SDS

ManualsBrandsPlasti Dip ManualsPaint11 oz. Bright Aluminum Metalizer

SAFETY DATA SHEET

1. Identification

11oz Bright Aluminum MetalizerProduct identifier

Other means of identification

11247-6

Product Code

Not available.

Recommended use

Manufacturer/Importer/Supplier/Distributor information

Plasti Dip International

Address

3920 Pheasant Ridge Drive

Company name

Website

Telephone

General Assistance 763-785-2156

Emergency phone number

Chemtrec/INTL 800-424-9300/703-527-3887

E-mail

United States

Plastidip.com

Pdi@Plastidip.com

Blaine, MN 55449

2. Hazard(s) identification

Category 1Flammable aerosols

Physical hazards

Liquefied gasGases under pressure

Category 4Acute toxicity, oral

Health hazards

Category 2ASerious eye damage/eye irritation

Category 2Carcinogenicity

Category 2Reproductive toxicity

Category 1Specific target organ toxicity, repeated

exposure

Category 2Hazardous to the aquatic environment, acute

hazard

Environmental hazards

Category 2Hazardous to the aquatic environment,

long-term hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Extremely flammable aerosol. Contains gas under pressure; may explode if heated. Harmful if

swallowed. Causes serious eye irritation. Suspected of causing cancer. Suspected of damaging

fertility or the unborn child. Causes damage to organs through prolonged or repeated exposure.

Toxic to aquatic life. Toxic to aquatic life with long lasting effects.

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not

spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn,

even after use. Do not breathe mist or vapor. Wash thoroughly after handling. Do not eat, drink or

smoke when using this product. Avoid release to the environment. Wear protective

gloves/protective clothing/eye protection/face protection.

Response

If swallowed: Call a poison center/doctor if you feel unwell. If in eyes: Rinse cautiously with water

for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If

exposed or concerned: Get medical advice/attention. Rinse mouth. If eye irritation persists: Get

medical advice/attention. Collect spillage.

1 / 12

Material name: 11oz Bright Aluminum Metalizer

11247-6 Version #: 02 Revision date: 04-07-2016 Issue date: 04-07-2016

SDS US

Summary of content (12 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier 11oz Bright Aluminum Metalizer Other means of identification Product Code 11247-6 Recommended use Not available. Manufacturer/Importer/Supplier/Distributor information Company name Address Telephone Website E-mail Emergency phone number Plasti Dip International 3920 Pheasant Ridge Drive Blaine, MN 55449 United States General Assistance Plastidip.com Pdi@Plastidip.com Chemtrec/INTL 763-785-2156 800-424-9300/703-527-3887 2.
PAGE 2
Storage Store locked up. Protect from sunlight. Store in a well-ventilated place. Protect from sunlight. Do not expose to temperatures exceeding 50°C/122°F. Disposal Dispose of contents/container in accordance with local/regional/national/international regulations. Hazard(s) not otherwise classified (HNOC) None known. Supplemental information 84.4% of the mixture consists of component(s) of unknown acute oral toxicity. 92.
PAGE 3
Specific methods General fire hazards Use standard firefighting procedures and consider the hazards of other involved materials. Move containers from fire area if you can do so without risk. In the event of fire and/or explosion do not breathe fumes. Extremely flammable aerosol. Contents under pressure. Pressurized container may explode when exposed to heat or flame. 6.
PAGE 4
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Form Value PROPANE (CAS 74-98-6) PEL XYLENE (CAS 1330-20-7) PEL US. ACGIH Threshold Limit Values Components Type Value Form TWA 1 mg/m3 Respirable fraction.
PAGE 5
Appropriate engineering controls Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. Provide eyewash station.
PAGE 6
Percent volatile 91.21 Specific gravity 0.68 VOC 614.35 g/l Regulatory 5.13 lbs/gal Material 5.13 lbs/gal Regulatory 614.35 g/l Material 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. Chemical stability Material is stable under normal conditions. Possibility of hazardous reactions Hazardous polymerization does not occur. Conditions to avoid Heat. Avoid temperatures exceeding the flash point.
PAGE 7
Components Species Test Results Rat 1.67 g/kg Mouse 680 mg/l, 2 Hours Rat 658 mg/l, 4 Hours Rat > 1442.847 mg/l, 15 Minutes Dermal LD50 Rabbit > 43 g/kg Inhalation LC50 Mouse 3907 mg/l, 6 Hours Rat 6350 mg/l, 4 Hours Mouse 1590 mg/kg Rat 3523 - 8600 mg/kg N-BUTANE (CAS 106-97-8) Acute Inhalation LC50 PROPANE (CAS 74-98-6) Acute Inhalation LC50 XYLENE (CAS 1330-20-7) Acute Oral LD50 * Estimates for product may be based on additional component data not shown.
PAGE 8
Components Species Test Results Rainbow trout,donaldson trout (Oncorhynchus mykiss) 0.16 mg/l, 96 hours 1.37 - 4.4 mg/l, 48 hours ALUMINUM (CAS 7429-90-5) Aquatic Fish LC50 ETHYLBENZENE (CAS 100-41-4) Aquatic Crustacea EC50 Water flea (Daphnia magna) Fish LC50 Fathead minnow (Pimephales promelas) 7.
PAGE 9
Subsidiary risk Label(s) Packing group Special precautions for user Special provisions Packaging exceptions Packaging non bulk Packaging bulk IATA UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Label(s) Packing group Environmental hazards Special precautions for user Other information Passenger and cargo aircraft Cargo aircraft only IMDG UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Label(s) Packing group Environmental hazards Marine p
PAGE 10
XYLENE (CAS 1330-20-7) Listed. SARA 304 Emergency release notification Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not regulated. Superfund Amendments and Reauthorization Act of 1986 (SARA) Immediate Hazard - Yes Hazard categories Delayed Hazard - Yes Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed.
PAGE 11
US. New Jersey Worker and Community Right-to-Know Act ALUMINUM (CAS 7429-90-5) ETHYLBENZENE (CAS 100-41-4) METHYL ETHYL KETONE (CAS 78-93-3) METHYL N-AMYL KETONE (CAS 110-43-0) N-BUTANE (CAS 106-97-8) PROPANE (CAS 74-98-6) XYLENE (CAS 1330-20-7) US. Pennsylvania Worker and Community Right-to-Know Law ALUMINUM (CAS 7429-90-5) ETHYLBENZENE (CAS 100-41-4) METHYL ETHYL KETONE (CAS 78-93-3) METHYL N-AMYL KETONE (CAS 110-43-0) N-BUTANE (CAS 106-97-8) PROPANE (CAS 74-98-6) XYLENE (CAS 1330-20-7) US.
PAGE 12
Disclaimer Revision information The information in the sheet was written based on the best knowledge and experience currently available. THE INFORMATION CONTAINED HEREIN IS BASED ON DATA BELIEVED TO BE RELIABLE AND THE MANUFACTURER DISCLAIMS ANY LIABILITY INCURRED FROM THE USE OR RELIANCE UPON THE SAME. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION.