Colour Television Chassis TE3.2E CA G_16010_000.eps 260406 Contents Page 1. Technical Specifications, Connections and Chassis Overview 2 2. Safety Instructions, Warnings, and Notes 5 3. Directions for Use 7 4. Mechanical Instructions 8 5. Service Modes, Error Codes and Fault Finding 9 6. Block Diagrams, Test Point Overviews, and Waveforms Block Diagram Audio / Video 11 Block Diagram Power Supply 12 I2C Diagram 13 Block Diagram 13 7.
EN 2 1. Technical Specifications, Connections and Chassis Overview TE3.2E CA 1. Technical Specifications, Connections and Chassis Overview 1.2.2 Index of this chapter: 1.1 Technical Specifications 1.2 Connections / Control Facilities 1.3 Chassis Overview 1.1 Technical Specifications 1.1.
Technical Specifications, Connections and Chassis Overview 1.2.3 Rear Connections 21PT5421 only 75 Ohm G_16010_040.eps 260406 Figure 1-5 Rear Connections 1.2.4 TV Aerial In Aerial input TE3.2E CA 8 - CVBS - status 9 10 11 12 13 14 15 16 17 18 19 20 21 - Green - gnd - n.c. - n.c. - n.c. - Red - gnd - FBL - gnd - YC-C - in - n.c. - Video - Video - CVBS - out - Y/CVBS - in - Shielding 1. 0 - 2 V: INT 4.5 - 7 V: EXT 16:9 9.5 - 12 V: EXT 4:3 Ground EN 3 H Ground Ground 0.
EN 4 1.3 A6 1. TE3.2E CA Technical Specifications, Connections and Chassis Overview Chassis Overview CRT PANEL MAIN CHASSIS PANEL MCU A1 VIDEO A2 SOUND A3 POWER A4 DEFLECTION A5 SCART A7 G_16010_042.eps 260406 Figure 1-8 Chassis Overview 14” & 21” A6 CRT PANEL A8 SIDE I/O PANEL MAIN CHASSIS PANEL MCU A1 VIDEO A2 SOUND A3 POWER A4 DEFLECTION A5 SCART A7 G_16010_043.
Safety Instructions, Warnings, and Notes TE3.2E CA 2. EN 5 2. Safety Instructions, Warnings, and Notes 1. Perform the “general repair instruction” noted above. 2. Clean the power supply and deflection circuitry on the chassis. 3. Clean the picture tube panel and the neck of the picture tube. Index of this chapter: 2.1 Safety Instructions 2.2 Maintenance Instructions 2.3 Warnings 2.4 Notes 2.1 Safety Instructions 2.
EN 6 2. TE3.2E CA Safety Instructions, Warnings, and Notes semiconductors in the unit, irrespective of the type indication on these semiconductors. 2.4.2 Schematic Notes • • • • • • 2.4.3 All resistor values are in ohms, and the value multiplier is often used to indicate the decimal point location (e.g. 2K2 indicates 2.2 kohm). Resistor values with no multiplier may be indicated with either an "E" or an "R" (e.g. 220E or 220R indicates 220 ohm).
Directions for Use • 2.4.5 3. Directions for Use You can download this information from the following websites: http://www.philips.com/support http://www.p4c.philips.com EN 7 Practical Service Precautions • • Caution: For BGA-ICs, you must use the correct temperatureprofile, which is coupled to the 12NC. For an overview of these profiles, visit the website www.atyourservice.ce.philips.com (needs subscription, but is not available for all regions) 3.
EN 8 4. TE3.2E CA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: 4.1 Rear Cover Removal 4.2 Service Position Main Panel 4.3 Rear Cover Mounting Note: Figures below can deviate slightly from the actual situation, due to the different set executions. 4.1 Rear Cover Removal • • 4.2 Service Position Main Panel • • • • 4.3 Remove all (ten) fixation screws of the rear cover: two at the top, two at each side, three at the bottom and one in the middle of the rear cover.
