OWNER’S MANUAL THREE-PERSON & FOUR-PERSON CORNER SAUNAS SA1312/SA1320 / SA2412DX/SA2420DX
TABLE OF CONTENTS ASSEMBLY TIPS & WARNINGS 3 PARTS IDENTIFIER 4 ASSEMBLY INSTRUCTIONS 5-10 OPERATION INSTRUCTIONS 11 ENJOYING YOUR SAUNA 12 HEALTH & SAFETY WARNINGS 13 CLEANING & MAINTANENCE 14 TROUBLESHOOTING GUIDE 14-15 REPLACEMENT PARTS 16-19 WARRANTY INFORMATION 20 The information contained in this manual is subject to change without notice.
ASSEMBLY TIPS & WARNINGS • Before you begin, read all assembly instructions and safety warnings carefully. • This sauna requires at least 3 adults to complete assembly. • Remove all of the contents from boxes and verify that you have all of the parts shown on the Parts Identifier before you begin assembly. Note: Some parts may be pre-installed or pre-assembled. • This manual is used for the assembly of several sauna models; therefore, some figures or drawings may not look exactly like your product.
PARTS IDENTIFIER (NOT TO SCALE) * Refer to REPLACEMENT PARTS (PAGE 16-19) to determine the correct part number when ordering replacements.
ASSEMBLY INSTRUCTIONS 1. Begin assembly by determining an appropriate location for your sauna – see ASSEMBLY TIPS & WARNINGS for details. Attach the FRONT PANEL to the FLOOR by lining up the FRONT PANEL with the groove in the front of the FLOOR. 2. Attach the LEFT PANEL to the FRONT PANEL by aligning the hooks and sliding the LEFT PANEL down, locking it into place. 3. Attach the RIGHT PANEL to the FRONT PANEL by aligning the hooks and sliding the RIGHT PANEL down, locking it into place.
ASSEMBLY INSTRUCTIONS (CONT.) 4. Attach the LEFT BACK PANEL to the FLOOR. Buckle the LEFT BACK PANEL to the LEFT PANEL. 5. Attach the RIGHT BACK PANEL to the FLOOR. Buckle the RIGHT BACK PANEL to the RIGHT PANEL and to the LEFT BACK PANEL. 6. Attach the FLOOR HEATER to the FLOOR with 1-1/2” SCREWS. Connect the heater plug.
ASSEMBLY INSTRUCTIONS (CONT.) 7. Slide the LONG BENCH HEATER PANEL into place between the LEFT BACK PANEL and RIGHT PANEL. Connect the heater plug. Note: It may be necessary to unbuckle the RIGHT PANEL from the RIGHT BACK PANEL in order to slide the LONG BENCH HEATER PANEL into place. 8. Slide the SHORT BENCH HEATER PANEL into place between the LONG BENCH HEATER PANEL and LEFT PANEL. Connect the heater plug.
ASSEMBLY INSTRUCTIONS (CONT.) 10. Attach SHORT BENCH SEAT with 2” SCREWS. 11. Lift the ROOF above the sauna, feeding the control panel and heater cables through the corresponding holes. Feed the cables for the AM/FM CD PLAYER through the hole in the bottom of the ROOF. Secure the ROOF to the sauna with 1-1/8” SCREWS. Connect the control panel and heater plugs. 12. Feed the main power cable through hole in ROOF COVER. Secure the ROOF COVER with 3/4” SCREWS.
ASSEMBLY INSTRUCTIONS (CONT.) 13. Attach the DOOR HANDLE to the GLASS DOOR. 14. Gently pull the cables for the AM/FM CD PLAYER through the opening in the front of the STEREO SHELF. Attach the STEREO SHELF with 3/4” SCREWS. 15. Plug the controller and antenna into the back of the AM/FM CD PLAYER. Note: The red and white cables are used for an optional video player and can be tucked out of the way. Slide and lock the AM/FM CD PLAYER into the STEREO SHELF.
ASSEMBLY INSTRUCTIONS (CONT.) 17. Attach the CUP HOLDER(S) with 3/4” SCREWS. Note: A sticker indicates the optimal position for this accessory, but attaching it is optional. Consider the position carefully before driving any screws into the sauna interior. 18. Attach the DOUBLE TOWEL HOOK with 3/4” SCREWS. Note: A sticker indicates the optimal position for this accessory, but attaching it is optional. Consider the position carefully before driving any screws into the sauna interior. 19.
OPERATION INSTRUCTIONS SAUNA CONTROL PANEL Note: The sauna controls are the same for both the interior and exterior Control Panels. 1. Press POWER to turn ON the sauna. 2. Set the desired TEMPERATURE with the (+) and (-) buttons. 3. Press and hold both (+) and (-) to switch between °F (Fahrenheit) and °C (Celsius). 4. Set the desired TIME with the (+) and (-) buttons. 5. Press INSIDE or OUTSIDE to turn on or off the corresponding light. 6. When the TIME reaches 00, the heaters will turn OFF automatically.
