Operating instructions

ManualsBrandsR.H. Peterson ManualsDomestic AppliancesD1-25 Series

SAFETY WARNINGS & CODES

INSTALLER: Leave these instructions with consumer.

CONSUMER: Retain for future reference.

INSTALLATION AND OPERATING

INSTRUCTIONS

IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION

DELUXE GOURMET

UNIBODY SLIDE-IN

11 SERIES

Unit in enclosure with optional oven hood and

side burner accessories shown

DANGER:

IF YOU SMELL GAS:

1. Shut off the gas to the appliance.

2. Extinguish any open ﬂ ame.

3. Open lid if equipped with an oven.

4. If odor continues, keep away from the

appliance and Immediately call your gas

supplier or Fire Brigade.

WARNING:

1. Do not store or use Petrol or other

ﬂ ammable vapors and liquids in the

vicinity of this or any other appliance.

2. A propane cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

Robert H. Peterson Co. • 14724 East Proctor Ave. • City of Industry, CA 91746

CODE AND SUPPLY REQUIREMENTS: This

barbecue must be installed in accordance with all

applicable local,national, and international codes

and ordinances.

This appliance and its individual shutoff valves must

be disconnected from the gas supply piping system

when testing the system at pressures in excess of

½ psig (3.5 kPa).

This appliance must be isolated from the gas supply

piping system by closing its individual manual

shutoff valves during any pressure testing of the

gas supply system at pressures up to and including

½ psig (3.5 kPa).

(See last page for Model Number and Serial Number

information.)

WARNING

ACCESSIBLE PARTS MAY BE VERY HOT. KEEP

YOUNG CHILDREN AWAY.

All electrical outlets in the vicinity of the barbecue

must be properly grounded in accordance with

local, national, or international codes, which ever

is applicable.

Keep all electrical supply cords and fuel supply

hoses away from any heated surface.

Certiﬁ ed to CEN/BCEN 498: 1997, 484: 1998

This gas appliance for use in GB and IE

FOR OUTDOOR USE ONLY

WARNING

Improper installation, adjustment, alteration,

service or maintenance can cause injury

or property damage. Refer to this manual.

For assistance or additional information

consult qualiﬁ ed, professional installer,

service agency, or the gas supplier.

REV 1 - 0609201134

L-C2-24206

Summary of content (18 pages)