Service Modes, Error Codes and Fault Finding TE3.2E CA 5. EN 9 5. Service Modes, Error Codes and Fault Finding Index of this chapter: 5.1 Service Modes 5.2 Fault Tracing Diagram for Power Supply 5.1 Service Modes The Service Mode offers features, which the service technician can use to repair a set. Any feature change, made via the Service Menu, will respond at the same time. All displayed text strings in the Service Modes are in English. 5.1.1 TV Service Mode Purpose • To perform alignments (e.g.
EN 10 5.2 5. TE3.2E CA Service Modes, Error Codes and Fault Finding Fault Tracing Diagram for Power Supply D100,101 D102,103 R100, C106, YES G_16010_013.
Service Modes, Error Codes and Fault Finding TE3.2E CA 5. EN 11 Table 5-1 Diversity between Main Board 05TA085-5 and 05TA085-6 Component Pos.
EN 12 5. TE3.2E CA Service Modes, Error Codes and Fault Finding Personal Notes: E_06532_012.
Block Diagrams, Test Point Overviews, and Waveforms TE3.2E CA 6. EN 13 6. Block Diagrams, Test Point Overviews, and Waveforms Block Diagram Audio / Video G_16010_015.
Block Diagrams, Test Point Overviews, and Waveforms TE3.2E CA 6. EN 14 Block Diagram Power Supply G_16010_016.
Block Diagrams, Test Point Overviews, and Waveforms TE3.2E CA 6. I2C Diagram Block Diagram A2 TUNER CTF5540 EN 15 A1 5 R241 4 R242 SD A SD A SD A SCL SCL SCL R340 R339 51 52 VI D EO PROC. STV2 2 4 8 R241 R242 6 5 EEPROM 2 4 C1 6 20 19 M CU ST9 2 1 9 5 G_16010_017.eps 130206 G_16010_018.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 16 7. Circuit Diagrams and PWB Layouts Main Panel (05TA085-5): MCU 1 A1 2 3 4 5 6 8 7 MCU A1 D D 1 5VD I201 5VD R222 10K TSOP34386 J933 SCL 7 BC848 R231 R232 220R 0R 2 R205 1 220R J810 C202 R203 10uF 220R 3 P2.1/INT5/AIN1 RESET P2.2/INT0/AIN2 C223 10NF KEYB 56 R238 R239 820R R234 470R 560R 1K5 B200 C+ 55 5 R204 220R P0.7 P2.3/INT6/VS1 P0.6 P2.4/NMI 6 5V R221 7 1K AV_ST. 8 10 J802 R213 4.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 17 Main Panel (05TA085-5): Video 1 A2 2 3 4 5 6 8 7 VIDEO A2 8V J878 L323 10uH C311 100nF D R323 10K R324 10K R367 6.8K D F302 K9453 D316 D311 D303 R356 ICATH BCLG R337 47K IF1 IF1 C312 N.U. 2 4 T304 BC848 10K BAT85 1nF BA282 D317 R350 BA282 C304 100nF 68K L/L' J873 L/L' 22K R368 3 7.5V C362 1 5 J908 BCLG T305 BC848 T306 BC848 R369 2.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 18 Main Panel (05TA085-5): Sound 1 A3 2 3 4 5 6 8 7 SOUND A3 R402 J930 SDA 8 45 AVSS I2C_DA C413 10uF C402 100nF 1R 2.2R 12 13 14 C 15 I2S_WS VREFTOP I2S_DA_OUT 330nF ADA_DA ADA_WS ADA_CL C437 3.3uF 43 SC2_IN_R SC2_IN_L 16 C416 10uF 17 C428 330nF R2_IN 39 C427 330nF L2_IN 19 5V R409 20 21 22 23 TV_S/L TV_S/R TV_S/L R425 24 100R 1uF R426 C441 25 100R 26 B C422 1nF 1nF OUT- N.C.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 19 Main Panel (05TA085-5): Power 1 2 3 4 5 6 8 7 POWER A4 A4 D D L102 100uF/400 FB. S101 POWER CON J109 R101 2 * D111 BYV36C C103 2.2nF 12 FB BYV36C C106 1 N.U. 2 NC VCC * C108 * 3 C109 * 4 PCS RZI OUT ICE1QS01 GND SRC OFC L105 FB 390K C115 T101 * 8 100N C107 2 N.U. 7 R110 10R 6 C116 56P 5 1 C117 33uF R112 ! D105 R102 * * R103 * R104 * V100 * 13 D109 * * 47K R113 11 16 15 6 * C118 N.U.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 20 Main Panel (05TA085-5): Deflection 1 A5 2 3 4 5 6 8 7 DEFLECTION A5 D D D604 J601 * BYV36C 5.6K 3W D601 * 1 10R C607 VC V_OSD VERT 9 R601 100R C602 47nF R604 3K3 VERTJ893 R615 1K C603 100uF HOUT 10K R606 10K R607 2R2 T600 R609 220R BC337 R610 T601 R613 1K5 J890 100nF D606 LS4148 N.U.