ENJOYING YOUR SAUNA 1. Prior to initial use, wipe down all interior surfaces of the sauna with a damp cloth. 2. Turn on the sauna and set temperature to 104° F for one hour to burn off any factory dust. 3. Always drink plenty of water before, during and after your sauna session to stay properly hydrated. 4. A normal sauna session should last 30 minutes or less. 5. Allow approximately 10 to 15 minutes for the sauna to warm up before entering. 6.
HEALTH & SAFETY WARNINGS 1. Review all instructions and warnings before operating your sauna. A sauna is not a toy. Serious injury may result from negligence, intentional misuse and failure to follow safety instructions. 2. Hyperthermia Danger: Hyperthermia occurs when the body absorbs more heat than it can dissipate. When the elevated body temperatures are sufficiently high, hyperthermia is a medical emergency and requires immediate treatment to prevent disability or death.
CLEANING & MAINTENANCE 1. Always unplug the sauna and allow it to cool down before performing any cleaning or maintenance. 2. Use furniture polish or furniture oil when cleaning the sauna exterior. 3. The sauna interior surfaces should only be wiped down with a damp cloth. Do NOT use chemicals, abrasive cleaners or solvents on the unfinished interior wood. 4. As with all natural wood products, variations in the color and the grain as well as irregularities such as knots and fine cracks may be present.
TROUBLESHOOTING GUIDE (CONT.) Problem THE CONTROL PANEL DOES NOT WORK Solution 1. Check that all the connections are tight. 2. If the numbers are scrambled or the buttons are unresponsive, replace the Control Panel. 3. If the temperature indicator does not work or reads “--” or “EP”, replace the Control Panel with Temperature Sensor. Problem THE LIGHTS ARE NOT WORKING 1. Check that all the connections are tight. Solution 2. If one light does not work, replace the bulb.
REPLACEMENT PARTS In the event that you need replacement parts, locate your sauna model in the guide below to reference the correct part numbers. It is important to use only the replacement parts specified by the manufacturer. The use of unauthorized substitutes may damage your sauna or cause electrical hazards resulting in injury or fire.
REPLACEMENT PARTS SA1320 FOUR-PERSON CEDAR CORNER SAUNA DESCRIPTION FRONT PANEL with GLASS DOOR LEFT PANEL LEFT BACK PANEL RIGHT PANEL RIGHT BACK PANEL ROOF ROOF COVER FLOOR FLOOR HEATER LONG BENCH SEAT LONG BENCH HEATER PANEL SHORT BENCH SEAT SHORT BENCH HEATER PANEL BACKREST DOOR HANDLE STEREO SHELF AM/FM CD PLAYER with MP3 INPUT CUP HOLDER MAGAZINE RACK DOUBLE TOWEL HOOK COLOR THERAPY CONTROL PANEL OXYGEN IONIZER 2” (50mm) SCREW 1-1/2” (40mm) SCREW 1-1/8” (30mm) SCREW 3/4” (20mm) SCREW 300W HEATER ELEM
REPLACEMENT PARTS SA2412DX THREE-PERSON HEMLOCK CORNER SAUNA DESCRIPTION FRONT PANEL with GLASS DOOR LEFT PANEL LEFT BACK PANEL RIGHT PANEL RIGHT BACK PANEL ROOF ROOF COVER FLOOR FLOOR HEATER LONG BENCH SEAT LONG BENCH HEATER PANEL SHORT BENCH SEAT SHORT BENCH HEATER PANEL BACKREST DOOR HANDLE STEREO SHELF AM/FM CD PLAYER with MP3 INPUT CUP HOLDER MAGAZINE RACK DOUBLE TOWEL HOOK COLOR THERAPY CONTROL PANEL OXYGEN IONIZER 2” (50mm) SCREW 1-1/2” (40mm) SCREW 1-1/8” (30mm) SCREW 3/4” (20mm) SCREW 330W HEATER
REPLACEMENT PARTS SA2420DX FOUR-PERSON HEMLOCK CORNER SAUNA DESCRIPTION FRONT PANEL with GLASS DOOR LEFT PANEL LEFT BACK PANEL RIGHT PANEL RIGHT BACK PANEL ROOF ROOF COVER FLOOR FLOOR HEATER LONG BENCH SEAT LONG BENCH HEATER PANEL SHORT BENCH SEAT SHORT BENCH HEATER PANEL BACKREST DOOR HANDLE STEREO SHELF AM/FM CD PLAYER with MP3 INPUT CUP HOLDER MAGAZINE RACK DOUBLE TOWEL HOOK COLOR THERAPY CONTROL PANEL OXYGEN IONIZER 2” (50mm) SCREW 1-1/2” (40mm) SCREW 1-1/8” (30mm) SCREW 3/4” (20mm) SCREW 300W HEATER
SAUNA WARRANTY REGISTRATION CARD 1. This sauna has a 5-Year Warranty against defects in materials and workmanship. To receive the warranty, the card must be filled out completely and returned. This 5-Year Warranty covers the sauna. The radio in your sauna is covered by a limited 1-Year Warranty. 2. Please notify Blue Wave Products in advance of any sauna warranty claim prior to shipping the sauna back. Contact our warranty claim department at warranty@splashnetxpress.com. 3.