HIGH PRESSURE CLEANERS PS2600HD PS3000HD PS4200HD IMPORTANT: Please make certain that the person who is to use this equipment carefully reads and understands these instructions before operating.
We Appreciate Your Business. Thank you and congratulations for choosing Powershot This Operating Manual has been designed to instruct you on the correct use and operation of your Powershot product. Your satisfaction with this product and its safe operation is our ultimate concern. Therefore please take the time to read the entire manual, especially the Safety Precautions. They will help you to avoid potential hazards that may exist when working with this product.
Table Of Contents 6SHFL¿FDWLRQV 6\PERO 8VDJH ,PSRUWDQW 6DIHW\ ,QVWUXFWLRQV Quick Set-Up Guide ..........................................................................10 Quick Start Guide .............................................................................
not see or smell. You may be breathing CO even if you do not smell engine exhaust. Specifications PS4200HD PS3000HD PS2600HD SVL SVL SVL PSI Max*: 16L/min 15m 20-100psi Cold tap 11L/min 15m 20-100psi Cold tap 9L/min m 20-100psi Cold tap Soap Consumption Rate: 10% max 10% max 10% max L/Minute Max*: High Pressure Hose: Presure of Inlet Water: Inlet Water: * Rated Pressure and Rated Water Flow is within manufacturing tolerance of (+/- 10%).
DANGER! Risk of Explosion or Fire WHAT CAN HAPPEN HOW TO PREVENT IT Spilled gasoline and it’s vapors can become ignited from cigarette sparks, electrical arcing, exhaust gases and hot engine components VXFK DV WKH PXIÀHU Shut off engine and allow it to cool before adding fuel to the tank. Heat will expand fuel in the tank which could UHVXOW LQ VSLOODJH DQG SRVVLEOH ¿UH H[SORVLRQ Keep maximum fuel level 1/2” (12.
DANGER! Risk to Breathing (Asphyxiation) WHAT CAN HAPPEN HOW TO PREVENT IT Breathing exhaust fumes will cause serious injury or death! Engine exhaust contains carbon monoxide, an odorless and deadly gas. Operate pressure washer in a well ventilated area. Avoid enclosed areas such as garages, basements, etc. Never operate unit in or near a location occupied by humans or animals 6RPH FOHDQLQJ ÀXLGV FRQWDLQ VXEVWDQFHV ZKLFK could cause injury to skin, eyes or lungs.
Injuries can result if system pressure is not reduced before attempting maintenance or disassembly. To relieve system pressure, shut off engine, turn off water supply and pull gun trigger until water stops ÀRZLQJ Use only accessories rated equal to or higher than the rating of the pressure washer. DANGER! Risk of Injury from Spray WHAT CAN HAPPEN HOW TO PREVENT IT +LJK YHORFLW\ ÀXLG VSUD\ FDQ FDXVH REMHFWV WR break, projecting particles at high speed.
If proper starting procedure is not followed, engine can kickback causing serious hand and arm injury. If engine does not start after two pulls, squeeze trigger of gun to relieve pump pressure. Pull starter cord slowly until resistance is felt. Then pull cord rapidly to avoid kickback and prevent hand or arm injury. The spray gun/wand is a powerful cleaning tool that could look like a toy to a child. Keep children away from the pressure washer at all times.
DANGER! Risk of Chemical Burn WHAT CAN HAPPEN HOW TO PREVENT IT Use of acids, toxic or corrosive chemicals, SRLVRQV LQVHFWLFLGHV RU DQ\ NLQG RI ÀDPPDEOH solvent with this product could result in serious injury or death. Do not spray acids, gasoline, kerosene, or any othHU ÀDPPDEOH PDWHULDOV ZLWK WKLV SURGXFW 8VH RQO\ household detergents, cleaners and degreasers recommended for use with pressure washers. Fuel or oil leaks will damage carpet, paint or other surfaces in vehicles or trailers.
Quick Set-Up Guide WARNING! To reduce the risk of injury, read the pressure washer instruction manual and the engine instruction manual before operating pressure washer. Quick Start Guide DANGER! Never run engine indoors or in enclosed, poorly ventilated areas. Engine exhaust contains carbon monoxide, an odorless and deadly gas.
WARNING! This Guide is not a substitute for reading the operator’s manual. User must read and understand operator’s manual before using this product. www.powershot.co.nz 11.
Power Washer Controls and Features NOTE: Photographs and line drawings used in this manual are for reference only and do not UHSUHVHQW D VSHFL¿F PRGHO L G K C D Compare the illustrations B with your unit to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. M H A A. High Pressure Pump: Increases pressure of the water supply. B. Engine: Drives the high pressure pump.
Pressure Washer Terminology Assembly instructions PSI (Pounds per Square Inch): The unit of measure for water pressure. Also used for air pressure, hydraulic pressure, etc. LPM (Litres Per Minute): The unit of measure IRU WKH ÀRZ UDWH RI ZDWHU CU (Cleaning Units): LPM multiplied by psi equals CU. Bypass Mode: Allows water to re-circulate within the pump when the gun trigger is not pulled.