Circuit Diagrams and PWB Layouts TE3.2E CA 7.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 22 Main Panel (05TA085-5): SCART 1 A7 2 3 4 5 6 8 7 SCART A7 8V C701 D FAV_AUD 3K3 1uF R761 R762 12K 4K7 J888 EXT_AUD J705 D701 FAV_AUD R701 LS4148 8V R711 8K2 R758 6K8 R760 R713 8K2 10R D702 * R759 T710 BC848 R763 2K2 R766 * 6K8 AV1/AV2 D EXT_AUD N.U. 8V MONO APPLICATIONS R764 680R R712 AV1/AV2 J889 R708 3.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 23 Layout Main Panel (05TA085-5) (Top Side) 05TA085-5 G_16010_008.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 24 Layout Main Panel (05TA085-5) (Bottom Side) 05TA085-5 G_16010_009.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 25 Main Panel (05TA085-6): MCU 1 A1 2 3 4 5 6 8 7 MCU A1 D D 5VD 5VD 1 I201 5VD R222 10K 3 R206 1K5 TSOP2236 J933 SCL BC848 R231 R232 220R 0R 2 R205 1 0R 2 R203 C202 10uF 220R 3 RESET P2.2/INT0/AIN2 56 C223 10NF KEYB R238 R239 560R 1K5 B200 C+ 55 T200 BC858 2.7V 5 R204 220R 6 5VM R221 7 AV_ST. 8 P0.7 P2.3/INT6/VS1 P0.6 P2.4/NMI R213 4.7K B_OSD G_OSD R_OSD FB_OSD SDA B SCL R210 4.7K R211 4.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 26 Main Panel (05TA085-6): Video 1 A2 2 3 4 5 6 8 7 VIDEO A2 8V J878 L323 10uH C311 100nF D R323 10K R324 10K R367 6.8K D F302 K9453 D316 5 J908 BCLG D311 D303 R356 ICATH 4 T304 BC848 10K BAT85 R337 47K 1nF BA282 D317 IF1 IF1 C312 N.U. 2 R350 BA282 C304 100nF J951 68K J873 L/L' L/L' 22K R368 3 7.5V C362 1 BCLG T305 BC848 T306 BC848 J947 R369 2.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 27 Main Panel (05TA085-6): Sound 1 A3 2 3 4 5 6 8 7 SOUND A3 2 3 AUD_OL_OUT XTAL _IN D_CTH_OUT1 TESTEN D_CTR_OUT0 ANA_IN2+ N.C. OUT- GND2 OUT+ VCNT GND1 9 8 7 6 5 D 4W MONO AM PLIFIER C411 2.2pF 50 4 X401 18.432Mhz 51 3 52 XTAL _OUT 2 NC 1 D VI N N.C. I401 1 VSUP I402 * C412 2.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 28 Main Panel (05TA085-6): Power 1 2 3 4 5 6 8 7 POWER A4 A4 D D 1N5062 DSP J109 D111 BYV36C C106 1 N.U. D124 N.U. C121 220P 2 * C108 * 3 L106 12 FB VCC 8 PCS RZI OUT ICE1QS01 GND 7 R110 10R 6 4 SRC OFC ! D105 R102 * * R103 * R104 * V100 * 56P 2 9 BYV36C * 7 D106 * 47K R113 * C118 N.U. 6 O100 R114 N.U. * D107 R118 5 * 4 6.5V 1 5 2 4 3 2 6 D121 * 1 4 5 2 4 3 21" CPT COMP.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 29 Main Panel (05TA085-6): Deflection 1 A5 2 3 4 5 6 8 7 DEFLECTION A5 D D D604 J601 * BYV36C L600 R633 5.6K 3W D601 * C607 VC V_OSD VERT 9 R601 100R V_OSD 47nF R604 3K3 VERTJ893 R608 33K 10K R606 10K T600 R609 220R BC337 R610 T601 C610 C603 100uF ** HOUT J890 100nF D606 LS4148 1N4007 N.U.
