Specification Sheet

ManualsBrandsRheem ManualsFurnaceRheem Classic Series: 80% AFUE Single-Stage X-13 Motor

Rheem Classic Plus

™

Super Quiet 80

™

Upflow/Horizontal Gas Furnace

FORM NO. G11-516 REV. 1

RGPT- Series

80% A.F.U.E.†

Input Rates 50-125 kBTU

✝A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with

Department of Energy test procedures.

• The Rheem Classic Plus

™

Super Quiet 80

™

line of upflow/

horizontal gas furnaces are designed for utility rooms, closets,

alcoves, or attics. Because of the Super Quiet 80’s low-profile

34 inch [864 mm] height, the upflow model can also be used

to satisfy most applications that traditionally call for a hori-

zontal furnace.

• The design is certified by CSA International.

• Innovative combustion design results in reliable, efficient

operation at sound levels which provide distinct competitive

advantage.

• Patented Heat Exchanger, constructed of aluminized steel for the

maximum in corrosion resistance and thermal fatigue reliability.

• Low profile “34 inch” design is lighter and easier to handle,

and leaves room for optional equipment.

• Convertible from upflow to horizontal left or right without field

conversion.

• Left or right side gas and electric inlet connections with quick,

simple change.

• Robust and reliable direct spark ignition utilizing remote

sense and an integrated board with humidifier and electronic

air cleaner hookups.

• Insulated blower compartment helps to reduce jacket loss

and noise.

• Pre-paint galvanized steel cabinet.

• Molded permanent filter.

• Grab-holes in doors to aid in easy door removal and

replacement.

• ECM X-13 Blower Motor.

• A variety of cooling coils and plenums designed to use with

Rheem Classic Plus

™

Super Quiet 80

™

gas furnaces are

avail able as optional accessories.

• These furnaces can be installed in an upflow position or laid

on either side in a horizontal position. Field conversion not

required.

Air

Gas Furnaces

RGPT Series

Annual Fuel Utilization Efficiency -

AFUE

THIS MODEL

ENER UIDE

97%78%

HIGH

MID

82% 88%

80.0%

Summary of content (12 pages)

PAGE 1
Air Gas Furnaces RGPT Series Rheem Classic Plus™ Super Quiet 80™ Upflow/Horizontal Gas Furnace RGPT- Series 80% A.F.U.E.† Input Rates 50-125 kBTU ENER UIDE Annual Fuel Utilization Efficiency - AFUE THIS MODEL 80.0% MID 78% 82% HIGH 88% 97% ✝ A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department of Energy test procedures.
PAGE 2
Air Table of Contents RGPT Series TABLE OF CONTENTS Standard & Optional Equipment ......................................................................3 Model Features/Physical Data & Specifications..................................................4 Model Number Identification ............................................................................5 Dimensional Data ........................................................................................6-7 Blower Performance Data ....................
PAGE 3
Air Standard & Optional Equipment RGPT Series DRAFT INDUCER MOTOR HEAT EXCHANGER IN-SHOT BURNERS GAS VALVE DIRECT SPARK IGNITOR REMOTE SENSOR INTEGRATED FURNACE CONTROL X-13 MOTOR STANDARD EQUIPMENT OPTIONAL EQUIPMENT Completely assembled and wired; induced draft blower; pressure switch; redundant main gas control; blower compartment door safety switch; solid state time on/time off blower control; limit control; manual shut-off valve, pressure regulator for natural and L.P.
PAGE 4
Air Model Features/Physical Data & Specifications RGPT Series Model Features • The design is certified by CSA International. • Innovative combustion design results in reliable, efficient operation at sound levels which provide distinct competitive advantage. • Patented heat exchanger, constructed of aluminized steel for the maximum in corrosion resistance and thermal fatigue reliability. • Low profile “34 inch” design is lighter and easier to handle, and leaves room for optional equipment.
PAGE 5
Air Model Number Identification RGPT Series Model Number Identification R G P T Rheem Gas Furnace Upflow/ Horizontal Design Series – 07E Heating Input Designation Electric Ignition NOx Model Input BTU/HR 05E 07E 10E 12E 05N 07N 10N 12N 50,000 [15 kW] 75,000 [22 kW] 100,000 [29 kW] 125,000 [37 kW] A M Variations A = Std.
PAGE 6
Air Dimensional Data RGPT Series Upflow Applications Dimensional Data REDUCED CLEARANCES (IN.
PAGE 7
Air Dimensional Data RGPT Series Horizontal Applications WARNING THIS FURNACE IS NOT APPROVED OR RECOMMENDED FOR INSTALLATION ON ITS BACK, WITH ACCESS DOORS FACING UPWARDS. Dimensional Data REDUCED CLEARANCES (IN.
PAGE 8
Air Blower Performance Data RGPT Series Blower Performance Data MODEL NUMBER RGPTSERIES BLOWER SIZE in INCHES [mm] (D x L) WIRE COLOR MOTOR OUTPUT NUMBER RED YELLOW* PURPLE BLUE BLACK RED YELLOW PURPLE* BLUE BLACK RED YELLOW* PURPLE BLUE BLACK RED YELLOW PURPLE BLUE* BLACK RED YELLOW PURPLE BLUE* BLACK 1 *2* 3 4 5 1 2 *3* 4 5 1 *2* 3 4 5 1 2 3 *4* 5 1 2 3 *4* 5 MOTOR BLOWER H.P.
PAGE 9
Air Accessories RGPT Series EXTERNAL BOTTOM FILTER RACK: RXGF-CB FILTER RACK FILTER SIZES† INCHES [mm] MODEL RXGF-CA RGPT(SIDE) 153/4 x 25 05, 07(A), 07(B) [400 x 635] 153/4 x 25 10 [400 x 635] 153/4 x 25 12 [400 x 635] † Filter racks are shipped without filters. Filters shipped with furnace may be used or a suitable 1" [25.4 mm] filter. *Designates “E” or “N”. RXPF-F01 and F02 FOSSIL FUEL KITS are for use with Rheem Classic Heat Pumps and Super Quiet 80 warm air furnaces.
PAGE 10
Air Limited Warranty RGPT Series GENERAL TERMS OF LIMITED WARRANTY* Rheem will furnish a replacement for any part of this product which fails in normal use and service within the applicable period stated, in accordance with the terms of the limited warranty. *For complete details of the Limited and Conditional Warranties, including applicable terms and conditions, contact your local contractor or the Manufacturer for a copy of the product warranty certificate. 10 Heat Exchanger .........................
PAGE 11
Air Notes RGPT Series 11
PAGE 12
The new degree of comfort.™ In keeping with its policy of continuous progress and product improvement, Rheem reserves the right to make changes without notice. Rheem Heating, Cooling & Water Heating • P.O. Box 17010 Fort Smith, Arkansas 72917 • www.rheem.com Rheem Canada Ltd./Ltée • 125 Edgeware Road, Unit 1 Brampton, Ontario • L6Y 0P5 PRINTED IN U.S.A 10/13 QG FORM NO. G11-516 REV.