MSDS

ManualsBrandsQuicksilver ManualsMarine Accessories12 Oz. Phantom Black Gloss Enamel Spray Paint

Material name: PHANTOM BLACK 92 802878Q 1

Revision date: 01-29-2016 Issue date: 01-26-2016

SDS U

1 / 13

Identification

Product

identifier

Other means of

identification

Product

Code

Recommended

use

SAFETY DATA SHEET

PHANTOM BLACK Aerosol 92 802878Q 1

126-3213Q

Not available.

Manufacturer/Importer/Supplier/Distributor

information

Manufacturer

Company

name

Mercury Marine

Address

P.O. Box 1939

Fond du Lac, WI 54935

United States

Telephone

General Assistance (920) 929-5040

Emergency

phone number

Chemtrec Phone 800-424-9300 (U.S. only)

Emergency

phone number

Chemtrec Phone 703-527-3887 (outside U.S.)

2. Hazard(s)

identification

Physical

hazards

Health

hazards

Environmental

hazards

OSHA defined

hazards

Label

elements

Flammable aerosols

Gases under pressure

Skin corrosion/irritation

Serious eye damage/eye irritation

Carcinogenicity

Reproductive toxicity

Specific target organ toxicity, single exposure

Specific target organ toxicity, repeated

exposure

Hazardous to the aquatic environment, acute

hazard

Hazardous to the aquatic environment,

long-term hazard

Not classified.

Category 2

Liquefied gas

Category 2

Category 2A

Category 2

Category 3 narcotic effects

Category 1

Category 3

Signal word

Danger

Hazard statement

Flammable aerosol. Contains gas under pressure; may explode if heated. Causes skin irritation.

Causes serious eye irritation. May cause drowsiness or dizziness. Suspected of causing cancer.

Suspected of damaging fertility or the unborn child. Causes damage to organs through prolonged

or repeated exposure. Harmful to aquatic life. Harmful to aquatic life with long lasting effects.

Precautionary

statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not

spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn,

even after use. Do not breathe mist or vapor. Wash thoroughly after handling. Do not eat, drink or

smoke when using this product. Use only outdoors or in a well-ventilated area. Avoid release to

the environment. Wear protective gloves/protective clothing/eye protection/face protection.