Circuit Diagrams and PWB Layouts TE3.2E CA 7.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 31 Main Panel (05TA085-6): SCART 1 A7 2 3 4 5 6 8 7 SCART A7 8V C701 D FAV_AUD 3K3 1uF R761 R762 12K 4K7 J888 EXT_AUD J705 D701 FAV_AUD R701 LS4148 8V R711 8K2 R758 6K8 8V R713 8K2 R766 * 6K8 AV1/AV2 J889 R708 10R D702 * R759 AV1/AV2 D EXT_AUD N.U. R760 T710 BC848 R763 2K2 MONO APPLICATIONS R764 680R R712 10K 3.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 32 Layout Main Panel (05TA085-6) (Top Side) 05TA085-6 G_16010_036.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 33 Layout Main Panel (05TA085-6) (Bottom Side) 05TA085-6 G_16010_037.
Circuit Diagrams and PWB Layouts TE3.2E CA 7.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 35 Layout Side I/O Panel (Top Side) (21PT5421 only) 05TA026E Personal Notes: G_16010_039.eps 240406 E_06532_012.
Circuit Diagrams and PWB Layouts TE3.2E CA 7. EN 36 Personal Notes: E_06532_013.
Alignments TE3.2E CA 8. EN 37 8. Alignments b6: 1: East Europe available; 0: East Europe not available b7: 1: EXT2 available; 0: EXT2 not available Index of this chapter: 8.1 Hardware Alignments 8.2 Software Alignments/Settings 8.1 Hardware Alignments 8.1.1 System Voltage Adjustment • • 8.
EN 38 8. TE3.2E CA Alignments • • Enter the Service Mode and select the GEOMETRY settings. VS, VP and HP settings carry out standard geometry adjustments. 1. Apply a 'dark grey' pattern (at 10 IRE). 2. Set CONTRAST to 70% and BRIGHTNESS and COLOUR SATURATION in the middle. 3.
Circuit Descriptions, Abbreviation List, and IC Data Sheets TE3.2E CA 9. EN 39 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets • Index of this chapter: 9.1 Basic Hardware Descriptions 9.2 Functional Description 9.3 Abbreviation List 9.1 Basic Hardware Descriptions 9.1.1 ST92195C/D Microcontroller General Features • Register File based 8/16 bit Core Architecture with RUN, WFI, SLOW, HALT modes • 00 to +700C operating temperature range • Up to 24MHz. operation @ 5V (10%) • Min.
EN 40 • • • • • • • • • • • • • • • • • 9.1.3 TE3.
Circuit Descriptions, Abbreviation List, and IC Data Sheets • Table 9-2 Smart Picture Mode Settings BrightColor ness Colour Contrast Sharpness Temp NR Contrast+ Rich 59% 59% 92% 87% Cool OFF ON Natural 58% 56% 86% 71% Normal OFF ON Soft 43% 48% 83% 87% Normal ON OFF Multimedia 50% 54% 95% 81% Normal OFF ON 9.2.6 TE3.2E CA 9. EN 41 It takes 3 seconds for the changes on Picture or Sound settings to be stored into NVM.
