Instruction Manual 36V Lithium Push Mower PMLI-14 This Manual Contains Important Information Regarding: SAFETY, ASSEMBLY, OPERATION AND MAINTENANCE. Please Read And Keep This Book For Future Reference.
1 2 3 4 7 5 8 9 10 6 8 11 16 17 18 2 12 13 14 15
1 Safety button 11 Battery pack 2 Switch lever 12 Safety key 3 Handle knob 13 Power cord for charger 4 Cable clip 14 Charger 5 Battery cover 15 Mulching Insert 6 Height adjustment lever 16 Battery temperature indicator 7 Upper push bar 17 Battery power indicator 8 Grass catcher indicator 18 Switch button for indicator 9 Grass catcher bag 10 Quick fold lever Intended Use ■ This lawn mower is designed for residential use ONLY, not for commercial use.
Not applicable. Wait until all machine components have completely stopped before touching them. The blade continues to rotate after the machine is switched off. A rotating blade can cause injury. Do not mow in the rain or leave the lawnmower outdoors when it is raining. Beware electric shock hazard. Keep away from cords. Only use the battery charger indoors. Battery charger contains a safety transformer. ■ Never allow children or people unfamiliar with these instructions to use the lawnmower.
■ Switch on the lawnmower according to instructions and with feet well away from the blade. ■ Do not put hands or feet near or under rotating parts. Keep clear of discharge opening at all times. ■ Never pick up or carry the lawnmower while the motor is running.
Product Specification Lawn mower Model: PMLI-14 Mains:36V, 4Ah Charging time: 2-3 hours Cutting width: 380mm No load speed:3000rpm Cutting system: rotary blade Cutting height: 6 settings, 25-75mm Grass catcher bag capacity:40L Battery Pack Art.No.:LI-14BATT Battery type: Lithium Battery Battery Voltage:36V,4Ah Charging time: 2-3 hours Battery Charger Art.No.:PAS42AA-W04201000 Input:100-240V-50/60Hz Output voltage:42V Charging current:1.
2. Securing cable by using cable clips Figure 3 Secure the cable from the motor to the switch assembly by using four cable clips – two are fixed on upper push bar, the other two are fixed on lower push bar. See Figure 3 3. Mount the grass catcher bag Before mounting the grass catcher bag, the motor must be switched off. Figure 4 Figure 5 Figure 4 Raise the safety flap as far as possible and place the grass catcher on two hooks of the under deck.
Operation 1. TIPS for the use of this battery-powered mower Under normal conditions, the battery should run for approximately 30 minutes per single charge. This operation time and the area that can be mowed by this battery-powered mower is dependent on various factors. These are: Figure 6 Type of lawn Battery-powered lawnmowers are suitable for lawns which are mowed frequently, for example, Battery-powered mowers are not suitable for infrequently-mowed meadows or similar.
2. Charging and caring for the battery Important: Before charging the battery, read all instructions and warning markings in this manual and on your mower, Do not operate your mower until you have read and understand all instructions and the battery has been fully charged. Battery: This mower comes with a Lithium battery from the factory. The battery is rated for 36volts and 4 amp – hours. The battery is completely maintenance-free.
Important: Always connect the charger to the battery first, and then plug it into the wall outlet. When unplugging, reverse the process: unplug the charger from the wall outlet first and then disconnect it from the battery. Charging the battery inside and outside the mower Figure 9-10 1. Insert charging plug into battery power socket, see Figure 9 2. Plug the charger into a wall outlet, see Figure 10 Figure 9 Figure 10 During the charging process, the charger will be warm to the touch.
4. Starting and Stopping Attention! Rotary cutting blade, The blade continues to rotate for a few seconds after the machine is switched off. Allow the motor/blade to stop rotating before switching “on” again. Do not rapidly switch off and on. Starting Figure 11 Before starting make sure the battery pack is put into the mower and put the safety key into its socket.
Figure 13 Instructions for mowing without the grass catcher bag We recommend: The grass should not be too high nor too wet! Mow slowly Do not cut grass more than 20mm (see Figure 14) Mowing tips: If grass residue is left in the discharge opening, pull mower backwards about 1-2m so that the grass residue can drop out downwards.
Two green lights go on, mid battery capacity Three green lights go on, full battery capacity Red light indicates the battery temperature is too high. Please wait until the red light is off before restarting the charging process. (See figure 14 and 15) Maintaining and Storing WARNING! ALWAYS switch off the mower, remove safety key from its socket and remove battery before performing any adjustments, maintenance, blade change or repairs to your mower. 1.
Tools & supplies needed: 14 mm socket wrench. Gloves or rag to protect your hands Wear heavy gloves to protect your hands when holding, removing and attaching blades. 1. Remove the safety key from its socket and remove battery. If you are charging the battery, first disconnect the charger from the electrical (wall) outlet. 2. While holding the handle bars, turn the mower over on its right side to expose the blade. 3. Place the socket wrench over the blade nut. 4.
Remove safety key from its socket. Always store the mower in an environment where the temperature is between –4°F (–20°C) and +104°F (+40°C). Make sure the storage temperatures will never be outside these limits. For long-term storage, store your battery in an environment where the temperature is lower, since the battery self-discharges slower at low temperatures. Store the mower in a dry environment. Do not store it on a floor that may be damp or subject to accidental flooding.
Mower stops while mowing (for reasons other than releasing the trigger bar) Mower is hard to push The battery has been completely depleted. this could indicate that the battery pack is needing be replaced. Contact your service provider. Recharge the battery immediately or replace it with a fully charged battery. The grass may be too high for the cutting height. Raise the cutting height or narrow your cutting swath and try again. The blade, mower deck or rear discharge plate may be clogged with debris.
collecting grass poorly The grass is too long or the mower is cutting too low The mower is moving too fast Raise the cutting height. The rear clogged Remove the safety key from the socket and remove battery, turn the mower over on the right side and clean away any debris from the rear discharge plate and below the deck Clean the grass catcher. discharge may be The mesh holes on the grass catcher are clogged The grass catcher bag is wet. Slow down.
LIMITED ONE-YEAR WARRANTY The RECHARGE MOWER® PMLI-14 is warranted for one (1) year against defects in materials and workmanship when put to personal residential household use. This warranty refers to “personal residential household use” as the NON-COMMERCIAL, residential use and further excludes misuse, abuse, accidents or damage due to lack or inadequate maintenance. The RECHARGE MOWER® PMLI-14 is fit for the ordinary purpose which this product type is intended. Drive by Solar Inc.
