OWNERS MANUAL LEGACY SERIES GAS GRILLS BIG SUR SERIES (S48R) PACIFICA SERIES (S36,S36R & S36T) NEWPORT SERIES (S27,S27R & S27T) Assembly, Operating & Maintenance Instructions LP OR NATURAL GAS PORTABLE OR MASONRY Manual Includes Instruction for PGS Grills with our without TIMERS WARNING DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open Lid. 4.
CONGRATULATIONS! You have purchased a truly exceptional outdoor cooking appliance with your Legacy Series grill from PGS. Your outdoor gas grill has been designed and constructed to give you many years of outdoor cooking enjoyment. All PGS grills are designed with quality, dependability, performance and safety features not found in any other gas grills. Please read this manual from cover to cover.
TABLE OF CONTENTS Recap of Safety Tips, Warnings and Recommendations............................................................... Page 4 & 5 Grill Model Identification ................................................................................................................ Page 6 Liquid Propane Gas Safety, Connections, Handling and Storage ................................................... Page 6 & 7 Natural Gas Pressure Requirements ................................................................
VERY IMPORTANT SAFETY TIPS AND WARNINGS At PGS, we are most concerned about the safe use of our product. The following two pages are a summarization of the safety tips found throughout this manual. Please take the time to review them, as they are critical in the enjoyable and safe use of your grill. Improper assembly, neglect, use or insufficient care of your PGS gas grill may result in serious bodily injury and/or property damage. GIVE THIS SYMBOL SPECIAL ATTENTION THROUGHOUT THIS MANUAL.
VERY IMPORTANT SAFETY TIPS AND WARNINGS CONTINUED Never move your gas grill when operating. Never move grill when HOT. Use an insulated glove when opening and operating the grill. Open grill lid slowly to allow heat and smoke to escape before fully opening. Never lean over hot grill surface or look directly into grill when attempting to light. The grill hood must be opened fully when lighting. Be sure that all family members are aware of safe lighting and operating procedures of grill.
MODEL NUMBER _______________________ PLEASE NOTE THIS SYMBOL IT DEALS WITH PRODUCT SAFETY ISSUES AND WARNINGS TYPE OF GAS _______ NAT GAS______ PROPANE SERIAL NUMBER _____________________________ DATE PURCHASED____________________________ IT IS YOUR RESPONSIBILITY TO: ASSEMBLE, INSTALL, LEAK CHECK, CARE AND OPERATE YOUR GAS GRILL. SAVE INSTRUCTIONS FOR FUTURE REFERENCE.
PLEASE NOTE. In the event that you inadvertently have the valves of your grill turned to the “ON” position, and then open the valve on top of your tank, the excess flow device will activate and shut off the flow of gas. If this should occur, turn the valves to the “OFF” position on your grill head then the valve on the tank “OFF”. Wait five minutes before attempting to light. Always turn on the valve at the top of your tank and then the valves to your grill head to the “ON” position.
Do not use in buildings, garages, sheds, breezeways or any enclosed areas. Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. SAFETY PRECAUTIONS IF YOU SMELL GAS: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid. 4. If odor continues, immediately call your gas supplier.
LP HOSE AND REGULATOR CONNECTION TO MANIFOLD 5. Place the 2 locking casters on the same end of the cart (makes no difference which) and attach to cart by inserting screw/flat washer/lock washer in each of the four pre-attached nuts. DO NOT TIGHTEN UNTIL ALL FOUR ARE STARTED. DO NOT CROSS THREAD. Screws can be tightened with an Allen-wrench, vice grips on channel locks. 6. Attach the two non-locking wheels to the other side of the cart. 7.
PROPANE CYLINDER CONNECTION L.P. cylinder is connected to grill via a hand wheel. When full, cylinder weighs nearly 42 pounds to handle with care. Place cylinder in retaining ring and tighten screw on ring to secure tank. Place LP Regulator hand wheel in LP tank outlet, tighten hand wheel. Manual Lighting of Grill NOTE: If grill is hot, manual lighting tube may not work. Allow grill to fully cool before relighting.
After cleaning burner assembly and the lower housing of grill, reinstall burner. TURN YOUR GAS SUPPLY (LP OR NAT) ON AND TEST ALL FITTINGS FOR LEAKS. BEFORE ATTEMPTING TO LIGHT GRILL, BE CERTAIN BOTH VALVES ARE IN THE OFF POSITION. TURN GAS SUPPLY ON (leaving both control knobs to the "OFF" position). CHECK ALL CONNECTIONS WITH A SOLUTION OF 50% LIQUID SOAP, 50% WATER. SOLUTION CAN BE SPRAYED ON WITH A SPRAY BOTTLE OR PAINTED ON ALL CONNECTIONS WITH A BRUSH.
BEFORE CALLING FOR SERVICE/TROUBLESHOOTING CHECKLIST environment. The most common source of such particles is from "wire-wool" scouring pads, but contamination may also occur from carbon steel utensils and cast iron water supply pipes. These brown marks are only superficial stains, which will not harm the Grill; they should be removable using a soft damp cloth and a quality stainless cleaner.
