QP Series Model QP-10 Parts Manual Record of Change 201 This manual contains important safety information and must be carefully read in its entirety and understood prior to installation by all personnel who install, operate and/or maintain this product. On-line product registration, parts ordering and warranty information is available at www.quincycompressor.com Manual No.
TABLE OF CONTENTS INTRODUCTION This manual provides information for the Model QP-10 reciprocating compressor, per Record of Change 201. Serial Number Identification...................................2 Ordering Replacement Parts..................................2 The Model QP-10 is an aircooled, two stage, two cylinder, pressure lubricated compressor, with up to 175 PSI continuous pressure capability. It has a 5" low pressure bore and a 2.75" high pressure bore, with a 3.5" stroke.
Serial Number Identification Quin-Cip lubricant Refer to the chart below to order Quin-Cip-D or Quin-Cip lubricant from your local authorized Quincy distributor. The unit serial number identification tag is located on the air tank top plate. The basic compressor serial number decal is located on the side of the crankcase opposite the oil fill side.
CRANKSHAFT GROUP 116174-002 QP-10 2022201501, July 2014 Quincy Compressor 3 3501 Wismann Lane, Quincy IL - 62305-3116
CRANKcase GROUP 2021090303 Sterling Blue Oil & Filters Kit 2022103501 Item # Qty. 1 1 3 qt.
bearing carrier GROUP 2024400460 Gasket Set 114772 Item # Qty. 1 1 1 1 1 1 1 3 Part Number 111781-001 111274-002 114585 114586 114599 114583 114584 112708-908 Description oil seal gasket, head to valve plate gasket, cylinder to valve plate gasket, head to valve plate gasket, cylinder to valve plate gasket, crankcase to brg.
connecting rod & piston group 116176X002 (low pressure) QP-10 2022201501, July 2014 Quincy Compressor 6 3501 Wismann Lane, Quincy IL - 62305-3116
CONNECTING ROD & PISTON GROUP 116177X002 (high pressure) Sterling Blue Ring Kit 2022104600 Item # Qty.
cylinder & head group 116178 (without head unloaders) QP-10 2022201501, July 2014 Quincy Compressor 8 3501 Wismann Lane, Quincy IL - 62305-3116
QP-10 2022201501, July 2014 9 110258B080 drive belt 116162K valve repair kit 116163K valve repair kit 2 1 1 Description Part Number Item # Qty.
CONTROL PIPING SCHEMATICS QP-10 2022201501, July 2014 Quincy Compressor 10 3501 Wismann Lane, Quincy IL - 62305-3116
PILOT VALVEs 113708 Series Pilot Valve (continuous run operation) 110998 Series Pilot Valve (dual control operation) Add dash # listed below to 113708 (per pressure setting) to obtain correct pilot valve. Add dash # listed below to 110998 (per pressure setting) to obtain correct pilot valve.
SUCTION VALVE UNLOADER ASSEMBLIES Installation The pilot valve is mounted directly into the air tank. Compressors in the field, not equipped with these controls, can be converted. Consult your local Quincy distributor for assistance with conversion procedures.
typical unit repair parts list The parts listed here are for standard QP-10 units and may or may not be applicable to specially built units. Check with your local authorized Quincy distributor for parts that can be used for custom built units. Make sure the components you order are rated within the safe operating limits of your system. If you are doubtful about which components to order, contact your local Quincy distributor.
typical unit repair parts list The parts listed here are for standard QP-10 units and may or may not be applicable to specially built units. Check with your local authorized Quincy distributor for parts that can be used for custom built units. Make sure the components you order are rated within the safe operating limits of your system. If you are doubtful about which components to order, contact your local Quincy distributor.
QUINCY COMPRESSOR STANDARD TERMS AND CONDITIONS TITLE & LIEN RIGHTS: The equipment shall remain personal property, regardless of how affixed to any realty or structure. Until the price (including any notes given therefore) of the equipment has been fully paid in cash, Seller shall, in the event of Buyer’s default, have the right to repossess such equipment.
Reciprocating / Systems: E-mail: Website: 217.222.7700 info@quincycompressor.com quincycompressor.