EN 42 9.3 9. TE3.
Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4 TE3.2E CA IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs). 9.4.
EN 44 Circuit Descriptions, Abbreviation List, and IC Data Sheets TE3.2E CA Diagram A1, ST92195CD (IC I200) Block Diagram Up to 96 Kbytes ROM 256 or 512 bytes RAM Up to 8 Kbytes TRI TDSRAM MEMORY BUS 256 bytes Register File 8/16-bit CPU I/O PORT 0 8 P0[7:0] I/O PORT 2 6 P2[5:0] I/O PORT 3 4 P3[7:4] I/O PORT 4 8 P4[7:0] I/O PORT 5 2 P5[1:0] MMU NMI INT[7:4] INT2 INT0 DATA SLICER & ACQUISITION UNIT Interrupt Management ST9+ CORE OSCIN OSCOUT RESET RESETO SDO/SDI SCK RCCU SYNC.
Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.3 TE3.2E CA 9.
EN 46 9.4.4 9. TE3.2E CA Circuit Descriptions, Abbreviation List, and IC Data Sheets Diagram A3, TDA2822 (IC I404) Block Diagram Pin Configuration / Connection Diagrams G_16010_026.
Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.5 TE3.2E CA Diagram A4, IC1QS01 (IC I100) Block Diagram VCC 20V Foldback Point Corr. - Overvoltage Protection + PCS UVLO + - + SRC + Burst-Mode 1.5V Reference Voltage and Current + 5V 2V + - 1V Ringing Suppression Time + 20k + 4.4V - Start 5V + 3.5V - 50µs Timer Latch 50ms Timer Primary Regulation 25mV + RZI 5V 4.8V - Digital Processing - ZC-Counter UP/DO-Counter 5.
EN 48 9.4.6 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets TE3.
Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.7 TE3.2E CA Diagram A4, LM7805 (IC I104) Block Diagram Pin Configuration / Connection Diagrams G_16010_022.eps 130206 Figure 9-7 Internal block diagram and pin configuration 9.
EN 50 9.4.8 9. TE3.2E CA Circuit Descriptions, Abbreviation List, and IC Data Sheets Diagram A5, TDA1771 (IC I600) Block Diagram 9 2 VOLTAGE REGULATOR FLYBACK GENERATOR 10 R3 TRIGGER IN 3 CLOCK PULSE RAMP GENERATOR POWER AMP. BUFFER STAGE 4 6 1 THERMAL PROTECTION 7 8 5 Pin Configuration / Connection Diagrams 10 9 8 7 6 5 4 3 2 1 FLYBACK GENERATOR VS INVERTING INPUT BUFFER OUTPUT RAMP GENERATOR GROUND HEIGHT ADJUSTMENT TRIGGER INPUT OUTPUT STAGE V S POWER OUTPUT G_16010_025.
Spare Parts List TE3.2E CA 10. 10. Spare Parts List Table 10-1 14PT1501/12 Pos Pos 12NC Code Description C212 040031042261 CAP CER 22PF 50V 5% COG 0603 CER2 0603 X7R 50V 2N2 COL R 12NC Code Description C213 482212614238 002013202630 CABLE 2P*1SKT 20CM MINI C214 482212614238 CER2 0603 X7R 50V 2N2 COL R 002528554101 CABLE POW FLTLI7.