FLAME ADJUSTMENT Please check our website: www.aeicorporation.com for more ideas. If installing LP grill in masonry island, we recommend Propane Cylinder be securely mounted OUTSIDE island with rigid, secured pipe and connections. Connectors must comply with ANZI Z21.75/CSA 6.27 and must be suitable for outside installations. Maximum length on the connections shall be 6’. Maximum pressure when using propane to fuel grill is 11.0”w.c..
4. Reinstall burner and light as normal and inspect flame. If burner requires additional adjustment repeat above procedure. There is not a significant degree of adjustment required to these burners. REPLACEMENT PARTS USE ONLY PGS ORIGINAL REPLACEMENT PARTS AVAILABLE THROUGH YOUR DEALER OR CONTACT AEI CORPORATION FOR CLOSEST PARTS SUPPLIER.
T Series Grills PGS offers LEGACY series grills with a built-in ONE HOUR FLOW timer that will automatically shut the gas flow supply off at a maximum of one hour. The TIMER grills (T Series) were specifically designed for added safety, convenience and energy saving for home owners and commercial users alike. Shown: S27T and MDS L30 Doors in Masonry Surround Two models are available with the timer in the LEGACY series: S27T and S36T available in Natural Gas or Propane Fuels.
PACIFIC GAS SPECIALTIES COOKING TIPS AND TEMPERATURE GUIDE our recipes might be a bit low. higher setting to compensate. climates or on windless days. "doneness" will also allow you process. Cooking outdoors has truly come of age in America. What was once a frustrating experience, pitting the weekend chef against a raging charcoal inferno has evolved into an enjoyable culinary experience. Outdoor cooking has no equal in terms of flexibility, flavor, creativity or exciting presentations.
HEAT OUTPUT VARIATIONS INDIRECT COOKING No two gas grills will perform exactly the same way. The fuel source, line pressure or volume, method of installation, wind and weather conditions all contribute to influencing heat output and control. Irrespective of the cooking appliance cooking will always be more art than pure science. You can bake or roast foods in your PGS grill just like you would in a conventional oven. Casseroles, whole poultry, breads, and cakes can be cooked using this indirect method.
You can save on the calories by carefully selecting the cuts of meat that you cook on your grill. Cuts should be as fat free as possible and carefully trimmed if calorie counting and cholesterol reduction are objectives. Skinless chicken breasts are low in calories, as is most seafood... both taste GREAT cooked on the grill. A little bit of pre-planning along with taking full advantage of natural flavoring possibilities will allow the dieter to join right in with the rest of the gang at barbecue time.
When you believe the beef is finished you can use the touch test described earlier in this section. Four 1 1/2 inch steaks should take approximately 22-28 minutes cooked on MEDIUM and then LO. Again, cooking results will vary according to the individual grill, location, weather conditions, gas pressure, and other factors. Use oil or a marinade on roasts to help seal the meat surfaces and hold in the juices. Use a foil drip pan when cooking meats with a heavy fat content.
any strain on the rotis motor. Balancing the cut of meats that you are rotissing will increase the life of the motor. Brush the outside of the chicken with olive oil and sprinkle salt, pepper, and paprika. You can also try your favorite seasoning salt. Cook at the low heat setting for 40 to 50 minutes. For consistent results use a meat probe thermometer for accuracy and degree of doneness. Insert a drip pan halfway through the cooking process and baste with your favorite BARBECUE or cooking sauce.
mind that several factors such as outdoor temperature conditions, wind, humidity, altitude, size, quality and thickness of meat can influence results. Your PGS outdoor gas grill is a fun and exciting product that welcomes your involvement and creativity. Only your imagination will limit what your grill can cook! POULTRY COOKING GUIDE (Grill Preheated 5-10 Minutes) Poultry, unlike beef, requires that meat be fully cooked. poultry to insure proper doneness.
PACIFIC GAS SPECIALTIES Legacy Grill Series Warranty PLEASE NOTE: ENCLOSED WARRANTY REGISTRATION CARD MUST BE RETURNED TO PGS FOR WARRANTY TO BE IN PLACE. PGS WILL NOT USE WARRANTY INFORMATION FOR ANY PURPOSE OTHER THAN INTERNAL REGISTRATION OR BULLETINS REGARDING PRODUCT IMPROVEMENTS. PGS gas grills are made of the finest materials available and are designed to provide you and your family great outdoor cooking events. The Warranty Information below applies to residential use only.
PGS GRILLS BY AEI CORPORATION 2641 Du Bridge Ave. P.O. BOX 16097 IRVINE, CA.
PLEASE NOTE: TO INSURE WARRANTY REGISTRATION, PLEASE FILL OUT WARRANTY CARD BELOW AND RETURN MAIL. WILL NOT SELL OR USE OWNER INFORMATION FOR MARKETING PURPOSES. PGS If you would like, you can fax this to us at 949 474-0559 or e-mail it to info@aeicorporation.com GAS GRILL WARRANTY REGISTRATION IMPORTANT: Please fill out this Warranty Registration within 10 days of purchase. Thank you for purchasing a Pacific Gas Specialties gas grill.
KEY# DESCRIPTION S27(T) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 19 19 20 20 LID HANDLE HANDLE BRACKET 1.25" SPACER FOR 1.
PGS GRILLS by AEI CORPORATION 2641 Du Bridge Ave. P. O. BOX 16097 IRVINE, CA 92623-6097 PH (949) 474-3070 FAX (949) 474-0559 Email: info@aeicorporation.
