User Manual

ManualsBrandsRevoace ManualsPropane Gas Grills2-Burner Space Saver Gas Grill, Stainless and Black, GBC1705WV

OWNER’S MANUAL

Table of Contents

Important Safeguards ...........................................................Page 2

Expanded View & Hardware .......................................................... 4

Assembly Instructions............................................................... 5

Installing LP Gas Tank............................................................... 9

Installing Natural Gas Line ........................................................... 9

Operating Instructions............................................................... 9

Cleaning and Care ................................................................ 10

Limited Warranty ................................................................. 11

Troubleshooting .................................................................. 12

The use and installation must conform with local codes or, in the absence of local codes, with either the

National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1,

or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/

NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP

FOR FUTURE REFERENCE.

If you are assembling this unit for someone else, give this manual to them to read and save for future

reference.

California Proposition 65: Combustion by-products produced when using this product contain chemicals

known to the State of California to cause cancer, birth defects, and other reproductive harm.

California Proposition 65: Wash your hands after handling this product.

California Proposition 65: Handling the brass material on this product exposes you to lead, a chemical

known to the State of California to cause cancer, birth defects, or other reproductive harm.

Manufactured in China for: RevoAce Inc. Limited

Hong Kong, China

Outdoor LP Gas Barbecue Grill

Model No. GBC1705WV

DANGER

Never operate this appliance unattended.

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

FOR YOUR SAFETY:

1. Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage.

2. Read the installation, operation, and

maintenance instructions thoroughly

before installing or servicing this

equipment.

3. Failure to follow these instructions could

result in ﬁre or explosion, which could

cause property damage, personal injury, or

death.

4. This instruction manual contains Important

information necessary for the proper

assembly and safe use of the appliance.

5. Read and follow all warnings and

instructions before assembling and using

the appliance.

6. Follow all warnings and instructions when

using the appliance.

7. Keep this manual for future reference.

FOR YOUR SAFETY:

1. Do NOT store or use gasoline or other

flammable liquids or vapors in the vicinity

of this or any other appliance.

2. An LP cylinder not connected for use shall

NOT be stored in the vicinity of this or any

other appliance.

DANGER

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

If you have questions or need assistance during assembly,

please call 1-800-694-0013

GBC1705WV-OM-E-F102

Natural gas conversion

kit (model no. VFK1702W)

available at Walmart or

www.Walmart.ca

Summary of content (12 pages)

PAGE 1
OWNER’S MANUAL Outdoor LP Gas Barbecue Grill Model No. GBC1705WV FOR YOUR SAFETY: 1. Improper installation, adjustment, . alteration, service or maintenance can cause injury or property damage. 2. Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment. 3. Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death. 4.
PAGE 2
Important Safeguards Warning WW This grill is for outdoor use only, and should not be used in a building, garage or any other enclosed area. WW Do NOT operate, light or use this appliance within ten feet (3.05 m) of walls, structures or buildings. WW For residential use only. This grill is NOT for commercial use. WW This grill is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause asphyxiation.
PAGE 3
Important Safeguards Warning WW NG: The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5 kpa). WW This grill is designed to operate at an inlet pressure of: LP gas: 11 inches water column; NG: 7 inches water column. WW Do NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.
PAGE 4
Expanded View 1 4 3 2 6 5 8 9 5 7 10 8 12 14 11 13 16 18 15 19 17 18 21 20 29 22 23 29 25 26 24 27 28 27 Parts List 1 Handle G1205-0307 11 Control Knob Bezel (2)* G1205-200 21 LP Gas Tank Retainer Wire G1205-150 2 Temperature Gauge B0104-JRE 12 Control Knob (2) G0900-080 22 Upper Front Panel G1205-170 3 Warming Rack G1205-010 13 Regulator/Hose Assembly* G1405-090 23 Condiment Holder G0900-160 4 Heat Plate (2) B0212-040 14 QCC Clip* G1205-220 24 Low
PAGE 5
1 Assembly Instructions DO NOT RETURN TO PLACE OF PURCHASE. For assistance, call 1.800.694.0013 toll-free. Please have your owner’s manual and model number available for reference. 2 5 Assemble Left Cart Frame Note: The model number is printed on a label which can be found on the inside door, back or side of the cart assembly. Assembly Tips: 1. Select an area where you will assemble this product. To protect components, choose a smooth surface that’s free of cracks or openings. 2.
PAGE 6
5 B 7 Attach Front Panels and Rear Cart Support x 11 Attach LP Gas Tank Retainer Wire 6 Attach Cart Frame Support Wire G 8 x1 Attach Handle, Control Knobs and Temperature Gauge D x2 H x2 I x2
PAGE 7
9 D 11 Secure QCC Clip x5 E H 10 Attach Grill Body Assembly and Lighting Rod 7 x2 Attach Condiment Basket x1 B 12 C x1 Attach Side Shelves x4
PAGE 8
13 Insert Grease Cup Support and Grease Cup 15 Insert Heat Plates and Cooking Grids 14 Insert Warming Rack Natural gas conversion kit (model no. VFK1702W) available at Walmart or www.Walmart.ca.
PAGE 9
Installing LP Gas Tank To operate, you will need one precision-filled standard grill LP gas tank with external valve threads. 17.9 in. / 45.5 cm 20 lb 9 Kg CAUTION WW LP gas tank must be properly disconnected and removed prior to moving this grill. Inserting LP Gas Tank . Securing LP Gas Tank Place precision-filled LP gas tank upright into the notches in the right cart frame so the tank valve is facing the gas line connection.
PAGE 10
Operating Instructions (continued) Figure 4 5. Spoon several drops of solution, or use a squirt bottle, at all “X” locations (Figures 1 and 3). a. LP: If any bubbles appear, turn LP gas tank valve to “CLOSED,” reconnect and re-test. NG: If any bubbles appear, turn natural gas main valve “OFF,” reconnect and re-test. b. LP: If you continue to see bubbles after several attempts, turn LP gas tank valve to “CLOSED” and disconnect LP gas tank, per “Disconnect LP Gas Tank” section. Contact 1.800.694.
PAGE 11
Cleaning and Care (continued) Cleaning Surfaces 1. 2. 3. 4. Wipe surfaces clean with mild dishwashing detergent or baking soda mixed with water. For stubborn surfaces, use a citrus-based degreaser and a nylon scrubbing brush. Rinse clean with water. Allow to air dry. Figure 6 Burner Flame Conditions Use this chart to see if your burners need to be cleaned. Cleaning Main Burner 1. LP: Turn LP gas tank valve to “CLOSED.” NG: Turn natural gas main valve to “OFF.” 2.
PAGE 12
Troubleshooting Problem Burner will not light using ignitor Burner will not light with match Sudden drop in gas flow or reduced flame height Possible Cause Prevention/Cure LP: Make sure regulator is securely attached to the LP gas tank per “Installing LP gas tank valve is closed LP Gas Tank,” then turn LP gas tank valve to “OPEN” NG main valve is closed NG: Make sure regulator and NG main line are securely attached per “Installing Natural Gas Line,” then turn NG main valve to “ON” LP gas tank is lo