EN 52 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description C373 042194504751 CAP ELECT 4.7MF 50V 20% D112 482213042606 BYD33J C375 482212613883 220PF 5% 50V D114 482213042606 BYD33J C440 042416501051 CAP ELECT 1MF 50V 20% D116 482213041602 BYW95C C443 042446502251 CAP ELECT 2.2MF 50V 20% D117 048321423201 DIODE RECT.1N4007 DO-41 C444 042446502251 CAP ELECT 2.2MF 50V 20% D120 048540146001 DIODE ZNR.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description L108 032040555211 RESS.W.W 5.6R 5W 10%VERCM SFTY R216 482205130472 4K70 L109 608000000221 COIL 10UH 5% 0.41A AXIAL FIXED R217 482205130561 560R00 5% 0,062W L110 608000000221 COIL 10UH 5% 0.41A AXIAL FIXED R218 482205130561 560R00 5% 0,062W L301 608780002411 COIL FILTER 3.5*9*0.8 F.
EN 54 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description R373 482205130103 10K00 5% 0,062W R623 030055722811 RESISTOR FUSIBLE 0.22R 1/2W 5% R374 482205130563 56K00 5% 0,062W R624 030020675011 RESISTOR C.F 75R 1/4W 5% R375 482205130271 270R00 5% 0,062W R625 482211712925 47K 1% 0.063W 0603 R376 482205130271 270R00 5% 0,062W R626 482211712925 47K 1% 0.063W 0603 R377 482205130271 270R00 5% 0,062W R627 030020656131 RESISTOR C.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description T503 482213041782 BF422 C137 042410252281 CAP ELECT 2200MF 25V 20% T504 482213041782 BF422 C141 042416501051 CAP ELECT 1MF 50V 20% T505 482213041646 BF423 C142 042416503361 CAP ELECT 33MF 50V 20% T506 482213041782 BF422 C143 042446862251 CAP ELECT 2.2MF 250V 20% T507 482213041646 BF423 C144 042033911011 CAP ELECT 3.
EN 56 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description C356 042416501051 CAP ELECT 1MF 50V 20% C621 040040042231 CAP CER 2.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description I103 045000003631 IC ICE1QS01 R113 482205130682 6K80 I104 045000004131 IC ST92195C7B1 R114 030010683461 RESISTOR C.F 2.2R 1/10W5% 0603 I200 045238103051 IC LM317 1.5A ADJ V REG TO-220 R115 030208627311 RESISTOR M.O 27K 2W 5% I201 045000002291 IC STV2248E PAL/NTSC/SECAMPROG R120 030050622111 RESISTOR C.
EN 58 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description R324 482205130103 10K00 5% 0,062W R516 482205130561 560R00 R325 482205130103 10K00 5% 0,062W R517 030050639311 RESISTOR C.F 39R 1/4W R326 482205130103 10K00 5% 0,062W R518 030050715221 RES. C. COMP 1.5K 1/2W R327 482205130103 10K00 5% 0,062W R519 030050715221 RES. C. COMP 1.5K 1/2W R328 030010627261 RESISTOR C.F 2.7K 1/10W5% 0603 R520 030020610511 RESISTOR C.
Spare Parts List Pos TE3.2E CA 10. EN 59 Pos 12NC Code Description 12NC Code Description R758 482205130682 6K80 5% 0,062W 036016010071 FERRIT RING U5 T 31X7X19 R759 482205130682 6K80 5% 0,062W 067310001831 FUSE2.5A250V5X20MM TIME-LAGSFT R760 482205130109 10R00 067600002181 "ANTENNA ROD 14""" R761 030010612261 RESISTOR C.F 1.2K 1/10W5% 0603 070362110151 A33EKC02X01 R762 482205130472 4K70 075110211070 FUSE HOLDER GREY TK79/A2.
EN 60 10. TE3.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description D125 048000000031 DIODE RECT.SS13 L301 608780002411 COIL FILTER 3.5*9*0.8 F.BEAD D200 048773809001 DIODE LED KLR114L RED 5MM L302 036070204111 FERRIT BEAD LI0805H151R-00 SMD D201 048100000041 DIODE ZNR.
EN 62 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description R213 482205130472 4K70 5% 0,062W R370 482205130222 2K20 R214 482205130472 4K70 5% 0,062W R371 482205130153 15K00 R215 482205130472 4K70 5% 0,062W R372 030010682261 RESISTOR C.F 8.
