Rev. 5/16, Ver.
TABLE OF CONTENTS ASSEMBLY TIPS & WARNINGS 3 PARTS IDENTIFIER 4 5-8 ASSEMBLY INSTRUCTIONS 9 OPERATION INSTRUCTIONS ENJOYING YOUR SAUNA 10 HEALTH & SAFETY WARNINGS 11 CLEANING & MAINTANENCE 12 TROUBLESHOOTING GUIDE 12-13 REPLACEMENT PARTS 14-15 WARRANTY INFORMATION 16 If you would like a French version of this manual, please contact our Customer Service Department at 800-759-0977 or custserv@splashnetxpress.
ASSEMBLY TIPS & WARNINGS • Before you begin, read all assembly instructions and safety warnings carefully. • This sauna requires at least 2 adults to complete assembly. • Remove all of the contents from boxes and verify that you have all of the parts shown on the Parts Note: Some parts may be pre-installed or pre-assembled. may not look exactly like your product. • Retain this Owner’s Manual for future reference.
PARTS IDENTIFIER (NOT TO SCALE) This manual has been modified for this unit; therefore, some images or drawings may not look exactly like your product. For replacement parts please call 800-759-0977 * Refer to REPLACEMENT PARTS (page 14) to determine correct part number when inquiring about replacement parts.
ASSEMBLY INSTRUCTIONS 1. Begin assembly by determining an appropriate location for your sauna – see ASSEMBLY TIPS & WARNINGS for details. Attach the BACK PANEL to the FLOOR by lining up the BACK PANEL with the groove in the back of the FLOOR. 2. Attach the LEFT PANEL to the FLOOR. Buckle the LEFT PANEL to the BACK PANEL. 3. Attach the RIGHT PANEL to the FLOOR. Buckle the RIGHT PANEL to the BACK PANEL.
ASSEMBLY INSTRUCTIONS (CONT.) 4. Slide the BENCH HEATER PANEL into place between the LEFT and RIGHT PANELS. Connect the heater plug. 5. Attach BENCH SEAT with 2” SCREWS. NOTE: When performing Steps 4 and 5 above, you may need to skew the wall out slightly to accommodate inserting the BENCH HEATER PANEL and BENCH SEAT.
ASSEMBLY INSTRUCTIONS (CONT.) 6. Attach the FRONT PANEL to the FLOOR. Buckle the FRONT PANEL to the LEFT and RIGHT PANELS. 7. Lift the ROOF above the sauna, feeding the control panel and heater cables through the corresponding holes. The ROOF fits inside the four PANELS. Secure the ROOF to the sauna with 1-1/8” SCREWS. Connect the control panel (1) and heater plugs (2-4). Feed the main power cable (5) through hole in ROOF and plug securely into the receptacle mounted in the center.
ASSEMBLY INSTRUCTIONS (CONT.) 8. Place the ROOF COVER on top as shown and secure with 3/4” SCREWS. 9. Attach the DOOR HANDLE to the GLASS DOOR. 10. Attach the CABLE COVER into the upper left corner of the sauna using two 1-1/8” SCREWS.
CONGRATULATIONS! The assembly of your sauna is now complete. Please review the Operation Instructions and Health & Safety warnings before using your sauna. To ensure years of trouble-free use, follow the Cleaning & Maintenance guidelines carefully. OPERATION INSTRUCTIONS SAUNA CONTROL PANEL Note: The sauna controls are the same for both the interior and exterior Control Panels. 1. Press POWER to turn ON the sauna. 2. Set the desired TEMPERATURE with the (+) and (-) buttons. 3.
ENJOYING YOUR SAUNA 1. Prior to initial use, wipe down all interior surfaces of the sauna with a damp cloth. 3. Always drink plenty of water before, during and after your sauna session to stay properly hydrated. 4. A normal sauna session should last 30 minutes or less. 5. Allow approximately 25 to 45 minutes for the sauna to warm up before entering. 6. Perspiration will begin within 15 to 25 minutes after entering the sauna. 7. Limit the use of lotions or oils on your body while using your sauna.
HEALTH & SAFETY WARNINGS 1. Review all instructions and warnings before operating your sauna. A sauna is not a toy. Serious injury may result from negligence, intentional misuse and failure to follow safety instructions. 2. Hyperthermia Danger: Hyperthermia occurs when the body absorbs more heat than it can emergency and requires immediate treatment to prevent disability or death. It is very important not to allow your body’s core temperature to rise above 103° F.
CLEANING & MAINTENANCE 1. Always unplug the sauna and allow it to cool down before performing any cleaning or maintenance. 2. Use furniture polish or furniture oil when cleaning the sauna exterior. 3. The sauna interior surfaces should only be wiped down with a damp cloth. Do NOT use 4. As with all natural wood products, variations in the color and the grain as well as irregunatural beauty of the wood and should not be considered defective.
TROUBLESHOOTING GUIDE (CONT.) Problem THE CONTROL PANEL DOES NOT WORK Solution 1. Check that all the connections are tight. 2. If the numbers are scrambled or the buttons are unresponsive, replace the Control Panel. 3. If the temperature indicator does not work or reads “--” or “EP”, replace the Control Panel. Problem THE LIGHTS ARE NOT WORKING 1. Check that all the connections are tight. Solution 2. If one light does not work, replace the bulb. during installation. 3.
REPLACEMENT PARTS Rev. 3/16, Ver. 6 SA2402 1-2 PERSON HEMLOCK SAUNA WITH CARBON HEATERS REF.
16,28 SA2402 15
SAUNA WARRANTY REGISTRATION CARD 1. This sauna has a 7-Year Limited Warranty against defects in materials and workmanship from date of purchase. To receive the warranty, the card below must be filled out completely and returned within thirty (30) days from date of purchase. This 7-Year Limited Warranty covers the wood structure*. Heating elements and all electronics are covered by a 5-Year Limited Warranty. The radio/CD player (if included with your sauna) is covered by a limited 1-Year Warranty.
