Replacement Part List

ManualsBrandsPowermate ManualsTools & Hardware3 Gal. Electric Air Compressor with Extra Value Kit

200-2757

E103732

Revision B

Operator-Parts Manual

Manuel de l’opérateur - Manuel de pièces

Manual del operador - Manual de piezas

Oilless, Single Stage, Direct Drive, Electric Air Compressor

Sans l’huile, d’un seule étape, à prise directe, compresseur d’air électrique

Sin aciete, de una sola etapa, de mando directo, compresor de aire eléctrico

200-2757 (E103732)_ Rev B_2-11

WARNING: Read and understand all safety precautions in this manual before operating. Failure to comply with

instructions in this manual could result in personal injury, property damage, and/or voiding of your warranty. The

manufacturer WILL NOT be liable for any damage because of failure to follow these instructions.

AVERTISSEMENT : Lisez et veillez à bien comprendre toutes les consignes de sécurité de ce manuel avant

d'utiliser l'appareil. Toute dérogation aux instructions contenues dans ce manuel peut entraîner l'annulation de la

garantie, causer des blessures et/ou des dégâts matériels. Le fabricant NE SAURA être tenu responsable de dommages

résultant de l'inobservation de ces instructions.

ADVERTENCIA: Lea y comprenda todas las precauciones de seguridad contenidas en este manual antes de

utilizar esta unidad. Si no cumple con las instrucciones de este manual podría ocasionar lesiones personales, daños a la

propiedad y/o la anulación de su garantía. El fabricante NO SERÁ responsable de ningún daño por no acatar estas

instrucciones.

Specification Chart________Tableau des spécifications_______Cuadro de especificaciones

Questions? See back page._____Questions ? Consultez la page final._____¿Preguntas? Vea la página final.

Product style and configuration may

vary.

Le style et la configuration du produit

peuvent varier.

El estilo y la configuración del

producto puede variar.

MODEL NO.

(MODÈLE)

(MODELO)

RUNNING

H.P.

(CV)

TANK CAPACITY

GALLONS

(CAPACITÉ DU

RÉSERVOIR - LITRES)

(CAPACIDAD DEL

TANQUE - LITROS)

VOLTAGE/

AMPS/PHASE

(TENSION/

AMPS/PHASE)

(VOLTAJE

AMP/FASE)

KICK-IN

PRESSURE

(PRESSION

D’OUVERTURE)

(PRESION DE

CONEXION)

KICK-OUT

PRESSURE

(PRESSION DE

FERM.)

(PRESION DE

DESCONEXION)

VPP1080318

(E103699)

1 3 (11,4) 120/12/1 95 (6,55 bar) 125 (8,62 bar)

PP1080518

(E103700)

1 5 (18,9) 120/12/1 95 (6,55 bar) 125 (8,62 bar)

VPP1080818

(E103701)

1 8 (30,3) 120/12/1 95 (6,55 bar) 125 (8,62 bar)

VLP1081218

(E103702)

1 12 (45,4) 120/12/1 95 (6,55 bar) 125 (8,62 bar)

Summary of content (24 pages)