Spare Parts List TE3.2E CA Pos 12NC Code Description Pos 12NC Code Description R618 532211713042 3K9 1% 0.063W 0603 RC22H T201 046848000001 TRS.BC848B SOT-23 10. R619 030010612261 RESISTOR C.F 1.2K 1/10W5% 0603 T202 046848000001 TRS.BC848B SOT-23 R620 030010612161 RESISTOR C.F 120R 1/10W5% 0603 T303 046848000001 TRS.BC848B SOT-23 R621 030025601011 RESISTOR FUSIBLE 1R 1/4W 5% T304 046848000001 TRS.
EN 64 10. TE3.
Spare Parts List TE3.2E CA Pos 12NC Code Description Pos 12NC Code Description C609 620004001051 CAP MKT 10NF 50V D502 482213030842 BAV21 C610 040031042261 CAP CER 22PF 50V 5% COG 0603 D503 482213030842 BAV21 C611 618014011161 CAP MKT 100NF 50V 5% D504 482213031983 BAT85 10. C612 618014011161 CAP MKT 100NF 50V 5% D505 482213034382 BZX79-B8V2 C613 620013081041 CAP MKT 100NF 63V 5% 5MM D506 048321423201 DIODE RECT.
EN 66 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description L411 036070204111 FERRIT BEAD LI0805H151R-00 SMD R214 482205130472 4K70 5% 0,062W L412 036070204111 FERRIT BEAD LI0805H151R-00 SMD R215 482205130472 4K70 5% 0,062W L413 036070204111 FERRIT BEAD LI0805H151R-00 SMD R216 482205130472 4K70 5% 0,062W L600 608980004201 COIL LINEARITY 200UH PT190R R217 482205130561 560R00 5% 0,062W L601 608380002721 COIL CHOKE 56UH 15% 0.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code R370 482205130222 2K20 R616 030050610211 RESISTOR C.F 1K 1/2W 5% R371 482205130153 15K00 R617 030010624261 RESISTOR C.F 2.4K 1/10W5% 0603 R372 030010682261 RESISTOR C.F 8.2K 1/10W5% 0603 R618 482205130332 3K30 R373 482205130222 2K20 R619 030010612261 RESISTOR C.F 1.2K 1/10W5% 0603 5% 0,062W 5% 0,062W 5% 0,062W Description 5% 0,062W R374 482205130563 56K00 5% 0,062W R620 030010612161 RESISTOR C.
EN 68 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description T101 046933000151 TRS. STP10NK60ZFP C104 620004062241 CAP MKT220NF275VAC20%RFIX2 SFT T102 482213040959 BC547B C105 620004062241 CAP MKT220NF275VAC20%RFIX2 SFT T104 046848000001 TRS.BC848B SOT-23 C107 040052044861 CAP CER 470PF 50V 5% COG 0603 T105 046848000001 TRS.BC848B SOT-23 C108 040742041061 CAP CER 10PF 50V 5% COG 0603 T106 046848000001 TRS.
Spare Parts List TE3.2E CA 10.
EN 70 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code D106 048110411111 DIODE LS4148 SOD80 QMELF J934 040742022261 Description CAP CER 22NF 50V 5% X7R 0603 D107 048110411111 DIODE LS4148 SOD80 QMELF K401 841140010059 COMP.CABLE 5P*2SKT45CMBRDEHFE D108 048110411111 DIODE LS4148 SOD80 QMELF K901 075030211091 CONN.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description R126 482205130223 22K00 5% 0,062W R329 482205130273 27K00 5% 0,062W R127 030020622331 RESISTOR C.F 22K 1/4W 5% R330 482205130273 27K00 5% 0,062W R128 030010682161 RESISTOR C.F 820R 1/10W5% 0603 R331 482205130101 100R00 5% 0,062W R129 482205130102 1K00 R332 482205130101 100R00 5% 0,062W R130 482205130184 180K00 R337 482211712925 47K 1% 0.063W 0603 R131 030010627261 RESISTOR C.F 2.
