Side Burner User Manual

Model #

A - Width B - Depth C - Height

RSB1 8 1/2" 16 1/2" 2"

RSB2 12" 19" 9"

RJCSSB 10 3/4" 21" 8"

RDB1 12" 19" 8"

RDB1 EL 12" 19" 8"

ADB1 13 3/8" 23 1/4" 10 1/2"

ASB2 13 3/8" 23 1/4" 10 1/2"

Propane Gas Connection:

RCS side burners have 3/8" male flare connection

Minimum horizontal clearance from sides and back of the unit to adjacent vertical combustible construction extending above top of unit, 24 inches

from side and 24 inches from back. Do not locate under any overhead combustible construction.

Side Burner Owner's Manual

Safety and Installation Instructions

Side Burner Installation

This gas side burner must be installed in accordance with all local codes and is for outdoor use only.

If installation is planned in an area with no local codes, the gas side burner must be installed in accord with the National Fuel Gas Code ANSI

Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or CSA B149.1 natural gas and propane installation code.

CALIFORNIA PROPOSITION 65 WARNING

The burning of gas cooking fuel generates some by-products which are on the list of substances which are known by the State of California to

cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize

exposure to these substances, always operate the unit according to the use and care manual, ensuring you provide good ventilation when cooking

with gas.

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage, and void the warranty. Read

the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment.

Clearances

Combustible Construction

Natural Gas Connection:

Appliance pressure 4” W.C.

Appliance pressure 10” W.C.

Inlet pressure 5” – 14” W.C.

Inlet pressure 11” – 14” W.C.

Non-Combustible Construction

Sides of the side burner can be 0” from non-combustible wall, below the cooking surface.

Built-in Installation

For non-combustible cabinet enclosure installation only. Follow the cut-out dimensions as shown. ALL outdoor kitchen cabinets MUST include

ventilation. We recommend 12 square inches of opening for each (running) 4 feet of counter top. See Item # RVNT1 for approved vents.

Cut Out Dimensions

www.RCSGasGrills.com

PAGE 1
Side Burner Owner's Manual Safety and Installation Instructions Side Burner Installation This gas side burner must be installed in accordance with all local codes and is for outdoor use only. If installation is planned in an area with no local codes, the gas side burner must be installed in accord with the National Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or CSA B149.1 natural gas and propane installation code.
PAGE 2
Check for leaks with a soapy water solution every time the cylinder is replaced or reconnected. All leaks must be corrected immediately. Never use an open flame to check for leaks. Lighting Instructions Before Lighting: Check gas line/hose for signs of wear, abrasion or cuts. If evidence of deterioration is visible, replace the part prior to use. If you smell gas, check for leaks. If odor continues, immediately call for service. Keep your face and body away from the burner top when lighting or operating.