Product Manual

Summary of Important Safety Information for Operation (cont’d)
37
switch installed by a licensed electrician in compliance with all applicable local building and electrical codes. If the
generator is not isolated from the utility power system by such means, generator output will back feed into the utility power
grid. This may result in injury or death to utility power workers or others who contact the lines during a power outage. It
may also cause the generator to explode or cause fires when utility power is restored.
• Wet conditions. Water conducts electricity. DO NOT operate generator where it is wet. Operate on a dry surface under
an open, canopy-like structure.
• CO alarms. Ensure that working, battery-operated or battery back-up carbon monoxide alarms are used in any
dwelling/structure that is in close proximity to the running generator.
• Hot exhaust - fires. Exhaust from engine can be extremely hot and cause fire. Position muffler at least 7 feet from
combustible objects during operation.
• Spark arrester. Equip engine with a spark arrester if generator will be used near any ignitable forest, brush, or grassy
land. See the “Specifications” section of this manual to determine if your generator is already equipped. Make sure you
comply with applicable local, state and federal codes.
• Fire extinguisher. Keep a fire extinguisher rated “ABC” by the National Fire Protection Association nearby. Keep it
properly charged and be familiar with its use.
Safety – Before Use
Know how to operate
• Review safety rules. Before each use of this generator, review the “Rules for Safe Operation.” Failure to follow these
rules may result in serious injury or death.
• Know how to operate. Be thoroughly familiar with all controls and with the proper use of the equipment. Know how to
stop the generator quickly if needed.
Personal protective equipment
• Hearing protection. The use of ear plugs or other hearing protection device is recommended for those in close proximity
to the generator while it is operating.
• Loose / dangling. Loose or dangling apparel can become entangled in moving parts. Metal jewelry can conduct
electricity. Never wear jewelry or loose-fitting clothing when operating the generator.
Gasoline Safety
Gasoline is highly flammable and explosive. You can be burned or seriously injured when handling fuel. Use extreme care
when handling:
• Fuel outdoors. Fill fuel tank outdoors – never indoors. Gasoline vapors can ignite if they collect inside an enclosure.
Explosion can result.
• Use approved container. Never pump fuel directly into engine at gas station. Static charge can build and ignite fuel.
Use an UL approved fuel container to transfer gas to the engine.
• Running / hot engine. A running engine is hot enough to ignite fuel. Never add fuel or remove gas cap if engine is
running or still hot. Stop the engine and allow to cool at least two minutes before adding fuel.
• Heat / flames / sparks. Stay away from sources of heat, flame, or sparks while adding fuel.
• Don’t overfill. DO NOT overfill the gas tank. Allow at least 1/2 inch of empty space below the fill neck to allow for fuel
expansion.
• Replace cap. Replace gas cap securely before starting engine.
• Spills. Clean up fuel spills immediately. Move generator away from spilled fuel on the ground. Wipe fuel off engine and
wait 5 minutes for excess fuel to evaporate before starting engine. Gas soaked rags should be disposed of properly.
• On skin / clothes. If gasoline is spilled on your skin or clothes, change clothes and wash skin immediately.
• Inspect fuel system. Check fuel system on a regular basis. Look for signs of leaks, deterioration, chafed or spongy fuel
hose, loose or missing fuel hose clamps, damaged fuel tank, or a defective fuel shut-off valve. DO NOT start generator
until needed repairs have been completed.
• Gasoline storage. Store gasoline in a cool, dry place in an UL-listed, tightly sealed container.