Instructions / Assembly

PERGO Outlast+ Install Instructions
Tools Required for Installation
Common Tools
Wood
Glue
Carbide
40T Blade
Other Tools and Supplies
M
A
D
E
I
N
T
H
E
U
S
A
1
F
L
O
Z
(
3
3
.
5
m
l
)
PREMIUM
SYSTEM
COMPONENT
S
P
E
C
I
A
L
L
Y
D
E
V
E
L
O
P
E
D
F
O
R
L
A
M
I
N
A
T
E
F
L
O
O
R
I
N
G
Finishing
Putty
PREMIUM
SYSTEM
COMPONENT
Finishing
Putty
SILICONE
CAULK
SILICONE
CAULK
SILICONE
CAULK
100% Silicone
Sealant
Felt furniture
pads
Moisture
Meter
ON
Non Destructive Moisture
dlfwej dtra
djflsv
dlfwe vtra
alskdjf
vmwjc
Concrete
Encounter
Plus
0
1
2
3
4
5
6
0
50
100
150
200
250
Moisture
Meter
S
p
a
c
e
r
s
5
m
m
S
p
a
c
e
r
s
5
m
m
Laminate floor tapping
block and 5mm (
3
/16")
spacers
10' (3 m)
> 5" (130 mm)
6 mil (0.15 mm) virgin
polyethelene vapor barrier
ground
> 8" (200 mm)
Job Site
Site Requirements
Laminate is a durable oor covering, not intended as structural material.
Laminate requires a clean, dry, secure suboor that meets building codes.
The following requirements are not intended to supersede federal, state or
local building codes, but as with many other interior nish products, may
require modifying existing structural components for successful installation.
Owner assumes responsibility for compliance with all building codes.
Laminate oor is suitable for use in climate controlled (35-65% RH and 60-
85° F) indoor installations only and should not be installed in rooms with oor
drains or sump pumps. Laminate oor can be installed above, on or below
grade.
A moisture test is strongly recommended to determine if high moisture exists
in the suboor. When using a calcium chloride moisture test for concrete
suboors (ASTM F1869), values must be ≤ 5 lbs/1000ft²/24-hr or <80% RH
with an in-situ probe (ASTM F2170). Moisture readings of wood suboors
must be ≤ 12%.
Acceptable job site conditions, including relative humidity and suboor
moisture conditions, must be maintained throughout the lifetime of the
ooring.
Laminate ooring is installed as a oating oor and requires the use of
T-moldings in doorways 4 ft (1.22m) or less and in rooms 40 feet (12.2 m) or
larger in length or width. Floor movement must not be constrained by glue,
nails, screws, hardware or other xed obstructions.
This product must be installed in accordance with these installation
instructions.
For more information, call 1-800-33-PERGO
PE Foam
Backer Rod
2020_06_OP_UNI