ENGLISH RAIS - Manual for RONDO & MINO II USER MANUAL RAIS Rondo & RAIS Mino II 1
ENGLISH RAIS - Manual for RONDO & MINO II Rais Rondo Rais Mino II Rais Mino II soapstone Modified : 2 Date : March 2008 INTRODUCTION.................................................................................................................................................................................. 4 WARRANTY...........................................................................................................................................................................................
approx. 100 490-490-1030 336-289-345 1.5 -12 138 4.7 246 approx. 100 536-482-1027 336-289-345 1.5 -12 207 4.7 246 approx. 100 510-460-1000 336-289-345 1.5 -12 120 4.7 246 Heating area (m2): Stove’s width/depth/height (mm): Combustion chamber’s width/depth/height (mm): Recommended amount of wood when fuelling (kg): (Distributed on 2-3 logs of wood of approx. 25 cm) Min. uptake / Min.
ENGLISH RAIS - Manual for RONDO & MINO II Convection RAIS stoves are convection stoves. This means that the stove’s back and side panels are not over-heated. Convection means that there is a circulation of air, which ensures that the heat is distributed more evenly throughout the entire room. The cold air is sucked in at the base of the stove up through the convection channel, which runs along the stove’s combustion chamber.
ENGLISH RAIS - Manual for RONDO & MINO II Chimney The chimney is the driving force which makes the stove function. In order for the stove to perform satisfactorily the chimney height must be sufficient to ensure the correct draught of 14 to 18 Pa so as to clear the products of combustion and prevent problems of smoke emanating into the room when firing. NOTE: A chimney height of not less than 4.5 metres measured vertically from the outlet of the stove to the top of the chimney should be satisfactory.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Installation When installing the wood burning stove, there are some rules which MUST be followed: Producent RAIS A/S, Industrivej 20, 9900 Frederikshavn, Danmark 04 EN 13240:2001+A2:2004 Anordning til træ The stove must be set up and installed in accordance with all current national and local rules and regulations. Local authorities and a chimney specialist should be contacted prior to set up.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH Adjustment of chimney connection The stove is always delivered for top connection, but can be changed to rear connection as follows: RAIS - Manual for RONDO & MINO II Remove the casing knock-out. Remove baffle plate and smoke diverter (see cleaning and care). Remove protective cover and seal and place over the hole on the top - make sure that the seal is positioned properly. Tighten the assembly using the 3 M6 nuts.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Assembly of soapstone sides Installation of soapstone (RAIS Mino II Soapstone) Install the fitting for the soapstone as well as the spring square using the supplied lowhead screws. Ensure that the left fitting is used for the left side stone. Install the right fitting on the right soapstone in the same way.
ENGLISH RAIS - Manual for RONDO & MINO II Install right and left soapstone using the supplied pointed screws. The soapstone is twisted into place with the aid of the spring square, which must be fixed firmly against the back panel. 16 ENGLISH RAIS - Manual for RONDO & MINO II Fit the baking compartment stone and the top plate. The top plate is placed on top of the side stones. At the bottom of the top plate there are 2 holes, which must be placed on top of the two pointed screws.
ENGLISH RAIS - Manual for RONDO & MINO II Installation distance in case of combustible wall ENGLISH RAIS - Manual for RONDO & MINO II To find out whether the wall next to where the stove is going to be installed is flammable, you should contact your building contractor or the local building authorities. 360° swivel base - normally placed as a The hearth should be able to accommodate the weight of the stove. The chimney must be independently supported by wall brackets or a ceiling support plate.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II For the Installer Operating instructions Finally before firing the stove for the first time a check should be made to ensure that the assembly and stove installation has been satisfactory and that there are no leaks in any seals in the appliance and appliance connections to the chimney.
ENGLISH RAIS - Manual for RONDO & MINO II Drying and storage Drying wood takes time: proper air drying takes approx. 2 years. Here are some tips: Store the wood sawn, split and stacked in an airy, sunny place, which is protected against rain (the south side of the house is particularly suitable). Store the firewood stacks at a hand’s breadth apart, as this ensures that the air flowing through takes the moisture with it.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II First usage A careful start pays off. Start with a small fire, so that the wood burning stove can get accustomed to the high temperature. This gives the best start and any damage is avoided. Be aware that a strange but harmless odour and smoke concoction may emanate from the surface of the stove, the first time you fire up. This is because the paint and materials need to harden.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Lighting and fuelling To light the stove, use alcohol briquettes or similar, as well as approx. 2 kg of firewood, split into kindling sticks. Set the air damper to the fully open position. When the flames are clear - after approx. 5-10 min. - close the door. Damper - see adjustment of air damper. TIPS before firing up: Open a door or window close to the wood burning stove.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Cleaning and care Interruption of operation The wood burning stove and the chimney must be serviced by a chimney sweep once a year. During cleaning and care, the stove must be cold. Smoke spillage around door: If the glass is sooty: - Moisten a piece of paper or newspaper, dip it in the ash, and rub the sooty glass with it. - Now rub with a piece of paper and the glass will become clean.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Accessories and spare parts RAIS Mino II If spare parts other than those recommended by RAIS are used, the warranty is voided. Soapstone plate for baking compartment All replaceable parts can be bought as spare parts from your RAIS distributor. See the following spare parts diagrams for the individual products.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Spare parts diagram - Mino II Pos. Number Item no.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Spare parts diagram - RAIS Mino II Soapstone Pos. Number Item no.
ENGLISH RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II Spare parts diagram - RAIS Rondo Pos. Number Item no.
ENGLISH 38 RAIS - Manual for RONDO & MINO II ENGLISH RAIS - Manual for RONDO & MINO II 39
RAIS A/S Industrivej 20 DK-9900 Frederikshavn www.rais.
