MSDS

2
SECTION 5 – FIRE FIGHTING MEASURES
FLAMMABLE
Yes No
EXTINGUISHING
MEDIA
Carbon Dioxide, Dry Chemical, Foam, Water Fog
FLASHPOINT (°F) &
METHOD
>200F (Seta Closed Cup)
UPPER EXPLOSIVE LIMIT
(% BY VOLUME)
NE
LOWER EXPLOSIVE LIMIT
(% BY VOLUME)
NE
AUTOIGNITION
TEMPERTURE (°F)
NE
UNUSUAL FIRE & EXPLOSION
HAZARDS
None known.
SPECIAL
FIREFIGHTING
PROCEDURES
Wear self-contained breathing apparatus pressure demand (NIOSH approved or equivalent) & full protective gear. Use water spray to
cool exposed surfaces.
SECTION 6 – ACCIDENTAL RELEASE MEASURES
PROCEDURES
Wear proper protective equipment (Section 8). Use absorbent material or scrape up dried material & place in approved container.
SECTION 7 – HANDLING & STORAGE
HANDLING PROCEDURES &
EQUIPMENT
Keep out of reach of children & pets. Do not take internally. Do not breathe vapors. Use only w/ adequate ventilation. Wash
thoroughly after handling. Avoid contact w/ eyes, skin & clothing. Open windows & doors to ensure cross-ventilation &
fresh air during application & curing.
STORAGE REQUIREMENTS
Close container after each use. Store containers away from excessive heat & freezing. Do not store @ temperatures above 120F. Store
away from caustics & oxidizers.
SECTION 8 – EXPOSURE CONTROL / PERSONAL PROTECTION
RESPIRATORY
In case of insufficient ventilation, wear suitable respiratory equipment. A NIOSH-approved air purifying respirator w/ organic vapor cartridge may be
necessary under circumstances where concentrations are expected to exceed exposure limits.
EYEWEAR
Goggles or safety glasses w/ side shields.
CLOTHING /
GLOVES
Rubber gloves. Other protective equipment not required under normal use.
HYGENIC
PRACTICES
Remove & wash contaminated clothing before re-use. Wash hands before breaks & @ end of workday.
SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE
Paste
ODOR &
APPEARANCE
Mild acrylic/ammonia. Smooth paste.
SPECIFIC GRAVITY
Approximately 1.50 to 2.0
VAPOR DENSITY
(AIR=1)
Heavier than air
EVAPORATION RATE
> 1 (Butyl Acetate = 1)
BOILING RANGE (°F)
> 212F
pH
Approximately 7 to 10
SOLUBILITY IN
WATER
Appreciable, before cure.
VAPOR PRESSURE (MM
Hg)
NE
%/WT VOLATILE
(TNV)
< 20
SECTION 10 – STABILITY AND REACTIVITY
STABILITY
Yes No
Stable under normal conditions.
INCOMPATABILITY
Yes No
Incompatible w/ strong oxidizers.
CONDITIONS
TO AVOID
Excessive heat & freezing.
HAZARDOUS
POLYMERIZATION/HAZARDOUS
DECOMPOSITION PRODUCTS
Hazardous polymerization will not occur under normal conditions. Normal decomposition products, ie: Carbon Dioxide, Carbon
Monoxide.