FAQ

ManualsBrandsRedi Poxy ManualsBathEpoxy Tile Setting Material 12lb Set

REDIPOXY Adhesive Part A

917127 Version #: 02 Revision date: 25-November-2013 Issue date: 25-November-2013

SDS US

1 / 7



SAFETY DATA SHEET

1. Identification

Product identifier REDIPOXY Adhesive Part A

Other means of identification

Not available.

Recommended use

Adhesive.

Recommended restrictions

None known.

Manufacturer / Importer / Supplier / Distributor information

Company Name

Tile Redi USA LLC

Address

4450 NW 126

Ave

Coral Springs, FL 33065

Telephone

(203) -393-0010

Contact person

Steve Fine

Website

www.tileredi.com

Emergency phone number

Call CHEMTREC day or night

USA/Canada - 1.800.424.9300

Mexico - 1.800.681.9531

Outside USA/Canada

1.703.527.3887

2. Hazard(s) identification

Physical hazards

Health hazards

Environmental hazards

OSHA defined hazards

Label elements

Not classified.

Skin corrosion/irritation

Serious eye damage/eye irritation

Sensitization, skin

Specific target organ toxicity, single exposure

Hazardous to the aquatic environment, acute

hazard

Hazardous to the aquatic environment,

long-term hazard

Not classified.

Category 1B

Category 1

Category 3 respiratory tract irritation

Category 3

Signal word

Danger

Hazard statement

Causes severe skin burns and eye damage. May cause an allergic skin reaction. May cause

respiratory irritation. Harmful to aquatic life with long lasting effects.

Precautionary statement

Prevention

Use only outdoors or in a well-ventilated area. Do not breathe mist or vapor. Wash thoroughly

after handling. Wear protective gloves/protective clothing/eye protection/face protection.

Contaminated work clothing should not be allowed out of the workplace. Avoid release to the

environment.

Response

If swallowed: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all

contaminated clothing. Rinse skin with water/shower. If skin irritation or rash occurs: Get medical

advice/attention. Wash contaminated clothing before reuse. If inhaled: Remove person to fresh air

and keep comfortable for breathing. Immediately call a poison center/doctor. If in eyes: Rinse

cautiously with water for several minutes. Remove contact lenses, if present and easy to do.

Continue rinsing.

Storage

Store in a well-ventilated place. Keep container tightly closed. Store locked up.

Disposal

Dispose of contents/container in accordance with local/regional/national/international regulations.

Hazard(s) not otherwise

classified (HNOC)

Not classified.

