Rev. 5/16, Ver.
TABLE OF CONTENTS ASSEMBLY TIPS & WARNINGS 3 PARTS IDENTIFIER 4 5-10 ASSEMBLY INSTRUCTIONS OPERATION INSTRUCTIONS 11 ENJOYING YOUR SAUNA 12 HEALTH & SAFETY WARNINGS 13 CLEANING & MAINTANENCE 14 TROUBLESHOOTING GUIDE 14-15 REPLACEMENT PARTS 16-23 WARRANTY INFORMATION 24 If you would like a French version of this manual, please contact our Customer Service Department at 800-759-0977 or custserv@splashnetxpress.
ASSEMBLY TIPS & WARNINGS • Before you begin, read all assembly instructions and safety warnings carefully. • This sauna requires at least 3 adults to complete assembly. • Remove all of the contents from boxes and verify that you have all of the parts shown on the Parts Note: Some parts may be pre-installed or pre-assembled. may not look exactly like your product. • Retain this Owner’s Manual for future reference.
PARTS IDENTIFIER (NOT TO SCALE) This manual is used for the assembly of several sauna models; therefore, some images or drawings may not look exactly like your product.
ASSEMBLY INSTRUCTIONS 1. Begin assembly by determining an appropriate location for your sauna – see ASSEMBLY TIPS & WARNINGS for details. Attach the FRONT PANEL to the FLOOR by lining up the FRONT PANEL with the groove in the front of the FLOOR. 2. Attach the LEFT PANEL to the FRONT PANEL by aligning the hooks and sliding the LEFT PANEL down, locking it into place. 3. Attach the RIGHT PANEL to the FRONT PANEL by aligning the hooks and sliding the RIGHT PANEL down, locking it into place.
ASSEMBLY INSTRUCTIONS (CONT.) 4. Attach the LEFT BACK PANEL to the FLOOR. Buckle the LEFT BACK PANEL to the LEFT PANEL. 5. Attach the RIGHT BACK PANEL to the FLOOR. Buckle the RIGHT BACK PANEL to the RIGHT PANEL and to the LEFT BACK PANEL. 6. Attach the FLOOR HEATER to the FLOOR with 1-1/2” SCREWS. Connect the heater plug.
ASSEMBLY INSTRUCTIONS (CONT.) 7. Slide the LONG BENCH HEATER PANEL into place between the LEFT BACK PANEL and RIGHT PANEL. Connect the heater plug. Note: It may be necessary to unbuckle the RIGHT PANEL from the RIGHT BACK PANEL in order to slide the LONG BENCH HEATER PANEL into place. 8. Slide the SHORT BENCH HEATER PANEL into place between the LONG BENCH HEATER PANEL and LEFT PANEL. Connect the heater plug.
ASSEMBLY INSTRUCTIONS (CONT.) 10. Attach SHORT BENCH SEAT with 2” SCREWS. 11. Lift the ROOF above the sauna, feeding the control panel and heater cables through the corresponding holes. Feed the cables for the AM/FM CD PLAYER through the hole in the bottom of the ROOF. Secure the ROOF to the sauna with 1-1/8” SCREWS. Connect the control panel and heater plugs. 12. Feed the main power cable through hole in ROOF and plug securely into receptacle on back of POWER SUPPLY box .
ASSEMBLY INSTRUCTIONS (CONT.) 13. Attach the DOOR HANDLE to the GLASS DOOR. 14. Gently pull the cables for the AM/FM CD PLAYER through the opening in the front of the STEREO SHELF. Attach the STEREO SHELF with 3/4” SCREWS. 15. Plug the controller and antenna into the back of the AM/FM CD PLAYER. Slide and lock the AM/FM CD PLAYER into the STEREO SHELF. 16. Attach the MAGAZINE RACK with 1-1/2” SCREWS. Note: A sticker indicates the optimal position for this accessory, but attaching it is optional.