Operating the Power Washer NOTE: To apply chemicals the black low pressure nozzle must be installed and the Dial-N-Wash must be in the MAX pressure setting. Pressure Adjustments The pressure setting is preset at the factory to achieve optimum pressure and cleaning. If you need to lower the pressure, it can be accomplished by these methods. How to use the Spray Wand 1. Back away from the surface to be cleaned. The further away you are, the less the pressure will be on the surface to be cleaned.
Changing Nozzles on Spray Wand The nozzles for the spray wand are stored in the nozzle holder on the panel assembly. Colors on the panel identify nozzle spray pattern. DANGER! 5LVN RI ÀXLG LQMHFWLRQ 'R QRW GLUHFW discharge stream toward persons, unprotected skin, eyes or any pets or animals. Serious injury will occur. WARNING! Flying objects could cause risk of serious injury. Do not attempt to change nozzles while pressure washer is running. Turn engine off before changing nozzles. 1.
TREAT FLUID INJECTION AS A SIMPLE CUT! See a physician immediately! DANGER! Carbon Monoxide. Using an engine indoors can kill you in minutes. Engine exhaust contains high levels of carbon monoxide (CO), a poisonous gas you cannot see or smell. You may be breathing CO even if you do not smell engine exhaust. %UHDWKLQJ H[KDXVW IXPHV ZLOO FDXVH VHULRXV LQMXU\ or death! Engine exhaust contains carbon monoxide, an odorless and deadly gas. 2SHUDWH SUHVVXUH ZDVKHU LQ D ZHOO YHQWLODWHG area.
NOTE: Water source provided must be a minimum of 20 litres per minute at 20psi 7. Connect high pressure hose (C) to pump outlet (I). WARNING! To reduce the possibility of conWDPLQDWLRQ DOZD\V SURWHFW DJDLQVW EDFNÀRZ when connected to a potable water system. 8. Choose the correct nozzle for the job to be performed. See ‘How To Use spray Wand’ instrucWLRQV RQ SDJH NOTE: If applying a chemical or cleaning solution, see ‘Applying Chemicals & Solvents’ on page 15.
NOTE: Failure to release system pressure will prevent removal of high pressure hose from spray gun or pump connection. To Check Oil The oil level should come to the dot in the middle of the sight glass (AA). 5. See Storage section in this manual for proper storage procedures. Maintenance WARNING! Risk of burn hazard. When performing maintenance, you may be exposed to hot surfaces, water pressure or moving parts that can cause serious injury or death.
and/or when freezing temperatures are expected. 6LPSO\ ¿OO D EXFNHW XS KDOI ZD\ ZLWK DQWL IUHH]H water mix and use a short length of hose to suck the mixture into the pump while running. Turn machine off immediately as soon as bucket is empty. 2. Pull trigger on gun handle to relieve any water pressure. 3. Disconnect the spray wand from the gun. 5HPRYH KLJK SUHVVXUH nozzle (K) from spray wand.
Troubleshooting PROBLEM Engine will not start (see Engine Owner’s Manual for further engine troubleshooting) No or low pressure (initial use) No fuel Add fresh fuel Pressure builds up after two pulls on the recoil starter or after initial use Squeeze gun trigger to relieve pressure Choke lever in the “No Choke” position Move choke to the “Choke” position Spark plug wire not attached Attach spark plug wire Engine switch in OFF position. Place engine switch in ON position.
PROBLEM Will not draw chemicals Spray wand not in low pressure See How to Use Spray Wand paragraph in the Operation Section &KHPLFDO ¿OWHU FORJJHG &OHDQ ¿OWHU Chemical screen not in cleaning solution Make sure end of detergent siphon hose is fully submerged into cleaning solution Chemical too thick Dilute chemical.
High Pressure Cleaner Accessories PS3000HD & PS2600HD Nozzles - .030 %ODFN #+ % :KLWH #+ :
Warranty 5. WHAT IS NOT COVERED UNDER THIS WARRANTY: Serial Number: __________________________ A. Implied warranties, including those of merchantability and FITNESS for a particular purpose are limited in duration to this express warranty. After this period, all risks of loss, from whatever reason, shall be on the purchaser. B. ANY INCIDENTAL, INDIRECT, OR CONSEQUENTIAL LOSS, DAMAGE, OR EXPENSE THAT MAY RESULT FROM ANY DEFECT, FAILURE OR MALFUNCTION OF THIS PRODUCT. C.
Congratulations on your new POWERSHOT product. We are proud to have you as our customer and will strive to provide you with the best service and reliability in the industry. This product is backed by our extensive warranty and world-wide service network. To locate your nearest distributor or service agency call 0800 387 678, or email us at info@euroquip.co.nz.