Summary of content (13 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Product Code PHANTOM BLACK Aerosol 92 802878Q 1 126-3213Q Recommended use Not available. Manufacturer/Importer/Supplier/Distributor information Manufacturer Telephone Mercury Marine P.O. Box 1939 Fond du Lac, WI 54935 United States General Assistance (920) 929-5040 Emergency phone number Emergency phone number Chemtrec Phone Chemtrec Phone 800-424-9300 (U.S. only) 703-527-3887 (outside U.S.
PAGE 2
Response If on skin: Wash with plenty of water. If inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If exposed or concerned: Get medical advice/attention. Call a poison center/doctor if you feel unwell. If skin irritation occurs: Get medical advice/attention. If eye irritation persists: Get medical advice/attention.
PAGE 3
Unsuitable extinguishing media Do not use water jet as an extinguisher, as this will spread the fire. Specific hazards arising from the chemical Contents under pressure. Pressurized container may explode when exposed to heat or flame. During fire, gases hazardous to health may be formed.
PAGE 4
8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Value ACETONE (CAS 67-64-1) PEL CARBON BLACK (CAS 1333-86-4) ETHYLBENZENE (CAS 100-41-4) PEL 2400 mg/m3 1000 ppm 3.
PAGE 5
US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value MINERAL SPIRITS (CAS 8052-41-3) MINERAL SPIRITS (CAS 64741-65-7) MINERAL SPIRITS (CAS 8052-41-3) MINERAL SPIRITS (CAS 64741-65-7) N-BUTANE (CAS 106-97-8) Ceiling 1800 mg/m3 TWA 400 mg/m3 TWA 350 mg/m3 TWA 100 ppm TWA PROPANE (CAS 74-98-6) TWA ZIRCONIUM OCTOATE (CAS 22464-99-9) STEL 1900 mg/m3 800 ppm 1800 mg/m3 1000 ppm 10 mg/m3 TWA 5 mg/m3 US.
PAGE 6
9. Physical and chemical properties Appearance Physical state Liquid. Form Aerosol. Liquefied gas. Color Not available. Odor Not available. Odor threshold Not available. pH Not available. Melting point/freezing point -305.68 °F (-187.6 °C) estimated Initial boiling point and boiling range -43.78 °F (-42.1 °C) estimated Flash point -156.0 °F (-104.4 °C) estimated Evaporation rate Not available. Flammability (solid, gas) Not applicable. Upper/lower flammability or explosive limits 1.
PAGE 7
Hazardous decomposition products No hazardous decomposition products are known. 11. Toxicological information Information on likely routes of exposure May cause damage to organs through prolonged or repeated exposure by inhalation. May cause Inhalation drowsiness and dizziness. Headache. Nausea, vomiting. Skin contact Causes skin irritation. Eye contact Causes serious eye irritation.
PAGE 8
Components Species Test Results Rat > 25 ml/kg Mouse 680 mg/l, 2 Hours Rat 658 mg/l, 4 Hours Rat > 1442.847 mg/l, 15 Minutes Dermal LD50 Rabbit > 43 g/kg Inhalation LC50 Mouse 3907 mg/l, 6 Hours Rat 6350 mg/l, 4 Hours Mouse 1590 mg/kg Rat 3523 - 8600 mg/kg Oral LD50 N-BUTANE (CAS 106-97-8) Acute Inhalation LC50 PROPANE (CAS 74-98-6) Acute Inhalation LC50 XYLENE (CAS 1330-20-7) Acute Oral LD50 * Estimates for product may be based on additional component data not shown.
PAGE 9
Components Species Test Results ACETONE (CAS 67-64-1) Aquatic Crustacea EC50 Water flea (Daphnia magna) 10294 - 17704 mg/l, 48 hours Fish LC50 Rainbow trout,donaldson trout (Oncorhynchus mykiss) 4740 - 6330 mg/l, 96 hours 1.37 - 4.4 mg/l, 48 hours ETHYLBENZENE (CAS 100-41-4) Aquatic Crustacea EC50 Water flea (Daphnia magna) Fish LC50 Fathead minnow (Pimephales promelas) 7.
PAGE 10
Transport hazard class(es) Class Subsidiary risk Label(s) Packing group Special precautions for user Special provisions Packaging exceptions Packaging non bulk Packaging bulk IATA UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Label(s) Packing group Environmental hazards Special precautions for user Other information Passenger and cargo aircraft Cargo aircraft only IMDG UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Label(s) Packing gro
PAGE 11
IATA; IMDG General information Avoid transport on vehicles where the load space is not separated from the driver's compartment. Ensure vehicle driver is aware of the potential hazards of the load and knows what to do in the event of an accident or an emergency. Before transporting product containers: Ensure that containers are firmly secured. Ensure cylinder valve is closed and not leaking. Ensure valve outlet cap nut or plug (where provided) is correctly fitted.
PAGE 12
Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and Chemical Code Number ACETONE (CAS 67-64-1) 6532 Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c)) ACETONE (CAS 67-64-1) DEA Exempt Chemical Mixtures Code Number 35 %WV ACETONE (CAS 67-64-1) 6532 FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace ACETONE (CAS 67-64-1) Low priority US state regulations US.
PAGE 13
International Inventories Country(s) or region Australia Inventory name Australian Inventory of Chemical Substances (AICS) On inventory (yes/no)* Yes Canada Domestic Substances List (DSL) Canada Non-Domestic Substances List (NDSL) China Inventory of Existing Chemical Substances in China (IECSC) Europe European Inventory of Existing Commercial Chemical Substances (EINECS) No Europe European List of Notified Chemical Substances (ELINCS) No Japan Inventory of Existing and New Chemical Substance