Tile Replacement Mount Elevated Water Seal Technology® For use with Flat, S, & W shaped tiles Installation Instructions
Instructions: QMTR - Tile Replacement Mount Installation Tools Required: stud finder, tape measure, utility knife, drill with 1/8" bit, impact gun with T-30 Torx bit, channel lock pliers, caulking gun, appropriate sealant compatible with EPDM rubber and roofing materials, roofing bar, and hand broom. NOTE: Installation method is the same for all tile replacement flashing profiles. 2 1 Locate and remove the tile that will be replaced by the tile replacement flashing.
Additional Installation Notes - Tile Replacement Mount Flashing Tile Roofs in Florida In the State of Florida tile roofs require that the sub-flashing must be flashed ON ALL FOUR SIDES per the TRI/FRSA Florida High Wind Concrete and Clay Tile Installation Manual. For more information, check out Quick Mount PV's Waterproofing Tile Roof Mount sub-flashing: Three-Course Method instructions. Alternative flashing methods may be approved by the AHJ at their discretion.
ITEM NO. 4 DESCRIPTION QTY. 1 FLASHING, .040" X 12" X 7.5", SHEET, 5052-H32, MILL 1 2 TILE REPLACEMENT BASE, 8.125", 6061-T6, MILL 1 WASHER, SEALING, 5/16" ID X 3/4" OD, EPDM BONDED SS STRUCTURAL SCREW, QMPV, BUTTON HEAD, 5/16" X 4", T-30, STEEL, COATED 2 3 4 2 3 1 TITLE: 2 QMTR-BM: TILE REPLACEMENT, BASE MOUNT UNLESS OTHERWISE SPECIFIED: PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF QUICK MOUNT PV.
BI 7.2.3-40 3 Jan-2020, Rev 13 5 WRITTEN PERMISSION OF QUICK MOUNT PV IS PROHIBITED. 4 COPYRIGHT © 2020 QUICK MOUNT PV 3 7 2 3 7 6 5 4 3 2 DO NOT SCALE DRAWING THIS EDGE TOWARDS ROOF RIDGE RACKING NOT INCLUDED PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF QUICK MOUNT PV. ANY REPRODUCTION IN PART OR AS A WHOLE WITHOUT THE BASE MOUNT SOLD SERARATELY (QMTR-BM) 4 5 6 DESCRIPTION 1 1 1 1 1 1 QTY.
BI 7.2.3-40 4 Jan-2020, Rev 13 5 WRITTEN PERMISSION OF QUICK MOUNT PV IS PROHIBITED. 4 COPYRIGHT © 2020 QUICK MOUNT PV 7 2 3 3 7 6 5 4 DO NOT SCALE DRAWING THIS EDGE TOWARDS ROOF RIDGE RACKING NOT INCLUDED PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF QUICK MOUNT PV. ANY REPRODUCTION IN PART OR AS A WHOLE WITHOUT THE BASE MOUNT ASSEMBLY SOLD SEPARATELY (QMTR-BM) 4 5 6 1 1 1 1 1 1 QTY.
BI 7.2.3-40 5 Jan-2020, Rev 13 5 WRITTEN PERMISSION OF QUICK MOUNT PV IS PROHIBITED. 4 COPYRIGHT © 2020 QUICK MOUNT PV 1 2 3 3 THIS EDGE TOWARDS ROOF RIDGE 6 5 4 3 2 DO NOT SCALE DRAWING RACKING NOT INCLUDED PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF QUICK MOUNT PV. ANY REPRODUCTION IN PART OR AS A WHOLE WITHOUT THE BASE MOUNT ASSEMBLY SOLD SEPARATELY (QMTR-BM) 4 5 6 1 DESCRIPTION 1 1 1 1 1 1 QTY.
925-478-8269 | www.quickmountpv.com | tech@quickmountpv.com 2700 Mitchell Dr. | Walnut Creek, CA 94598 BI 7.2.3-40 Jan-2020, Rev 13 ©2019 by Quick Mount PV. All rights reserved.
