary ........................................................................................................................ iii Technical Support ....................................................................................................................................... iii Introduction .........................................
ii IMPORTANT SAFETY PRECAUTIONS SAVE THESE INSTRUCTIONS Important Notice: Attention Installer: This manual contains important information about the installation, operation and safe use of this product. This information should be given to the owner and/or operator of this equipment. WARNING - IMPORTANT SAFETY INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK, OR INJURY TO PERSONS. READ AND FOLLOW ALL INSTRUCTIONS.
iii Declaration of Conformity We declare, under our sole responsibility, that the product identified in this declaration, and to which this declaration relates, are in conformity with the protection requirements of Council Directive 89/ 336/EEC and standards IP33 • • • Standard EN60335-1:2001, EN60529 Standard EN6100-3-2:2000, EN6100-3-3:1995 +A1:2001 Standard EN 55014-2: 1997 +A1:2001, EN 55014-1 2000 +A1, +A2 2002 Manufacturer: Pentair Water Pool and Spa, Inc.
1 Power Center Overview The IntelliChlor™ system comprises of a Power Center and electrolytic Cell. The Power Center converts AC electrical current to a low voltage DC current required by the IntelliChlor electrolytic cell to operate and create chlorine for the swimming pool and spa. The Power Center is connected with the pool circulation pump electrical source so that the electrolytic cell only operates when the pool pump is on.
2 Operating Instructions When using a pool pump timer: The Association of Pool and Spa Professionals (APSP) recommends that all water in a residential pool pass through the filtration system at least once every 12 hours (referred to as pool water turnover). However, many factors have an effect on actual pump and filter system run times.
3 Installing the Power Center Install the Power Center at eye level as close to the IntelliChlor pump and filtration as possible. CAUTION: The Power Center must be installed more than 8 ft. (2.44 m) from the pool edges. Leave sufficient clearance on all sides of the Power Center. Ensure that the 15 ft. (4.61 m) DC power cord from the Cell assembly pipe location can reach the Power Center location. The Power Center enclosure can be mounted on the wall up to 15 feet away from the cell controller.
4 Connect AC power to the Power Center: 6. Use 12-14 AWG three conductor insulated wire for the main AC power connection. Connect the Power Center to pool pump AC power source. The Power Center should be connected to the pump motor switch or automatic timer. For system wiring information, see page 6. 7. Attach incoming GROUND wire to the ground lug inside the Power Center. 8. Earth Bonding (Grounding): Connect the earth wire to the GROUND BONDING LUG located on the bottom of the Power Center enclosure.
5 Electrical Specifications and 110 VAC and 220 VAC Wiring Circuit Protection: Two-pole 20 AMP device at the electrical panel. IntelliChlor Model IC20 Input: 90-130 VAC, 50/60 Hz, 220 Watts (2 AMP) or 220-240 VAC, 50/60 Hz, 220 Watts (1 AMP). Output: 22-39 VDC @ 6 AMPS maximum from the Power Center. Chlorine: 0.70 lb. / 24 hour. (317 gm / 24 Hour). IntelliChlor Model IC40 Input: 90-130 VAC, 50/60 Hz, 220 Watts (2 AMP) or 220-240 VAC, 50/60 Hz, 220 Watts (1 AMP).
6 Notes IntelliChlor Power Center Installation Guide
LIMITED WARRANTY Pentair Water Pool and Spa, Inc. ("Pentair Water") manufactures its products with the highest standards of workmanship, using the best materials available through state of the art process. Pentair Water warrants its products as follows: Limited Warranty: Pentair Water warrants its products to be free from defects in material and/or workmanship for a period of three (3) years or 8,000 hours (parts only) from the original date of installation.
P/N 520590 - Rev C
