Replacement Parts Guide

ManualsBrandsReznor ManualsHeatingReplacement Pilot Assembly, NG/LP, up to 6,000 ft

Form P-PILOTS, 131133R2, Page 1

IMPORTANT

1. Always include complete heater model and serial number so

that any specification change can be considered for parts

shipment. It can save time and expense.

2. Specifications are subject to change without notice.

3. We reserve the right to substitute functional replacements.

4. Order either by Kit or Component Part No.

Form P-PILOTS

Obsoletes Form 701-B

Pilot Kits and Components

If the replacement pilot changes with the introduction of a Model Series, the Series is indicated in the Selection Table. The

Series indicator is on the heater rating plate; it is the suffix number on the Model Size (Ex: SC400-6; "6" is the Series).

** Spark pilot kits for all indirect-fired products are for use with Model G60, G65, G67, or G770 ignition controllers only. Pilot kits

are not available for other spark ignition systems used on indirect-fired products.

Functional

Replacement Pilots

FIGURE 1 - Vertical Match-

Lit Pilot for Models F and B

Replacement Natural Gas - P/N 110851

Pilot Kits Propane Gas - P/N 110852

Code

P/N

Component Description

96360

Natural Gas Pilot Assembly with orifice, pilot tubing, and

thermocouple; less fitting (Johnson #J994HKA-9731-715)

96361

Propane Gas Pilot Assembly with orifice, pilot tubing, and

thermocouple; less fitting (Johnson #J994HKA-9733-410)

103034

Natural Gas Orifice only, Johnson #9731-715 (brass)

98695

Propane Gas Orifice only, Johnson #9733-410 (black)

98698

Pilot Tubing, 1/8" x O.D. x 18" long, Johnson #B10499-995-11

97572

Compression Fitting, FTG75 (2 required when replacing pilot tubing

)

84761

Thermocouple, 24", #K15FA-24D

Natural Propane FIGURE Natural Propane FIGUR

- - - 110854 110854 2

- - - 110853 110853 2

110851 110852 1 110853 110854 2

- - - 110853 110854 2

110855 110856 3 110857 110858 4

110859 110860 5 110861 110862 6

- - - 110857 110858 4

- - - 110861 110862 6

131457 131458 8

- - - 110853 110854 2

110861 110862 6

110863 110864 8 - - -

110859 110860 5 110861 110862 6

- - - 131457 131458 8

- - - 110861 110862 6

- - - 110865 110866 9

RCG 2 - 5 ton - with vertical pilot

- - - 110867 110868 10

- with horizontal pilot

- - - 110861 110862 6

ADF, ADFH with hot surface ignition

- - - 120048 120048 11

RDF -with spark ignition and flame probe

- - - 110869 110869 11

-with spark ignition and ultraviolet sensor

- - - 110918 110918 11

-with hot surface ignition

- - - 120048 120048 11

DV with hot surface ignition

- - - 120048 120048 11

DFA with hot surface ignition

- - - 120048 120048 11

Quick Reference Replacement Pilot Kit Selection Table

(Refer to FIGURES 1-12, pages 1-4, for illustrations and component part numbers.)

Uni t

Heaters

Infrared

EEXL, EEXLB, CEEXL, CEEXLB 125-400

SCA, SCB prior to Series 6

SCA, SCB Series 6

Match Lit Pilot Kits Spark Pilot Kits**Type of

Heater

X, XA, XB, XC, XD, XE, XG XJ, PAK, DFAH, CX, CXE, CPAK

beginning 9/73

Model Designation*/Sizes

T, TR-H 50

T, TR-H 75-200

F, B 25-400

FE, BE 25-400

UA, XL, XLB, CXL, CXLB 30-105

XL, XLB, CXL, CXLB 125-400

EEXL, EEXLB, CEEXL, CEEXLB 30-105

Heating/

Cooling

Direct

Fired

SC, SCE Series 6

RX, REB, RXE, RXJ, CRX, CREB, CRXE, RPAK,CRPAK, SC, SCE,

SCJ prior to Series 6; RPV, RPVE, RPBE, RPVAK, CRPV, CRPVE,

CRPBE, CRPVAK Series 6; RG, CRG, RP, CRP, RGB, CRGB, RPB,

CRPB, RGBL, CRGBL, RPBL, CRPBL, SSCBL

RPV, RPBE, RPVE, RPVAK RPVJ. CRPV, CRPBE, CRPVE,

CRPVAK prior to Series 6

RCG 7-1/2, 10 ton

Duct

Furnaces

and

Packaged

Systems

(Also

applies to

Mode l s

wi th

prefix

"H")

EEDU, HEEDU Series 6

EEDU, HEEDU prior to Series 6

X, XA, XB, XC, XD, XE, XG XJ, PAK, DFAH prior to 9/73

Summary of content (4 pages)

PAGE 1
Form P-PILOTS Obsoletes Form 701-B ® IMPORTANT 1. Always include complete heater model and serial number so that any specification change can be considered for parts shipment. It can save time and expense. 2. Specifications are subject to change without notice. 3. We reserve the right to substitute functional replacements. 4. Order either by Kit or Component Part No.
PAGE 2
Models F/FE/B/BE Model TR 50 Models TR 75-200 Models (H)EEDU Series 6 Application 97534 F/FE/B/BE and (H)EEDU Series 6 TR 75-200 97535 F/FE/B/BE and (H)EEDU Series 6 TR 50 103034 F/FE/B/BE and (H)EEDU Series 6 TR 75-200 98695 F/FE/B/BE and (H)EEDU Series 6 TR 50 98698 Replacement FIGURE 2 - Vertical Spark Pilot Kits Pilot for Unit Heater Models F/FE/B/BE, Infrared Models TR/TR-H, and Duct Furnace Models EEDU/HEEDU Series 6 Code P/N 1 4 1 2 3 2 3 F/FE/B/BE/TR and (H)EEDU Series 6 97572 4 5 98697 9757
PAGE 3
FIGURE 6 - Horizontal Spark Pilots for Models 2 XL, XLB, CXL, CXLB 125-400 5* EEXL, EEXLB, CEEXL, CEEXLB 125-400; EEDU, HEEDU prior to Series 6 Starting 9/73 for X, XA, XB, XC, XD, XE, XG, XJ, PAK, DFAH, CX, CXE, CPAK 3 RX, REB, RXE, RXJ, CRX, CREB, CRXE, RPAK, CRPAK; SC, SCA, SCB, SCE, SCJ Prior to Series 6; RPV, RPVE, RPBE, RPVAK, CRPV, CRPVE, CRPBE, 1 CRPVAK Series 6; RG, CRG, RP, CRP, RGB, CRGB, RPB, CRPB, RGBL, 6* 4 CRGBL, RPBL, CRPBL, SSCBL RCG 2 through 5 ton with horizontal pilot Replacement Natur
PAGE 4
FIGURE 10 - Vertical Spark Pilot for Models RCG 2 - 5 ton with Vertical Pilot 1 5 4 2 Replacement Pilot Kits Code P/N 47484 1 47485 3 2 3 4 6 *See instructions below.