Instructions / Assembly


OperatingInstructionsfortheVulcan,770‐00‐175

1. RemoveBBQgrillandallcomponentsfromthestoragebag.Makesuretoremoveallcardboard
and/orplasticfromallpartsbeforeusingthegrill.
2. Unfoldthelegs(awayfromthecenter)andplacethegrillonasecuredandlevelsurface.Place
thegrateontopoftheBBQgrill.
3. LocatethelocknutonthesideoftheBBQgrill.AligntheBBQscrewpostoftheregulatorwith
thelocknutofthegrill.Turnthelocknutclo ckwiseuntilthepropaneregulatorissecured.Do
notovertightenasthismaycausedamagetothescrewpost.Asmallwrenchmaybeused,but
isnotnecessarytoformaproperconnection.(Wrenchnotincluded.)
4. Attachapropane(LP)gastanktothegrillaccordingtothemanufacturer’sdirectionsprintedon
thecanister.Besuretofollowmanufacturer’sdirectionsforusetoavoidinjury.Thegrillisnow
readytolight.
5. Howtolight–UsingaBBQlighterorfireplacematches,insertflamethroughanopenexterior
holeatthebottomofgrillsoflamereachesintothegrill’sinterior.Turnknobto“on”position;
BBQshouldigniteimmediately,atwhichpointoneshouldremovetheflamesource.IfBBQdoes
notignitewithin2seconds,turnknob“off”,wait20secondsand repeatprevioussteps.
ALWAYSBESURETOINTRODUCEFLAMESOURCE
BEFORETURNINGGASKNOBTO“ON”
POSITION.Turninggasknobonbeforelightingthegrillmaylikelyresultingasbuildingupinthe
gaslinewhichcouldcauseseriousinjurywhen BBQislit.

InstructionsforStoringtheVulcan
1. OncetheBBQgrillhasfullycooled,removethegratefromtheBBQandputaside.Unscrewthe
regulatorfromtheBBQgrill,andplaceitundertheheatplateatoneend.Invertthelidsothat
itrestsinsidethegrill,makingsurethehandlefitsintothecut‐outsectionoftheheatplate.
2. Foldthelegsofthegrillin(towardsthecenter),makingtheBBQgrillascompactaspossible.
PlacetheBBQgrillinthebottomofthestoragebag.PlacetheBBQgrillinthebagontopofthe
grate.Cinchthedrawstringtoclosethebag.Placethebaginthebottom‐mostzippered
compartmentoftheVulcan.
770‐00_Vulcan_OperatingInstructions.doc