3. Composition/information on ingredients

Mixtures

Summary of content (21 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier REDIPOXY Adhesive Part A Other means of identification Not available. Recommended use Adhesive. Recommended restrictions None known. Manufacturer / Importer / Supplier / Distributor information Company Name Address Telephone Contact person Website Emergency phone number Tile Redi USA LLC 4450 NW 126th Ave Coral Springs, FL 33065 (203) -393-0010 Steve Fine www.tileredi.com Call CHEMTREC day or night USA/Canada - 1.800.424.9300 Mexico - 1.800.
PAGE 2
Chemical name CAS number % 68953-36-6 70 - 75 Tetraethylene pentamine 112-57-2 8 - 10 2-Piperazin-1-ylethylamine 140-31-8 3-5 2,4,6-Tris-(dimethylaminometh yl)- phenol 90-72-2 1-3 Fatty acids, tall-oil, reaction products with tetraethylenepentamine Composition comments All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4.
PAGE 3
Conditions for safe storage, including any incompatibilities Keep container tightly closed. Store in a cool and well-ventilated place. Store away from incompatible materials (See Section 10). 8. Exposure controls/personal protection Occupational exposure limits US. Workplace Environmental Exposure Level (WEEL) Guides Components Type Value Form Tetraethylene pentamine (CAS 112-57-2) TWA 5 mg/m3 Aerosol. 1 ppm Aerosol.
PAGE 4
Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature Not available. Decomposition temperature Viscosity Not available. Not available. 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. Chemical stability Material is stable under normal conditions. Possibility of hazardous reactions No dangerous reaction known under conditions of normal use.
PAGE 5
No data available. Chronic effects 12. Ecological information Harmful to aquatic life with long lasting effects. Ecotoxicity Components Species Test Results 2-Piperazin-1-ylethylamine (CAS 140-31-8) Aquatic Fish LC50 Persistence and degradability Fathead minnow (Pimephales promelas) 1950 - 2460 mg/l, 96 hours No data is available on the degradability of this product. Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) Tetraethylene pentamine (CAS 112-57-2) Not available.
PAGE 6
Label(s) Packing group Environmental hazards Marine pollutant EmS Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Further information 8 III No F-A, S-B Read safety instructions, SDS and emergency procedures before handling. This substance/mixture is not intended to be transported in bulk. IATA classification is not relevant as the material is not transported by air. 15.
PAGE 7
International Inventories Country(s) or region Australia Inventory name Australian Inventory of Chemical Substances (AICS) On inventory (yes/no)* Yes Canada Domestic Substances List (DSL) Canada Non-Domestic Substances List (NDSL) China Inventory of Existing Chemical Substances in China (IECSC) Yes Europe European Inventory of Existing Commercial Chemical Substances (EINECS) Yes Europe European List of Notified Chemical Substances (ELINCS) Japan Inventory of Existing and New Chemical Substan
PAGE 8
SAFETY DATA SHEET 1. Identification Product identifier Other means of identification REDIPOXY Adhesive Part B Not available. Recommended use Adhesive. Recommended restrictions None known. Manufacturer / Importer / Supplier / Distributor information Company Name Address Telephone Contact person Website Emergency phone number Tile Redi USA LLC th 4450 NW 126 Ave Coral Springs, FL 33065 (203) - 393-0010 Steve Fine www.tileredi.com Call CHEMTREC day or night USA/Canada - 1.800.424.9300 Mexico - 1.800.
PAGE 9
Reaction product: Bisphenol F-(epichlorohydrin); epoxy resin 28064-14-4 14-25 Alkyl(C12-14) glycidyl ether 68609-97-2 9-15 Composition comments All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4. First-aid measures Inhalation Move to fresh air. Call a physician if symptoms develop or persist. Skin contact Remove contaminated clothing immediately and wash skin with soap and water.
PAGE 10
Appropriate engineering controls Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. Provide eyewash station.
PAGE 11
. Toxicological information Information on likely routes of exposure May cause discomfort if swallowed. Ingestion No adverse effects due to inhalation are expected. Inhalation Skin contact Irritating to skin. May cause an allergic skin reaction. Eye contact Irritating to eyes. Rash. Irritant effects. Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity May cause discomfort if swallowed.
PAGE 12
Contaminated packaging Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. 14.
PAGE 13
Superfund Amendments and Reauthorization Act of 1986 (SARA) Immediate Hazard - Yes Hazard categories Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed. SARA 311/312 Hazardous chemical Yes SARA 313 (TRI reporting) Not regulated. Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.
PAGE 14
NFPA Ratings 0 2 References Disclaimer 0 HSDB® - Hazardous Substances Data Bank Registry of Toxic Effects of Chemical Substances (RTECS) The information in this (M)SDS was obtained from sources which we believe are reliable but cannot guarantee. Additionally, your use of this information is beyond our control and may be beyond our knowledge. Therefore, the information is provided without any representation or warranty express or implied.
PAGE 15
SAFETY DATA SHEET 1. Identification Product identifier Other means of identification REDIPOXY Adhesive Part C Not available. Recommended use Adhesive. Recommended restrictions Workers (and your customers or users in the case of resale) should be informed of the potential presence of respirable dust and respirable crystalline silica as well as their potential hazards. Appropriate training in the proper use and handling of this material should be provided as required under applicable regulations.
PAGE 16
Composition comments All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4. First-aid measures Inhalation Move to fresh air. Call a physician if symptoms develop or persist. Skin contact Wash off with soap and water. Get medical attention if irritation develops and persists. Eye contact Rinse with water. Get medical attention if irritation develops and persists. Ingestion Rinse mouth. Get medical attention if symptoms occur.
PAGE 17
US. OSHA Table Z-3 (29 CFR 1910.1000) Components Type Value Form 2.4 millions of particle Respirable. US. ACGIH Threshold Limit Values Components Type Value Form Silica sand (CAS 14808-60-7) Titanium dioxide (CAS 13463-67-7) TWA 0.025 mg/m3 Respirable fraction. TWA 10 mg/m3 US. NIOSH: Pocket Guide to Chemical Hazards Components Type TWA Value 5 mg/m3 Form Calcium carbonate (CAS 471-34-1) Silica sand (CAS 14808-60-7) TWA 10 mg/m3 0.05 mg/m3 Total Respirable dust. Respirable.
PAGE 18
Not available. Explosive limit - upper (%) Not available. Vapor pressure Vapor density Not available. Relative density 2.3 Solubility(ies) Solubility (water) Insoluble in water. Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature Not available. Decomposition temperature Not Viscosity available. Not available. 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport.
PAGE 19
Carcinogenicity May cause cancer. In 1997, IARC (the International Agency for Research on Cancer) concluded that crystalline silica inhaled from occupational sources can cause lung cancer in humans. However in making the overall evaluation, IARC noted that "carcinogenicity was not detected in all industrial circumstances studied. Carcinogenicity may be dependent on inherent characteristics of the crystalline silica or on external factors affecting its biological activity or distribution of its polymorphs.
PAGE 20
15. Regulatory information US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. CERCLA Hazardous Substance List (40 CFR 302.4) Not listed.
PAGE 21
Country(s) or region New Zealand Inventory name New Zealand Inventory On inventory (yes/no)* Yes Philippines Philippine Inventory of Chemicals and Chemical Substances (PICCS) Yes United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory Yes *A "Yes" indicates this product complies with the inventory requirements administered by the governing country(s).