PAGE 1
Operator-Parts Manual Manuel de l’opérateur - Manuel de pièces Manual del operador - Manual de piezas 200-2757 E103732 Revision B Oilless, Single Stage, Direct Drive, Electric Air Compressor Sans l’huile, d’un seule étape, à prise directe, compresseur d’air électrique Sin aciete, de una sola etapa, de mando directo, compresor de aire eléctrico Product style and configuration may vary. Le style et la configuration du produit peuvent varier. El estilo y la configuración del producto puede variar.
PAGE 2
TABLE OF CONTENTS SAFETY GUIDELINES . . . . . . . . . . . . . . . . . . . . . . . . . . .3 OVERVIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Basic Air Compressor Components . . . . . . . . . . . . .6 ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 Assembling the Compressor . . . . . . . . . . . . . . . . . . .7 COMPRESSOR CONTROLS . . . . . . . . . . . . . . . . . . . . . .8 ELECTRICAL POWER REQUIREMENTS . . . . . . . . . . . .
PAGE 3
SAFETY GUIDELINES The following information relates to protecting YOUR SAFETY and PREVENTING EQUIPMENT PROBLEMS. To help you recognize this information, we use the following symbols. Please read the manual and pay attention to these sections. DANGER: – A POTENTIAL HAZARD THAT WILL CAUSE SERIOUS INJURY OR LOSS OF LIFE. WARNING: – A POTENTIAL HAZARD THAT COULD CAUSE SERIOUS INJURY OR LOSS OF LIFE. CAUTION: – A POTENTIAL HAZARD THAT MAY CAUSE MODERATE INJURY OR DAMAGE TO EQUIPMENT. WARNING 1. 2. 3. 4. 5.
PAGE 4
CONSIGNES DE SÉCURITÉ Les informations suivantes concernent VOTRE SÉCURITÉ et LA PROTECTION DU MATÉRIEL CONTRE LES PANNES. Pour vous aider à identifier la nature de ces informations, nous utilisons les symboles suivants. Veuillez lire le manuel et prêter attention à ces sections. DANGER: – DANGER POTENTIEL POUVANT ENTRAÎNER DE GRAVES BLESSURES OU LA MORT. AVERTISSEMENT: – DANGER POUVANT CAUSER DES BLESSURES GRAVES VOIRE MORTELLES.
PAGE 5
PAUTAS DE SEGURIDAD La información que sigue se refiere a la protección de SU SEGURIDAD y la PREVENCIÓN DE PROBLEMAS DEL EQUIPO. Como ayuda para reconocer esta información, usamos los siguientes símbolos. Lea por favor el manual y preste atención a estas secciones. PELIGRO: - UN POSIBLE RIESGO QUE CAUSARÁ LESIONES GRAVES O LA PÉRDIDA DE LA VIDA. ADVERTENCIA: - UN RIESGO POTENCIAL QUE PODRÍA PROVOCAR GRAVES LESIONES O MUERTE.
PAGE 6
OVERVIEW \ VUE D’ENSEMBLE \ RESUMEN GENERAL BASIC AIR COMPRESSOR COMPONENTS Oilless air compressors are factory lubricated for life and do not require any oil. The basic components of the air compressor are the electric motor, pump, pressure switch, and tank. The electric motor (see A) powers the pump. The electric motor is equipped with an overload protector and an automatic reset. If the motor becomes overheated, the overload protector will shut it down to prevent damage to the motor.
PAGE 7
ASSEMBLY / ASSEMBLAGE / MONTAJE 1. 2. 3. 4. 1. 2. 3. 4. 1. ASSEMBLING THE COMPRESSOR Unpack the air compressor. Inspect the unit for damage. If the unit has been damaged in transit, contact the carrier and complete a damage claim. Do this immediately because there are time limitations to damage claims. Check the compressor’s serial label to ensure that you have received the model ordered, and that it has the required pressure rating for its intended use.
PAGE 8
COMPRESSOR CONTROLS / COMMANDES DU COMPRESSEUR / CONTROLES DEL COMPRESOR COMPRESSOR CONTROLS CONTROLES DEL COMPRESOR ON/OFF Switch (see A) This switch turns on the compressor. It is operated manually, but when in the ON position, it allows the compressor to start up or shut down automatically, without warning, upon air demand. ALWAYS set this switch to OFF when the compressor is not being used, and before unplugging the compressor. ON/OFF Interruptor (vea A) Este interruptor enciende el compresor.
PAGE 9
ELECTRICAL POWER REQUIREMENTS SPÉCIFICATIONS DE L'ALIMENTATION ÉLECTRIQUE REQUERIMIENTOS DE ALIMENTACIÓN ELÉCTRICA ELECTRICAL WIRING Refer to the air compressor’s serial label for the unit’s voltage and amperage requirements. EXTENSION CORDS NOTE: Avoid use of extension cords. For optimum performance, plug the compressor power cord directly into a grounded wall socket. Do not use an extension cord unless absolutely necessary. Instead, use a longer air hose to reach the area where the air is needed.
PAGE 10
REQUERIMIENTOS DE ALIMENTACION ELECTRICA Figura 1 CABLEADO ELÉCTRICO Caja de tomacorriente puesta a tierra Consulte el rótulo del número de serie del compresor de aire para ver los requerimientos de voltaje y amperaje de la unidad. CORDONES PROLONGADORES Tomacorriente puesta a tierra NOTA: Evite el uso de cordones prolongadores. Para obtener un rendimiento óptimo, enchufe el cordón eléctrico del compresor directamente en un tomacorriente de pared conectado a tierra.
PAGE 11
OPERATING INSTRUCTIONS \ MODE D’EMPLOI \ INSTRUCCIONES OPERATIVAS 1. 2. 3. DAILY STARTUP Turn the ON/OFF switch to the OFF position (see A). Close the tank drain valve (see D). Turn in the clockwise direction. Plug in the power cord. 2. 3. ATTENTION: L'air et l'humidité qui s'échappent WARNING: High temperatures are generated 4. 5. 1. 2. 3. by the electric motor and the pump. To prevent burns or other injuries, DO NOT touch the compressor while it is running.
