Assembly Instructions

[phone]
Primo Cart Stainless Steel Side Tables
Assembly Instructions
www.primogrill.com
PART NUMBER: #369 (FOR OVAL LG 300 & XL 400) , #319 (FOR JR 200)
TOOLS REQUIRED FOR ASSEMBLY:
ADJUSTABLE WRENCH OR 10MM WRENCH
LARGE PHILLIPS HEAD SCREWDRIVER
FIGURE 2
FIGURE 3
FIGURE 4
NOTE: JR 200 SHELF BRACKETS (SINGLE HOLE)
*
NOTE: LG 300 & XL400 SHELF
BRACKETS (TRIPLE HOLE)
INTSTALL THESE SCREWS BEFORE SIDE SHELF
ASSEMBLY INSTRUCTIONS
HANDLE METAL PARTS WITH CARE AS SOME MAY HAVE SHARP EDGES.
1. Remove all parts from the packaging and compare to the parts list.
2. SEE FIGURE 1 RIGHT. Remove 4 end caps prior to installation of shelf
brackets if previously installed.
3. SEE FIGURE 2 BELOW. Install the 4 brackets to the frame of the cart with
four M6 x 20 hex head bolts. (finger tighten only). *SEE SPECIAL NOTE
BEFORE PROCEEDING.
4. SEE FIGURE 3 BELOW. Fit the side shelves over the brackets and cart
frame. For an Oval XL, use the outer most set of holes and for a Oval LG use
the innermost set. The Oval JR shelf brackets have a single set of holes as
seen in figure 4.
5. Adjust both the shelf and brackets to align the openings in order to screw the
shelf to the cart. Being careful not to cross-thread the screws, finger tighten
each of the 4 phillips head screws per shelf before setting them tightly with the
screwdriver.
6. Once both shelves are installed, go back and tighten the brackets to the cart
frame. DO NOT USE POWERED SCREWDRIVERS, DRILLS, OR IMPACT
WRENCHES TO TIGHTEN THE BOLTS. This could result in damage to the cart
or grommets.
TWO (2)
RIGHT HAND
SHELF BRACKETS
TWO (2)
LEFT HAND
SHELF BRACKETS
EIGHT (8)
M6 X 20
STAINLESS
STEEL
PHILLIPS HEAD
SCREWS
FOUR (4) M6 X 16
STAINLESS STEEL
FLAT HEAD PHILLIPS SCREWS
* SEE SPECIAL NOTE
FIGURE 1
*
SPECIAL NOTE : Some carts ship with Shelf Brackets that have 3 holes facing the cart side
(illustration below). Shelf brackets with a 3rd hole accept a M6x16 Phillips Head fastener that
fastens through the outermost 3rd hole away from the center of the cart.
(NOT INCLUDED WITH ALL CARTS)