MSDS
1
Material Safety Data Sheet
VINYL SPACKLING COMPOUND – ½ Pint
0532HD, Quart 0534HD, Gallon 0531 - Tubs
MSDS No. 0035HD
Emergency Phone No.
(918)825-5744
SECTION 1 – PRODUCT NAME & MANUFACTURER INFORMATION
PRODUCT NAME
VINYL SPACKLING COMPOUND – ½ Pint, Quart, Gallon Tubs
MANUFACTURER’S NAME &
TELEPHONE NUMBER
Red Devil, Inc. 918-825-5744
STREET ADDRESS
4175 Webb Street
CITY / STATE / ZIP
Pryor, Oklahoma 74361
SECTION 2 – COMPOSITION / HAZARDOUS INGREDIENTS
% TLV PEL UNITS
PRODUCT CONSISTS OF:
Aqueous Vinyl Acrylic Emulsion (mixture) < 20 NE NE
Soda Lime Borosilicate ** (65997-17-3) < 4 NE NE
Calcium Carbonate ** (1317-65-3) (as nuisance particulate, total) < 70 10 15 mg/m3
Amino Methyl Propanol (AMP-95) (124-68-5) < 0.10 NE NE
Propylene Glycol (57-55-6) **** < 1 400*** NE ppm
Non-hazardous ingredients * <20 NA NA
*Unlisted ingredients are not considered hazardous under the OSHA Hazard Communication Standard (29 CFR
1910.1200). ** Inhalation not likely due to products physical state. *** TWA. **** Contains no EG.
Calculated VOC: < 1.5 %/wt, < 25 g/L. CARB Compliance: Yes. Prop 65 Ingredients: Yes (See Section 16)
SECTION 3 – HAZARDS IDENTIFICATION
PRIMARY
ROUTE(S) OF
ENTRY
Skin Contact Skin Absorption Eye Contact Inhalation Ingestion
EMERGENCY
OVERVIEW
White to slightly off-white paste w/ a slightly sweet odor. May cause eye, skin, nose, throat & respiratory tract irritation.
EFFECTS OF
OVEREXPOSURE
May cause eye, skin, nose, throat & respiratory tract irritation. Harmful if swallowed. Inhalation of dust may result in pulmonary & respiratory damages.
Prolonged or repeated exposure to dust may cause lung damage. This product may contain small amounts of vinyl acetate, identified by IARC as a
potential carcinogen; however there should be minimal risk when used w/ ventilation adequate to keep the atmospheric concentration of vinyl acetate
below the recommended exposure limit.
MEDICAL
CONDITIONS
AGGRAVATED BY
EXPOSURE
If dry sanded, asthma & asthma-like conditions may worsen from prolonged or repeated exposure to dust.
SECTION 4 – FIRST AID MEASURES
SKIN CONTACT
Wash w/ soap & water for @ least 15 minutes. Get medical attention if symptoms persist. Remove & wash contaminated clothing.
EYE CONTACT
Immediately flush w/ large quantities of water for @ least 15 minutes until irritation subsides. Get medical attention.
INHALATION
If inhaled, remove to fresh air. If breathing difficult, leave area to obtain fresh air. If breathing remains difficult, get medical attention.
INGESTION
DO NOT INDUCE VOMITING. Get immediate medical attention.