EN 72 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description R522 030050715221 RES. C. COMP 1.5K 1/2W S506 075020800031 SOCKET CRTNARROW NECK29MM SFTY R525 030010600081 RESISTOR C.F 0R 1/8W 5% 0805 S507 002020511160 CBLE DBLE TERM.BLACK(SYH)30CM R527 030010600081 RESISTOR C.F 0R 1/8W 5% 0805 S600 002344350250 CABLE VERTICAL BASKILI 45CM R529 030010600081 RESISTOR C.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description 3501 030050633611 RESISTOR MGL 3.3M1/2W5%SFTVR37 C212 040031042261 CAP CER 22PF 50V 5% COG 0603 6005 482213031983 BAT85 C213 482212614238 CER2 0603 X7R 50V 2N2 COL R 002528554011 CABLE POWER P 2X500UH220CM C214 482212614238 CER2 0603 X7R 50V 2N2 COL R 002740010390 CABLE 5P*2SKT.BRD/EH BLACK45CM C215 482212613193 4,7NF10% X7R 63V 005007000240 PAINTED MUL.
EN 74 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description C404 040067141061 CAP CER 100NF 50V 10% X7R 0603 C621 040040046821 CAP CER 680PF 2KV 5% 7.5MM C405 040067141061 CAP CER 100NF 50V 10% X7R 0603 C622 042033911011 CAP ELECT 3.3MF 250V C406 040067141061 CAP CER 100NF 50V 10% X7R 0603 C623 620004028041 CAP MKP 280NF 250V 5% 15MM C407 040067141061 CAP CER 100NF 50V 10% X7R 0603 C624 040050151011 CAP CER 100PF 1KVAC P7.
Spare Parts List TE3.2E CA 10. Pos 12NC Code Description Pos 12NC Code Description D600 048321423201 DIODE RECT.1N4007 DO-41 L706 036070204111 FERRIT BEAD LI0805H151R-00 SMD D601 482213041487 BYV95C L707 608980000101 COIL 12UH 5% 0.15A AXIAL FIXED D602 482213041487 BYV95C L708 608980000101 COIL 12UH 5% 0.15A AXIAL FIXED D603 482213041487 BYV95C L709 608980000101 COIL 12UH 5% 0.15A AXIAL FIXED D604 482213041487 BYV95C L710 608980000101 COIL 12UH 5% 0.
EN 76 10. TE3.2E CA Spare Parts List Pos 12NC Code Description Pos 12NC Code Description R218 482205130561 560R00 5% 0,062W R412 482205130223 22K00 R219 482205130561 560R00 5% 0,062W R413 030010683061 RESISTOR C.F 2K 1/10W5% 0603 R220 482205130561 560R00 5% 0,062W R414 030010683061 RESISTOR C.F 2K 1/10W5% 0603 R221 482205130102 1K00 R415 030010612261 RESISTOR C.F 1.
Spare Parts List TE3.2E CA Pos 12NC Code Description Pos 12NC Code Description R640 030020620211 RESISTOR C.F 2K 1/4W 5% T106 046848000001 TRS.BC848B SOT-23 R641 482205130223 22K00 5% 0,062W T107 046000000131 TRS. POW BD135 R702 482205130103 10K00 5% 0,062W T200 046858000001 TRS.BC858 BP R703 482205130123 12K00 5% 0,062W T201 046848000001 TRS.BC848B SOT-23 5% 0,062W 10. R704 482205130123 12K00 T202 046848000001 TRS.BC848B SOT-23 R705 030010682261 RESISTOR C.F 8.
EN 78 11. TE3.2E CA Revision List 11. Revision List 11.1 Manual xxxx xxx xxxxx.0 • First release. 11.2 Manual xxxx xxx xxxxx.1 • • • • Chapter 1: 21PT5421 information added. Chapter 5: Main Board diversity table added. Chapter 7: Main Board version 05TA085-6 added. Chapter 10: New spare parts list.