Installation Guide

6
New Construction/Extensive Remodel
“New Finished Wall Surface”
1.Priortosheetrock,stub-out1/2”hotandcoldsupplylinesbeyondthenishedwallsurface,4”on
center.TheheightoftheStub-outsiscompletelydependentuponthedesiredmountingheightof
theNavajoShowerSpa.Foraperson5’8”–6’2”werecommendthestub-outstobe35”fromthe
nishedoor.¹
2.Afterthenishedwallsurfacehasbeencompleted,makecertainthewateriscompletelyturned
offtobothhot&coldsupplylinesoftheShower.Connectthe90°malethreadedttingstothe
stub-outsmaintaining1/4”–1/2”spacebetweenthettingandnishedwall.Theopenendofthe
threadedmalettingshouldpointdown.
3.Markthelocationoftheholesforthemountingbracketmakingsurethebracketislevel.Fora
person5’8”–6’2”tall,werecommend53”fromnishedoorheight².Beforedrillingholesforthe
bracket,makecertainthe ShowerSpawillrestatagainst nishedwallsurfaceatthe desired
mountingheightwiththesupplylinesconnected.
4.Drill1/4”holesthroughthewallsurfaceusingamasonrybit.Drillslowlythroughwallsurfaceto
avoidcrackingandchipping.Insertanchorandsecurelyscrewbrackettowall.Beforeconnecting
hotandcoldsupplylines,mounttheShowerSpaonthewall,checkingtheheight,andmakingsure
theShowerSpafeelssecure.
5.Connecthotandcoldwatersupplylinestomalethreadedpipe,donotover-tighten.Beforemount-
ingtheShowerSpa,checkthettingstomakesuretheyaresecure.Turnonwaterandcheckfor
leaks.Whenttingsareleak-freemountShowerSpaonwall.
6.Holdhandheldmounttodesiredheight,makingsureexiblehosereachesmount.Recommended
4"to6"fromShowerSpaontherightsideoftheunit,soyoucaneasilyremovehandheldwand.
Positionmountatonsurfacemaketwomarkswithpencil.Carefullydrill¼"holesthroughthewall
surfaceusingmasonrybit.Insertanchorsandsecurelyscrewmounttowall.
7.Optional:SealaroundthebodyofShowerSpawithabeadofsilicone.
¹ThedesiredmountingheightoftheShowerSpadeterminestheheightofthe1/2”stub-outs.The
stub-outsmustbelocatedataheightallowingthesupplylinestobeconnectedandthebodyof
theShowerSpatorestatagainstthenishedwall.
²Thisheightmayvarydependingonseveralfactors(i.e.locationofsupplylines,interferencefrom
ShowerSpaplumbing,personalpreference,etc.)
Retrotting An Existing Shower:
Note:Inare-modelinwhichyouarenotreplacingthenishedwallsurface(tile,orbackingmaterial)
itisadvisabletopurchaseaPULSEShowerSpamodelthatcoversthelocationoftheexistingvalve
assembly-eithersinglehandleortwo-handletype.IfyourPULSEShowerSpamodeldoesnotcover
thisarea,youwillneedtoeitherchooseanotherPULSEShowerSpamodelthatdoesormakethe
necessaryrepairswithappropriatematerials(i.e.wallboard,tile,berglass,etc).
1. Turnoffthewatersupplytotheshower.(Note:Typicallythereisagatevalvewherethewater
mainentersthehouse.Turningthewatervalveoffatthehotwatertankdoesnotturnoffthecold
watersupplyline.)
2. Makecertainthewateriscompletelyturnedofftobothhot&coldsupplylinesoftheShower.
(Turntheshowervalveon,bothhotandcold,toverifythewatersupplyisoff.)Openasinkfaucet
inthebathroomin which you areinstallingtheShowerSpato relieve anypressureandhelp
adequatelydraintheshowersupplylines.
1. ShowerHead............................................Qty1
2. ShowerArm..............................................Qty1
3. HandHeldShowerWand......................... Qty1
4. HandHeldMount...................................... Qty1
5. GlassShelf............................................... Qty1
6. StainlessSteelHose(ORB)..................... Qty1
7. ShowerPanelWallMount......................... Qty1
8. TaperedEndofHose................................
9. HexagonNutEndofHose........................
10. SoftWasher.............................................. Qty2
11. ShowerArmNuts...................................... Qty2
12. MountingScrewPanelBracket.................Qty2
13. MountingAnchorPanelBracket............... Qty2
14. MountingScrewHandHeldMount(blk)... Qty2
15. MountingAnchorHandHeldMount..........Qty2
16. Screen3mmWasher(inserted)................ Qty1
17. 3mmWasher.............................................Qty2
18. AllenSetScreww/NylonTop(inserted)... Qty2
19. AllenSetScrew(inserted)........................ Qty1
20. HandHeldHoseOutlet(attached)............ Qty1
Navajo ShowerSpa
Numbered Components
#10
#14
#11
#15
#12
#16
#13
#17
#17
#18
#18
#20
#19
#1
#2
#7
#6
#5
#4
#9
#3
#8
Parts Legend
3