PAGE 1
DELUXE GOURMET UNIBODY SLIDE-IN 11 SERIES INSTALLATION AND OPERATING INSTRUCTIONS INSTALLER: Leave these instructions with consumer. CONSUMER: Retain for future reference. Unit in enclosure with optional oven hood and side burner accessories shown IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION SAFETY WARNINGS & CODES DANGER: IF YOU SMELL GAS: 1. 2. 3. 4. WARNING: 1. Do not store or use Petrol or other flammable vapors and liquids in the vicinity of this or any other appliance.
PAGE 2
TABLE OF CONTENTS SAFETY WARNINGS & CODES TABLE OF CONTENTS PRODUCT DATA TABLE AND GAS TYPE SPECIFICATIONS PARTS LIST PLANNING FOR INSTALLATION OF YOUR DELUXE SERIES BARBECUE FIRE MAGIC DELUXE GOURMET SERIES BARBECUE ORIFICE CONVERSION AIR SHUTTER ADJUSTMENT SAFETY INFORMATION AND WARNINGS COMMON GAS EU CONNECTORS COMMON GAS EU CONNECTOR DIAGRAMS INSTALLING YOUR FIRE MAGIC DELUXE GOURMET SERIES BARBECUE SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS CHECKING AND CONVERTING GAS TYPE LIGHTING (IGNITION) INST
PAGE 3
PARTS LIST Item Description 1. GRILL, STAINLESS STEEL or GRILL, PORCELAINIZED STEEL or GRILL, PORCELAINIZED CAST IRON 2. FLAVOR GRID 3. AIR SHUTTER, GAS BARBECUE or SPRING, AIR SHUTTER 4. ORIFICE, NAT GAS 5. ORIFICE, L.P. GAS 6. BURNER VALVE MANIFOLD ASSEMBLY 7. FIRE MAGIC BARBECUE KNOBS (2) or PORCELAIN FACE w/FASTENERS 8. STAINLESS STEEL FACE w/FASTENERS 9. DRIP TRAY ASSEMBLY 10. IGNITOR ASSEMBLY or GAS LINE w/COMPRESSION NUTS & SLEEVE 11. DRIP TRAY, BARBECUE ASSEMBLY 12.
PAGE 4
PLANNING FOR INSTALLATION OF YOUR DELUXE SERIES BARBECUE WHERE TO INSTALL YOUR BARBECUE Fire Magic barbecues are designed for outdoor use only. the covered area. Installation in fully-enclosed patio areas is not recommended. WARNING Built-in models must be installed in masonry or other type of fireproof enclosure. The unit is not insulated, and therefore must be installed with 18" (45.
PAGE 5
FIRE MAGIC DELUXE GOURMET SERIES BARBECUE ORIFICE CONVERSION Perform the following checks before installing your Deluxe Gourmet barbecue: CHECK FUEL ORIFICES FOR PROPER SIZE Your Fire Magic Deluxe Gourmet barbecue is equipped with fuel orifices for natural gas, unless otherwise indicated. To use with propane gas, you must install smaller orifices to avoid hazardous overheating. (Refer to Table 1 for correct orifice size.) 1. Remove the cooking grid and flavor grid from your barbecue. 2.
PAGE 6
AIR SHUTTER ADJUSTMENT MAIN BURNER AIR SHUTTER ADJUSTMENT Important: Tab Dimple Partially open Fig. 6-1 The air shutters must be adjusted after installation. If not, this appliance may not light, heat evenly, or cook properly. Notch Flame off ports (Turn tabs) airair shutters are accessed by carefully sliding Main burner burner shutters are easily accessed by the unit forward in the enclosure. The air air shutters shutters are are removing the front panel (face).
PAGE 7
SAFETY INFORMATION AND WARNINGS This barbecue is for outdoor use only. Turn off the gas supply at the gas container after use. Do not use an appliance, which is leaking, damaged or which does not operate properly. This appliance shall be located a minimum of 0.5 meters from combustible construction. The gas cylinders shall be changed in a clear outside location, away from any sources of ignition, such as naked flames, pilots, and electric fires and away from other people.
PAGE 8
COMMON GAS EU CONNECTORS Hose Connectors Used in Europe Figures Countries Germany Austria Belgium Denmark Spain Finland France Greece Ireland Iceland Italy Luxembourg Norway Netherlands Portugal United Kingdom Sweden Switzerland A B C D E F G H ISO 228-1 ISO 7-1 x x x x x 1) x x4) 5) x2) x 1) 6 mm diameter. 2) 8 mm diameter. 3) For appliances built into a unit. 4) 13 mm diameter with d1=5 mm, d2=9 mm, l=24 mm. 5) 6 mm diameter with d1=5.5 mm, d2=6.5 mm.
PAGE 9
COMMON GAS EU CONNECTOR DIAGRAMS The main types of gas connectors used in the EU are shown below in Fig. 9-1 A through H. (All dimensions shown in millimeters.
PAGE 10
INSTALLING YOUR FIRE MAGIC DELUXE GOURMET SERIES BARBECUE CONNECT THE GAS SUPPLY TO THE BARBECUE a. You will need an approved flex connector (attached before shipping) to bring the gas supply from the gas line stub to the valve manifold. WARNING A rubber or plastic connector will rupture or leak, resulting in an explosion or serious injury, if used inside the barbecue enclosure. b. With the gas supply shut OFF, slide the clamp ring over the gas supply hose. c.
PAGE 11
SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE GAS CYLINDER. When operating this appliance with a propane gas cylinder these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. CYLINDER AND CONNECTOR REQUIREMENTS AND SPECIFICATIONS a.
PAGE 12
CHECKING AND CONVERTING GAS TYPE This barbecue comes from the factory configured for one type of gas as marked on the label behind the barbecue face plate. WARNING HAZARDOUS OVERHEATING WILL OCCUR IF A NATURAL GAS ORIFICE IS USED WITH PROPANE GAS. IF YOU ARE NOT SURE THE CORRECT ORIFICES ARE INSTALLED, OR IF AN ORIFICE CHANGE IS NECESSARY, REFER TO THE FOLLOWING INSTRUCTIONS. Converting this barbecue to burn a different type of gas requires a conversion kit from the factory.
PAGE 13
LIGHTING (IGNITION) INSTRUCTIONS Read entire instructions before lighting and follow these instructions each time you light the barbecue. MANUAL LIGHTING ELECTRONIC LIGHTING 1. Open all lids and remove all covers from the burners CAUTION: Always wait 5 minutes for gas to you wish to light. clear after any unsuccessful lighting attempt. 2. Turn all gas control knobs to their OFF positions. 3. Turn on the gas at its source. 1. Follow steps 1 through 4 (left).
PAGE 14
ACCESSORIES USING THE GRILL SCRAPER WARMING RACK The triangular stainless steel piece with serrated edges is designed to be used as a tool to quickly and easily scrape food particles and drippings off the grill after barbecuing. To use it, simply align one of the edges of the scraper so that the cooking grid bars fit into the grooves in the serrated edge, and then scrape it along the length of the cooking grid. Repeat as needed. The warming rack (Fig. 14-2) is packed separately with the barbecue.
PAGE 15
BARBECUE CARE & CLEANING CARE AND CLEANING The new Fire Magic barbecue represents the latest and most advanced technology available. In order to continue to enjoy the benefits of this technology and to protect your investment, we recommend the following: Check the burner ports annually for blockage. The inside of the barbecue may be cleaned periodically with oven cleaner if desired. Follow the oven cleaner instructions for proper use.
PAGE 16
This page intentionally left blank.
PAGE 17
REPLACING THE IGNITOR BATTERY 1. Remove the ignitor cover by turning it counter-clockwise. Note: If you have accidently removed the rubber cap, follow the instructions below to replace it. Important: Do not attempt to pull or turn the rubber cap. WRONG!! 2. Remove batter y for replacement. The battery is re-installed with the negative (-) end out. 3. After properly inserting the battery, replace the ignitor cover by turning the cap clockwise. 1. Pull the rubber cap and the inner plastic sleeve apart.
PAGE 18
FIRE MAGIC OUTDOOR GAS BARBECUES LIMITED WARRANTY PLEASE COMPLETE AND RETURN YOUR REGISTRATION CARD WHICH IS INCLUDED WITH YOUR BARBECUE LIFETIME WARRANTY - Fire Magic Cast Stainless Steel Burners, Stainless Steel Rod Cooking Grids and Stainless Steel Housings (including liners, frames, ovens and barbecues faces) are warranted for as long as you own your Fire Magic Barbecue.