Use and Care Manual

2
 PHONE:800-229-4500•FAX:800-570-0007 POSTALPRODUCTS
N1029085 - STD4C-118 REV 3
INSTALLATIONANDSETUP PAGE
GENERAL INFORMATION AND ADVISORIES 2
INSTALLATION REQUIREMENTS 3
PARCEL-ONLY UNIT FUNCTIONALITY AND INSTALLATION INFORMATION 4
INDEPENDENT INSTALLATION 6
INSTALLATION OF COLLECTION DOOR ARROW LOCK (by USPS) 8
INSTALLATION OF PARCEL DOOR ARROW LOCK (by USPS) 10
APPENDIX -
APPENDIX-INDEPENDENT INSTALLATION WALL CONSTRUCTION 12
• LAY BOXES FLAT, DO NOT STAND ON END.
BOX COULD FALL OVER AND CAUSE INJURY.
• BOXES ARE HEAVY. USE CAUTION WHEN
LIFTING AND CARRYING TO AVOID INJURY.
CAUTION: HANDLING & TRANSPORTATION
• 4C UNITS ARE HEAVY. USE CAUTION WHEN
LIFTING AND CARRYING TO AVOID INJURY.
• A PINCH HAZARD EXISTS WHEN PLACING THE
MAILBOX IN ROUGH OPENING. KEEP FINGERS
AND HANDS CLEAR TO AVOID AN INJURY.
CAUTION: INSTALLATION
• 4C UNITS ARE FRONT-HEAVY. DO NOT STAND
ON END WITHOUT SUPPORT TO PREVENT
TIPPING. MAILBOXES MAY TIP OUT OF ROUGH
OPENING UNTIL SECURED, POSSIBLY
RESULTING IN THE MAILBOX COLLIDING WITH
A PERSON AND CAUSING SERIOUS INJURY.
• 4C UNITS ARE VERY FRONT-HEAVY WITH
MASTER LOADING DOORS OPEN. UNITS MUST
BE BRACED OR HELD IN PLACE UNTIL
SECURED TO FRAMING. INSTALLER SHOULD
SUPPORT UNIT OR HAVE ASSISTANCE
HOLDING THE UNIT IN PLACE BEFORE
OPENING THE MASTER LOAD DOORS. FAILURE
TO DO SO COULD RESULT IN SERIOUS INJURY.
WARNING: INSTALLATION
THENEWU.S.POSTALSERVICESTD-4CINCLUDES
THEFOLLOWINGSPECIFICATIONS:
• ANEWCOMPARTMENTFORMFACTORMINIMUMSIZE
REQUIREMENT OF 12"W × 15"D × 3"H.
• ELIMINATESTHEVERTICALFORMFACTOR(5"W×6"D×
15"H) DESIGN.
• INTRODUCESAPARCELLOCKERREQUIREMENTBASED
ON A 1:10 PARCEL LOCKER TO CUSTOMER COMPART-
MENT RATIO.
• STRENGTHENSSECURITYREQUIREMENTSFORTHE
ENTIRE RECEPTACLE.
• STANDARDIZESANDIMPROVESTENANTCOMPARTMENT
LOCK DESIGN.
• ADDSTESTINGREQUIREMENTSTOVERIFYACCEPTABIL-
ITY FOR EITHER INDOOR OR OUTDOOR USE.
• INTRODUCESQUALITYMANAGEMENTSYSTEMSPROVI-
SIONS.
• ENHANCESDESIGNFLEXIBILITYFORCONCEPT,ERGO-
NOMICS,ANDMATERIALS.
4CMAILBOXSUITESAREDESIGNEDTOMEETOREXCEEDTHEUSPS
SPECIFICATIONSOUTLINEDABOVEANDINTHEFEDERALREGISTER/VOL.
69NO.171/SEPTEMBER3,2004/RULESANDREGULATIONSPOSTALSER-
VICE,39CFRPART111,STANDARDSGOVERNINGTHEDESIGNOFWALL-
MOUNTEDCENTRALIZEDMAILRECEPTACLES.PROPERINSTALLATIONIS
THERESPONSIBILITYOFTHEINSTALLER.THEINSTALLATIONREQUIRE-
MENTSLISTEDHEREINAREBASEDONTHEUSPSFEDERALREGISTER
PREVIOUSLY MENTIONED.
TABLEOFCONTENTS
GENERALINFORMATIONANDADVISORIES
4C MAILBOX SUITES