ASSEMBLY INSTRUCTIONS (CONT.) 17. Attach the CUP HOLDER(S) with 3/4” SCREWS. Note: A sticker indicates the optimal position for this accessory, but attaching it is optional. Consider the position carefully before driving any screws into the sauna interior. 18. Attach the DOUBLE TOWEL HOOK with 3/4” SCREWS. Note: A sticker indicates the optimal position for this accessory, but attaching it is optional. Consider the position carefully before driving any screws into the sauna interior. 19.
OPERATION INSTRUCTIONS SAUNA CONTROL PANEL Note: The sauna controls are the same for both the interior and exterior Control Panels. 1. Press POWER to turn ON the sauna. 2. Set the desired TEMPERATURE with the (+) and (-) buttons. 3. Press and hold both (+) and (-) to switch between °F (Fahrenheit) and °C (Celsius). 4. Set the desired TIME with the (+) and (-) buttons. 5. Press INSIDE or OUTSIDE to turn on or off the corresponding light. 6. When the TIME reaches 00, the heaters will turn OFF automatically.
ENJOYING YOUR SAUNA 1. Prior to initial use, wipe down all interior surfaces of the sauna with a damp cloth. 3. Always drink plenty of water before, during and after your sauna session to stay properly hydrated. 4. A normal sauna session should last 30 minutes or less. 5. Allow approximately 15 to 25 minutes for the sauna to warm up before entering. 6. Perspiration will begin within 15 to 25 minutes after entering the sauna. 7. Limit the use of lotions or oils on your body while using your sauna.
HEALTH & SAFETY WARNINGS 1. Review all instructions and warnings before operating your sauna. A sauna is not a toy. Serious injury may result from negligence, intentional misuse and failure to follow safety instructions. 2. Hyperthermia Danger: Hyperthermia occurs when the body absorbs more heat than it can dissipate. When the elevated body temperatures are sufficiently high, hyperthermia is a medical emergency and requires immediate treatment to prevent disability or death.
CLEANING & MAINTENANCE 1. Always unplug the sauna and allow it to cool down before performing any cleaning or maintenance. 2. Use furniture polish or furniture oil when cleaning the sauna exterior. 3. The sauna interior surfaces should only be wiped down with a damp cloth. Do NOT use chemicals, abrasive cleaners or solvents on the unfinished interior wood. 4. As with all natural wood products, variations in the color and the grain as well as irregularities such as knots and fine cracks may be present.
TROUBLESHOOTING GUIDE (CONT.) Problem THE CONTROL PANEL DOES NOT WORK Solution 1. Check that all the connections are tight. 2. If the numbers are scrambled or the buttons are unresponsive, replace the Control Panel. 3. If the temperature indicator does not work or reads “--” or “EP”, replace the Control Panel. Problem THE LIGHTS ARE NOT WORKING 1. Check that all the connections are tight. Solution 2. If one light does not work, replace the bulb. during installation. 3.
REPLACEMENT PARTS Rev. 5/16 SA1312 THREE-PERSON CEDAR CORNER SAUNA REF.
SA1312 17
REPLACEMENT PARTS SA1320 FOUR-PERSON CEDAR CORNER SAUNA REF.
SA1320 19
REPLACEMENT PARTS SA2412DX Rev. 5/16 THREE-PERSON HEMLOCK CORNER SAUNA REF.
SA2412DX 21
REPLACEMENT PARTS SA2420DX Rev. 5/16 FOUR-PERSON HEMLOCK CORNER SAUNA REF.
SA2420DX 23
SAUNA WARRANTY REGISTRATION CARD 1. This sauna has a 7-Year Limited Warranty against defects in materials and workmanship from date of purchase. To receive the warranty, the card below must be filled out completely and returned within thirty (30) days from date of purchase. This 7-Year Limited Warranty covers the wood structure*. Heating elements and all electronics are covered by a 5-Year Limited Warranty. The radio/CD player (if included with your sauna) is covered by a limited 1-Year Warranty.