Instructions / Assembly

Pb
Pb
Red
Black
REPAIR AND MAINTENANCE
7
5 Remove two (2) motor housing
screws using the Phillips screwdriver.
6 Using a 13 mm wrench, loosen the outside locknut
(9-7). Use a 13 mm wrench to prevent the inside nut
(9-4) from turning. Remove wheel/hub motor.
7 To install the replacement wheel/hub motor, reverse
steps 1 through 7.
Note:
Motor Control Module
Red
1
Blue
Black
1
Brown
Note: When re-inserting the motor
wires into the connector, make sure
the red wire connects to the blue
wire and the black wire connects to
the brown wire.
WARNING: If a battery leak
develops, avoid contact with the
leaking acid and place the damaged
battery in a plastic bag. Refer to
the disposal instructions at left. If
acid comes into contact with skin
or eyes, flush with cool water for at
least 15 minutes and contact
a physician.
WARNING: Battery posts,
terminals and related accessories
contain lead and lead compounds.
Wash your hands after handling.
In the US and Canada only:
For more information regarding
recycling of rechargeable batteries,
call toll free 1-800-822-8837,
or visit http://www.call2recycle.org
WARNING: Risk of fire–no user serviceable electrical parts.
Battery Care and Disposal
Do not store in freezing or below freezing temperatures. To properly maintain your battery and ensure maximum
battery life, carefully read the “Charging the Battery” section on page 4 of this owner’s manual.
CONTAINS SEALED LEAD-ACID BATTERY. BATTERY MUST BE RECYCLED.
Disposal: Your Razor product uses sealed lead-acid battery which must be recycled or disposed of in an
environmentally safe manner. Do not dispose of a lead-acid battery in a fire. The battery may explode or leak.
Do not dispose of a lead-acid battery in your regular household trash. The incineration, land filling or mixing of
sealed lead-acid batteries with household trash is prohibited by law in most areas. Return exhausted battery to
a federal or state approved lead-acid battery recycler or a local seller of automotive batteries. If you live in Florida
or Minnesota, it is prohibited by law to throw away lead-acid batteries in the municipal waste stream.
Charger
The charger supplied with the electric scooter should be regularly examined for damage to the cord, plug,
enclosure and other parts and in the event of such damage, the product must not be charged until it has been
repaired or replaced.
Use ONLY with the recommended charger.
Not intended for use at elevations greater than 2000 m above sea level.
Wheels
Wheels and drive system are subject to normal wear and tear. It is the responsibility of the user to periodically inspect
wheels for excess wear and replace hub motor components as required.
Replacement Parts
The most frequently requested replacement parts are available for purchase at some Razor retail partners. For the
complete selection of replacement parts visit shop.razor.com.
Repair Centers
For a list of authorized Razor repair centers:
• Check online at www.razor.com.
• Additional Customer Service contact information is listed on the back of this manual.
4 Remove motor cable wires from
connector using an awl.