Specification Sheet

ManualsBrandsRheem ManualsDomestic Appliances2-stage

Rheem Prestige Series

™

Two-Stage

Downflow Gas Furnace equipped with

the Comfort Control

System

FORM NO. G11-513 REV. 1

RGLE- Series

80% A.F.U.E.†

Input Rates 75-125 kBTU

✝A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with

Department of Energy test procedures.

• The Rheem Prestige Series

™

Super Quiet 80

™

Two-Stage

Downflow line of downflow gas furnaces is designed for

installation in closets, alcoves, utility rooms, or attics.The

design is certified by CSA International.

• The Comfort Control

System™ provides over 28 on-board

diagnostics and fault history codes by detecting system and

electrical problems. “Call for Service” alert notification is sent

to the thermostat to alert the homeowner of required service.

• Serial Communication Enhanced – When installed with a

Serial Com muni cat ing Condensing Unit and user interface

control (RHC-TST550CMMS) 500 Series thermostat this unit

offers 4 or 2 wire installation, auto-configuration, and diag-

nostic messaging with full communicating capability.

• Patented heat exchanger, constructed of aluminized steel for the

maximum in corrosion resistance and thermal fatigue reliability.

• Low profile “34 inch” [864 mm] design is lighter and easier to

handle, and leaves room for optional equipment.

• Energy efficient and quiet ECM 2+ communicating motor.

• Improves cooling efficiency when matched with rated

condensing unit and coil.

• Constant CFM.

• Seven segment LED for system diagnostics.

• Diagnostic history for troubleshooting.

• Dip switch settings for selectable cooling airflow.

• On-demand dehumidification terminal for improved comfort in

cooling mode.

• Left or right side gas and electric inlet connections.

• All models feature an integrated board with humidifier and

electronic air cleaner hookups.

• Insulated blower compartment, a slow-open gas valve,

specially designed draft inducer motor and blower motor

make it one of the quietest furnaces on the market today.

• Pre-paint galvanized steel cabinet.

• Easy door removal and replacement.

• Molded permanent filter.

• Compatible with single or two-stage thermostat. (For optimal

performance, two-stage thermostat recommended.)

• A variety of cooling coils and plenums designed to use with

Rheem Prestige Series

™

Super Quiet 80

™

Two-Stage Down-

flow gas furnaces are available as optional accessories.

Air

Gas Furnaces

RGLE Series

Annual Fuel Utilization Efficiency -

AFUE

THIS MODEL

ENER UIDE

97%78%

HIGH

MID

82% 88%

80.0%

Summary of content (12 pages)

