Model: PMG2000SR Inverter Gasoline OPERATOR’S MANUAL Warning: The Engine Exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. PowerMaxConverters.
TABLE OF CONTENTS
INTRODUCTION Thank you for purchasing this superior quality portable generator from PowerMax. When operating and maintaining this product as instructed in this manual, your generator will give you many years of reliable service. Product Specifications: This generator is an engine-driven, portable generator. It is designed to supply electrical power to operate tools, appliances, camping equipment, lighting, or serve as a backup power source during power outages.
Safety Rules SAFETY SYMBOLS Indicates a potentially hazardous WARNING! situation which could result in serious injury or death if not avoided. CAUTION! Indicates a potentially hazardous situation which could result in damage to equipment or property. Toxic Fumes Risk of fire Risk of electric shock Hot surface Risk of explosion Safety instructions The manufacturer cannot anticipate every possible hazardous circumstance that the user may encounter.
Safety Rules Never exceed generators wattage / amperage capacity. This could WARNING! damage the generator and / or connected electrical devices. • Check operating voltage and frequency requirements of all electrical devices prior to plugging them into the generator. WARNING! • • Never start or stop engine with electrical devices plugged in to the receptacles. Failure to do so could damage the generator and / or connected electrical devices.
Safety Rules WARNING! • • • • • • • Never handle the generator, electronic devices, or any cord while standing in water, while barefoot, or when hands or feet are wet. Always keep the generator dry. Never operate generator in rain or under wet conditions. Use a ground fault circuit interrupter (GFCI) in a damp or highly conductive area, such as metal decking or steel work. Never plug electronic devices into generator having frayed, worn, or bare wires.
FEATURES 7
8
9
CONTROL PANEL FUNCTIONS Note: The Economy switch must be turned to the “OFF” position when using electronic devices that require a large starting current, such as a compressor. Parallel Outlets Located just above the Ground Terminal, the generator’s Parallel Outlets enable a user to run two PMG4000iS generator’s simultaneously. This operation requires special cables. When operating parallel generators, the rated output is 7.0kVA and the rated current is 58.3A/120VAC.
11
12
13
14
15
OPERATION AC Parallel Operation It is possible to connect two PMG2000iS generators to each other, using a parallel cable kit, to increase available power output. • Connect PARALLEL OPERATION CABLES to two PMG4000iS generators according to the instructions provided with the cable kit. • Make sure the Economy switch is in the same position on both generators. • All electronic devices should be turned “OFF” and disconnected from generators prior to starting generator engines. • Start generator engines.
17
MAINTENANCE Regular maintenance will extend the life of this generator and improve its performance. The warranty does not cover items that result from operator negligence, misuse, or abuse. To receive full value from the warranty, operator must maintain the generator as instructed in this manual, including proper storage. Before inspecting or servicing this machine, make sure the engine is off and no parts are WARNING! moving. Disconnect the spark plug wire and move it away from the spark plug.
19
20
21
22
23
TROUBLESHOOTING Problem Cause Solution Generator is running, but does not supply power. 1. DC Circuit Breaker is “OFF” 2. Green AC Pilot Light Indicator is off. 3. Poor connection 4. Defective cord set 5. Connected device is faulty 6. Fault in generator 1. Turn DC Circuit Breaker “ON” 2. Stop engine and restart. 3. Check and repair 4. Check and repair 5. Connect a device that is working properly 6. Contact service department Engine runs good without load but bogs down when loads are connected 1.
DIAGRAMS PMG2000i PMG2000iS PowerMax products continually seeks advancement in quality and product desing.Therefore, while this manual contains the most current product information available at the time of printing, there may be minor discrepancies between your product and this manual. If there is any question concerning this manual, please consult a PowerMax dealer. This manual should be considered a permanent part of this product and should remain with this product when resold.
27
WARRANTY Limited 2 Year Warranty: From the date of original purchase, The warrants to the original purchaser, that each portable generator sold, shall be free from defect in material and workmanship, for the items and time period set forth below.It at its discretion, agrees to repair or replace any defective part that upon examination, inspection, and testing by a authorized service dealer, is found to be defective within the original warranty period.
WARRANTY What this Warranty Does Not Cover: • Normal wear: This warranty excludes normal wear items such as filters, spark plugs, gaskets, 0-rings, adapter cord sets, wheels, and starting batteries. • Maintenance: This warranty does not apply to tune-ups or routine maintenance and does not cover any adjustments or repairs not performed by an authorized repair facility.
PLACE FIRST-CLASS STAMP HERE Please do not send other correspondence to this address: www.PowerMaxConverters.com PRODUCT REGISTRATION 2051 S.
www.PowerMaxConverters.