PAGE 12
INSTRUCCIONES OPERATIVAS ARRANQUE DIARIO 1. 2. 3. Coloque el interruptor ON/OFF en la posición OFF (vea A). Cierre la válvula de desagüe del tanque (vea D). Hágalo girar hacia la derecha. Enchufe el cordón eléctrico. AVERTENCIA: El motor eléctrico y la bomba producen altas temperaturas. Para evitar quemaduras y otras lesiones, NO toque el compresor durante su funcionamiento. Permita que se enfríe antes de manipular o realizar el servicio. Mantenga a los niños alejados del compresor en todo momento. 4.
PAGE 13
MAINTENANCE \ ENTRETIEN \ MANTENIMIENTO MAINTENANCE WARNING: To avoid personal injury, always shut off and unplug the compressor and relieve all air pressure from the system before performing any service on the air compressor. Regular maintenance will ensure trouble free operation. Your electric powered air compressor represents high quality engineering and construction; however, even high quality machinery requires periodic maintenance. The items listed below should be inspected on a regular basis.
PAGE 14
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS VPP1080318 3 Gallon Horiz. ITEM # 39 PP1080518 5 Gallon Horiz.
PAGE 15
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS Item Art Art 1 2 3 5 or 6 7 9 10 11 12 13 14 15 16 17 18 or 19 or 20 or 21 or 22 23 24 25 26 or 27 28 29 30 or Part No No / P Núm / P Order item #39 Order item #39 Order item #39 040-0418 (see pages 18-19) 145-0585 145-0604 N/A N/A ** N/A 136-0098 034-0224 N/A N/A 019-0263 036-0084 ** N/A N/A N/A N/A N/A N/A 094-0184 094-0182 N/A 072-0018 N/A N/A 145-0586 145-0605 031-0091 N/A ** 032-0109 032-0114 31 032-0115 1 32 33 34 35 36 37 064-0112 N/A 114-0694
PAGE 16
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS VPP1080818 8 Gallon Horiz. ITEM # 38 VLP1081218 12 Gallon Vert.
PAGE 17
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS Item Art Art 1 2 3 5 or 6 7 8 9 10 11 12 13 14 or 15 16 17 18 or 19 or 20 or 21 22 or 23 24 25 26 or 27 28 29 30 31 32 33 34 35 36 37 Part No No / P Núm / P Order item #38 Order item #38 Order item #38 040-0418 (see pages 18-19) 145-0609 145-0607 N/A N/A N/A ** N/A 136-0098 034-0219 N/A 112-0173 112-0167 019-0263 036-0084 ** N/A N/A N/A N/A N/A N/A 094-0184 N/A N/A 072-0018 N/A N/A 145-0610 145-0608 031-0090 N/A ** 032-0109 N/A 095-0077 N/A N/A N/A N/A N/
PAGE 18
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS 040-0418 (U2C) Pump Breakdown ITEM # 30 18 ITEM # 29 200-2757
PAGE 19
PARTS LIST \ LISTE DE PIÈCES \ LISTA DE LAS PIEZAS Item Art Art 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Part No No / P Núm / P N/A N/A 042-0128 Order item #29 Order item #29 Order item #29 Order item #29 Order item #29 Order item #29 Order item #30 ** ** Order item #30 Order item #30 Order item #30 Order item #30 027-0049 ** N/A N/A Order item #30 Order item #30 ** N/A N/A ** N/A N/A Qty Qté Cant 4 4 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 7 1 2 1 1 1 1 1 1 3 Description Screw,
PAGE 20
MAINTENANCE \ ENTRETIEN \ MANTENIMIENTO CHECKING THE RELIEF VALVE Pull the relief valve daily to ensure that it is operating properly and to clear the valve of any possible obstructions. TESTING FOR LEAKS Check that all connections are tight. A small leak in any of the hoses, transfer tubes, or pipe connections will substantially reduce the performance of your air compressor. If you suspect a leak, spray a small amount of soapy water around the area of the suspected leak with a spray bottle.
PAGE 21
TROUBLESHOOTING CHART Note: Troubleshooting problems may have similar causes and solutions. PROBLEM Low pressure or not enough air or Compressor does not stop POSSIBLE CAUSE Tank drain valve is open Fittings Leak Restricted air intake Prolonged excessive use of air Compressor not large enough Hole in air hose Tank leaks Blown seals Valve leaks Leaking or worn piston Dirty or damaged regulator internal parts.
PAGE 22
DÉPANNAGE Remarque : Les problémes de dépannage peuvent avoir des causes et des solutions similaires.
PAGE 23
CUADRO DE DETECCIÓN DE FALLOS Nota: Los problemas de detección de fallos pueden tener causas y soluciones similares. PROBLEMA Presión baja o insuficiente cantidad de aire. o bien el compresor no se detiene CAUSA POSIBLE SOLUCION El grifo de desagüe del tanque Cierre el grifo de desagüe está abierto Las conexiones tienen fugas Revise las conexiones con agua jabonosa. Apriete o vuelva a sellar las conexiones que tengan fugas. NO LAS APRIETE EN EXCESO.
PAGE 24
PARTS AND SERVICE Replacement parts and service are available from your nearest authorized Service Center. If the need arises, contact Product Service as listed at right. When needing service, please contact the nearest authorized Service Center or call: When consulting with a Service Center or Product Service, refer to the model number and serial number located on the serial label of the compressor. Proof of purchase is required for all transactions and a copy of your sales receipt may be requested.