Manual

DANGER
Read this "Safety Precautions" before operation.
Below information should not be neglected for proper use of this product.
Your understanding can prevent harm or danger to user or others.
Common points for all series
High Performance Self-Priming Engine Pump
Avoid fire when refuel or maintenance.
Highly inflammable!
Do not operate Hidels pump inside a room or under
bad ventilation condition. Harmful substances are in
exhaust gas. There is danger of gas poisoning.
In case of operating Hidels Pump in a well or in a hollow,
the person operating the pump must not enter the small
space as there is danger of gas poisoning.
Do not use pump on slope.
Fuel spillage at tank cap or carburetor may cause fire.
Do not put any obstacle around engine muffler.
It may cause fire or breakage.
Read carefully and understand fully before use.
Keep children away from pump when in operation.
Do not overhaul or repair, except by person who is
trained to do so.
CAUTION
Do not touch muffler or any part of the engine.
It could cause burn.
Use this pump for clean water or agriculture water.
Not Suitable:drinking water, mud water, seawater, kerosene, light oil,
heavy oil, gasoline, chemical, acid, alkaline etc.
Use correct type of suction hose.
Water temperature tolerance: 5 to 45˚C.
May cause breakage if use outside the mentioned range.
Please don't run pump without water inside the pump.
This will cause pump damage.
Please use suction hose for suction side. Please
purchase suitable hose to fit to connection dia and
suitable length.
Please firmly connect hose with coupling and hose
band when you connect suction or delivery hose to pump.
LABEL Replace name plate if damaged/peeled,
please order with sales store.
1. Application
As this pump is design for agriculture use, do
not apply with muddy water.
*
Trouble if you don't observe.
Could damage mechanical seal.
2. Priming
As this pump is self-priming type, fill water
fully into priming port before running.
*
Trouble if you don't observe. Impossible to start
pumping and may damage mechanical seal.
3. Connection of suction hose
If pump does not work after filling water into priming port, it is likely due to
poor connection of suction hose. In such case, check hose connection again
before starting pump.
* Trouble if you don't observe. Impossible to pump.
4. Engine oil
Fill engine oil into oiling port, shown in
illustration, at the bottom of engine.
Change oil every 8 hours for the first 20 hours
and every 50 hours thereafter.
Applied oil : SAE#30 (spring-summer),
SAE#20 (autumn-winter),
SAE10W-30 (cold district, below-10˚C)
*
Trouble if you don't observe.
Burning of engine.
5. Drain water after use
Water inside may freeze at below 0˚C in winter and may damage pump.
After use, drain water from drain plug before storing.
* Trouble if you don't observe. Breakage of pump casing.
6. Long storage
Discharge fuel from fuel tank and carburetor completely.
*
Trouble if you don't observe. Impossible to start engine in future.
(Engine details, refer Engine Operation Manual.)
7. Prevent water hammer
Do not abruptly compress discharge hose during operation.
DRAIN PLUG
PRIMING
PLUG
1
4
DRAIN OIL BOLT
PRIMING OIL PLUG
CAUTION
SAFETY PRECAUTIONS
Following information is very important for safety in handling
this product. Be sure to observe them.
Indicates an imminently hazardous situation which,
if not avoided, will result in death or serious injury.
Indicates a potentially hazardous situation which,
if not avoided, could result in death or serious injury.
IMPORTANT PROHIBITED
ALERT
Indicates a potentially hazardous situation which, if not avoided,
may result in minor or moderate injury, or property damage.
DANGER
WARNING
CAUTION
Check accessories provided
List of accessories provided are printed on the pump manual.
1
2-stroke engine 2
Fuel / Engine oil
Please use "Unleaded gasoline mixed with lubricant
*
" only.
*
Please use "2-stroke oil" only.
BEFORE USE
25
( )
:
1
( )
Mixing
Ratio
2-stroke
oil
Unleaded
gasoline
Inflammable!! Avoid fire when refuel or maintenance.
WARNING
Inflammable! Do not smoke when mixing fuel and refuel near open fire.
Any fuel spillage must be cleaned completely before starting the engine.
Stop engine and wait until the engine has cooled down before refueling.
Do not use old fuel over 30 days. Fuel should be clean and fresh.
Fuel around the bottom of drum contains dirt, impurities and water.
Unused fuel in tank (if kept more than 30 days) may cause engine failure.
CAUTION
Thank you for choosing Koshin Hidels Pump.
This manual is prepared for your safety when
operating pump. Please read carefully and
comprehend fully before use.
(Wrong usage could cause injury or death.)
Please keep this manual handy for future
reference.