Crazy Cart Owner’s Manual Read and understand this entire manual before allowing child to use this product! For assistance contact Razor. DO NOT RETURN TO STORE. NOTE: Manual illustrations are for demonstration purposes only. Illustrations may not reflect exact appearance of actual product. Specifications subject to change without notice. Please have your 19 character product I.D. code ready before contacting Razor for warranty assistance and/or replacement parts. Product I.D.
Contents Safety Warnings............................................................................................1-2 Before You Begin.............................................................................................. 2 Assembly and Set-Up / Pre-Ride Checklist...................................................... 3 How to operate the Crazy Cart......................................................................4-5 Repair and Maintenance.........................................................
Safety Warnings PROPER RIDING ATTIRE Always wear proper protective equipment, such as an approved safety helmet (with chin strap securely buckled). A helmet may be legally required by local law or regulation in your area. Elbow pads and kneepads, a long-sleeved shirt, long pants and gloves are recommended. Always wear athletic shoes (laceup shoes with rubber soles), never ride barefooted or in sandals, and keep shoelaces tied and out of the way of the wheels, motor, and drive system.
Assembly and Set-Up Turn power switch off before conducting any maintenance procedures. q Charging the Battery Your Crazy Cart may not have a fully charged battery; therefore you must charge the battery prior to use. • Initial charge time: 12 hours. • Recharge time: up to 12 hours, even if the light turns green. Recommended maximum charging time is 24 hours. • Always charge the battery immediately after riding. • Fully charge battery before storing for extended periods of time.
HOW to OPERATE THE CRAZY CART Before you ride this exciting new product, take the time to learn about how it moves the way it moves. Familiarize yourself with these riding hints and tips so that your experiences with the Crazy Cart and allow you to maximize fun while keeping in control. Notice: This product is equipped with a safety button that will not allow the accelerator pedal to engage until the button is depressed, even if the power switch is “on”.
HOW to OPERATE THE CRAZY CART Drift Bar for Adjustable Rear Casters The rear wheels on the Crazy Cart are mounted on casters, like RipStik wheels. By altering the angle of the support for these wheels, the Crazy Cart can either “track” in the same direction as the drive wheel is going or allow the rear end to “drift” in response to turning or acceleration forces.
Repair and Maintenance Turn power switch off before conducting any maintenance procedures. WARNING: Failure to properly install and tighten the screws, nuts and bolts that affix the steering wheel and seat can cause you to lose control and crash. q Front Wheel/Chain Replacement Note: Front wheel hardware sequence 7-3 7-2 7-2 7-3 7-1 7-4 1 Using a Phillips screw driver, remove the four (4) screws on the right side of the motor cover (side of the foot pedal throttle) and remove cover.
Repair and Maintenance q Battery Care and Disposal Do not store in freezing or below freezing temperatures. To properly maintain your battery and ensure maximum battery life, carefully read the “Charging the Battery” section on page 3 of this owner’s manual. CONTAINS SEALED LEAD ACID BATTERIES. BATTERIES MUST BE RECYCLED. Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an environmentally safe manner.
Troubleshooting Problem Possible Cause Solution Product does not run. Undercharged battery. Charge the battery. A new battery should have been charged for at least 12 hours before using the product for the first time and up to 12 hours after each subsequent use. Safety button is not depressed. Depress safety button. Check all connectors. Make sure the charger connector is tightly plugged into the charging port and that the charger is plugged into a functioning wall outlet. Charger is not working.
Crazy Cart Parts Keep your Crazy Cart running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Specifications subject to change without notice.) 1. Incline Protect Wheel 10. Headset (Upper/Lower) 19. On/Off Switch 2. Chain 11. Steering Wheel 20. Base Cover (Right/Left) 3. Chain Tensioner 12. Safety Belt 21. Rear Axle/Drift Bar 4. Chain Guard 13. Seat 22. Rear Caster 5. Front Fork 14. Safety Button 23. Rear Wheels 6.
NOTICE: INSURANCE YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS SCOOTER/ELECTRIC RIDE-ON PRODUCT. TO DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT.
FCC COMPLIANCE This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. Note: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules.