User guide

Fig. 1
Fig. 2
1. Masthead White
2. Port Red
3. Starboard Green
4. Stern White
5. Bi-Color Red/Green
6. Towing Yellow
63 5MM
(2.5 Inch)
Center
5MM
Diamter
Screws
Cat. No. 0170 Series Navigation Lights
For use on sail or power driven vessels under 20 meters (65.6 ft.) in
length. Note: The Bi-Color lights are certified for A-16 Replacement
Use ONLY on vessels built prior to 11/1/03.
Mounting:
A). Consider the location of the light to give:
i) Correct positioning of the light on the boat and
ii) The most convenient positions for cleaning and bulb changing.
B). Mount the red (port) and green (starboard) sidelights accurately
vertical in the same thwartship plane and at the same height
above the waterline at least one meter below the masthead light.
Installation Instructions
A). Unscrew and remove lens assembly.
B). Pierce gasket in base assembly and thread cables through.
C). Mount base assembly using only round head or pan head screws
(screw diameter 5mm or No. 10 wood screw) DO NOT use
counter sunk screws.
D). Place silicone sleeves over cables.
E). Strip cable ends and connect under clamping washers ensuring
they lie clear of the bulb.
F). Locate the lens assembly on the base. Tighten mounting screw.
Electrical Connections
Always use cable of sufficent size to ensure total voltage drop is less
than 0.5 volt for a nominal 12 volt installation or 1 volt for a nominal 24
volt installation. Recommended minimum cable size 1.5mm
2
(No.16AWG).
Bulbs
12V 10W cylindrical PERKO Cat. No. 0069DP0CLR (Stern & Towing).
12V 15W cylindrical PERKO Cat. No. 0070DP1CLR (Side, Bi, Mast).
24V 10W cylindrical PERKO Cat. No. 0067DP1CLR (Stern & Towing).
24V 18W cylindrical PERKO Cat. No. 0067DP2CLR (Side, Bi-Color
and Masthead Lights).
Cleaning
Use only fresh water and mild detergents to clean.
12/08
0170INS1
PERKO, INC.
16490 N.W. 13th Avenue
Miami, FL 33164-5707
www.perko.com
USCG APPROVAL
33 CFR 183.810
Visibility: Multiple
Tested By: IMANNA Labs.
Date: Varies
Meets ABYC A-16
0170 Series Certifications
12V 24V
Light
Color Visibility Test Date Test Date
Masthead (_M) White 3nm 1/24/03 9/25/03
Port (_P) Red 2nm 8/28/03 5/30/03
Starboard (_SD) Green 2nm 8/28/03 5/30/03
Stern (_SN) White 2nm 1/24/03 5/30/03
Towing (_TW) Yellow 2nm 11/4/03 10/14/03
Fig. 1
Fig. 2
1. Masthead White
2. Port Red
3. Starboard Green
4. Stern White
5. Bi-Color Red/Green
6. Towing Yellow
63 5MM
(2.5 Inch)
Center
5MM
Diamter
Screws
Cat. No. 0170 Series Navigation Lights
For use on sail or power driven vessels under 20 meters (65.6 ft.) in
length. Note: The Bi-Color lights are certified for A-16 Replacement
Use ONLY on vessels built prior to 11/1/03.
Mounting:
A). Consider the location of the light to give:
i) Correct positioning of the light on the boat and
ii) The most convenient positions for cleaning and bulb changing.
B). Mount the red (port) and green (starboard) sidelights accurately
vertical in the same thwartship plane and at the same height
above the waterline at least one meter below the masthead light.
Installation Instructions
A). Unscrew and remove lens assembly.
B). Pierce gasket in base assembly and thread cables through.
C). Mount base assembly using only round head or pan head screws
(screw diameter 5mm or No. 10 wood screw) DO NOT use
counter sunk screws.
D). Place silicone sleeves over cables.
E). Strip cable ends and connect under clamping washers ensuring
they lie clear of the bulb.
F). Locate the lens assembly on the base. Tighten mounting screw.
Electrical Connections
Always use cable of sufficent size to ensure total voltage drop is less
than 0.5 volt for a nominal 12 volt installation or 1 volt for a nominal 24
volt installation. Recommended minimum cable size 1.5mm
2
(No.16AWG).
Bulbs
12V 10W cylindrical PERKO Cat. No. 0069DP0CLR (Stern & Towing).
12V 15W cylindrical PERKO Cat. No. 0070DP1CLR (Side, Bi, Mast).
24V 10W cylindrical PERKO Cat. No. 0067DP1CLR (Stern & Towing).
24V 18W cylindrical PERKO Cat. No. 0067DP2CLR (Side, Bi-Color
and Masthead Lights).
Cleaning
Use only fresh water and mild detergents to clean.
12/08
0170INS1
PERKO, INC.
16490 N.W. 13th Avenue
Miami, FL 33164-5707
www.perko.com
USCG APPROVAL
33 CFR 183.810
Visibility: Multiple
Tested By: IMANNA Labs.
Date: Varies
Meets ABYC A-16
0170 Series Certifications
12V 24V
Light Color Visibility Test Date Test Date
Masthead (_M) White 3nm 1/24/03 9/25/03
Port (_P) Red 2nm 8/28/03 5/30/03
Starboard (_SD) Green 2nm 8/28/03 5/30/03
Stern (_SN) White 2nm 1/24/03 5/30/03
Towing (_TW) Yellow 2nm 11/4/03 10/14/03