PAGE 1
Air Gas Furnaces RGLE Series Rheem Prestige Series™ Two-Stage Downflow Gas Furnace equipped with the Comfort Control System 2 RGLE- Series 80% A.F.U.E.† Input Rates 75-125 kBTU ENER UIDE Annual Fuel Utilization Efficiency - AFUE THIS MODEL 80.0% MID 78% 82% HIGH 88% 97% ✝ A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department of Energy test procedures.
PAGE 2
Air Table of Contents RGLE Series TABLE OF CONTENTS Standard & Optional Equipment ......................................................................3 Model Features ..............................................................................................4 Physical Data & Specifications ........................................................................5 Model Number Identification ............................................................................6 Dimensional Data..................
PAGE 3
Air Standard & Optional Equipment RGLE Series COMMUNICATING ECM MOTOR IFC INTEGRATED FURNACE CONTROL TWO-SPEED DRAFT INDUCER MOTOR HEAT EXCHANGER PRESSURE SWITCH IN-SHOT BURNERS DIRECT SPARK IGNITOR FLAME SENSOR STANDARD EQUIPMENT OPTIONAL EQUIPMENT Completely assembled and wired; 2 speed induced draft blower; high and low pressure switches; 2 stage redundant main gas control; blower compartment door safety switch; solid state time on/time off blower control; limit control; transformer; ECM blow
PAGE 4
Air Model Features RGLE Series The Comfort Control 2 System ™ Features: n The Rheem Dual 7-Segment LED Display easily shows system operating status codes and diagnostic codes. n The Status Indication System Diagnostics feature thermostat communication capability and built-in diagnostics. The thermostat communication capability and alerts the homeowner to any necessary service requirements.
PAGE 5
Air Physical Data & Specifications RGLE Series Physical Data and Specifications—Downflow Models U.S. and Canadian Models MODEL NUMBERS RGLE- SERIES 100% High Input–BTU/Hr [kW] ➁ High Heating Capacity–BTU/Hr [kW] ➀ 70% Low Input–BTU/Hr [kW] Low Heating Capacity–BTU/Hr [kW] Heating–Ext. Static Pressure [kPa] Blower (D x W) [mm] ECM Motor H.P. [W] Motor Full Load Amps. Unit Amps Maximum Overcurrent Protection Cooling CFM @ .5" [kPa] E.S.P. (Nominal) [L/s] (Range) Max. E.S.P. (In. W.C.
PAGE 6
Air Model Number Identification RGLE Series Model Number Identification—Downflow Models R G L Rheem Gas Furnace Downflow E 07E Design Heating Input Designation Series Input Electric NOx E = Communicating Ignition Model BTU/HR 07E 10E 12E [ ] Designates Metric Conversions 6 07N 10N 12N 75,000 [22 kW] 100,000 [29 kW] 125,000 [37 kW] A M K R Variations A = Std.
PAGE 7
Air Dimensional Data RGLE Series Dimensions and Clearance to Combustible Material (inches) [mm] REDUCED CLEARANCES (IN.
PAGE 8
Air Blower Performance Data RGLE Series Blower Performance Data MODEL RGLE- BLOWER SIZE (D X W) INCHES [mm] ECM MOTOR H.P. [W] 07A 11 x 7 [279 x 178] 1/2 [373] 07B 11 x 10 [279 x 254] 3/4 [559] 10, 12 11 x 10 [279 x 254] 1 [746] NOTE: See Coil Specification Sheet for coil data. [ ] Designates Metric Conversions 8 BLOWER SPEED HIGH MED-HI MED LOW HIGH MED-HI MED LOW HIGH MED-HI MED LOW CFM [L/s] AIR DELIVERY EXTERNAL STATIC PRESSURE INCHES WATER COLUMN [kPa] .1 [.02]–.8 [.
PAGE 9
Air DOWNFLOW WARNING: Unit design is certified for installation on noncombustible floor. A special factory supplied combustible floor subbase is required when installing on a combustible floor. Failure to install the sub-base may result in fire, property damage and personal injury. COMBUSTIBLE FLOOR BASE DIMENSIONS COMBUSTIBLE FLOOR BASE RXGC-B17 USE WITH FURNACE SIZES RGLE-07EAMK A IN. [mm] 181/4 [457] B IN. [mm] 163/4 [425] C IN.
PAGE 10
Air Limited Warranty RGLE Series GENERAL TERMS OF LIMITED WARRANTY* Rheem will furnish a replacement for any part of this product which fails in normal use and service within the applicable period stated, in accordance with the terms of the limited warranty. *For complete details of the Limited and Conditional Warranties, including applicable terms and conditions, contact your local contractor or the Manufacturer for a copy of the product warranty certificate. 10 Heat Exchanger .........................
PAGE 11
Air Notes RGLE Series 11
PAGE 12
The new degree of comfort.™ In keeping with its policy of continuous progress and product improvement, Rheem reserves the right to make changes without notice. Rheem Heating, Cooling & Water Heating • P.O. Box 17010 Fort Smith, Arkansas 72917 • www.rheem.com Rheem Canada Ltd./Ltée • 125 Edgeware Road, Unit 1 Brampton, Ontario • L6Y 0P5 PRINTED IN U.S.A 10/13 QG FORM NO. G11-513 REV.