Instructions / Assembly

2
Safety Information
Safety Precautions .................. 3-4
Introduction
Local Installation Regulations ...........5
Water Heater Location ................. 5
Installation Instructions
Inspect Shipment ..................... 5
Water Supply Connections ............. 6
Gas Supply. . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Wiring ............................... 7
Typical Installation ..................... 8
TABLE OF CONTENTS
Your safety and the safety of others are very important.
There are many important safety messages in this manual
and on your appliance. Always read and follow all safety
messages.
!
This is the safety alert symbol. Recognize this
symbol as an indication of importan safety
information! This symbol alerts you to safety
hazards that could result in physical harm or
death.
All safety messages will follow the safety alert symbol
and either the word “DANGER”, “WARNING”,
“CAUTION” or “NOTICE”.
These words mean:
!
DANGER
An imminently hazardous
situation that will result in death
or serious injury.
!
WARNING
A potentially hazardous
situation that could result in
death or serious injury and/or
damage to property.
!
CAUTION
A potentially hazardous
situation that may result in
minor or moderate injury.
NOTICE:
Attention is called to observe
a specified procedure or
maintain a specific condition.
READ ALL SAFETY INFORMATION
Operating Instructions
Ignition Instructions .................. 31
Water Temperature ................... 32
Emergency Shut Down ................ 32
User Interface .....................33-39
Troubleshooting
Before You Call For Service ......... 38-46
Alarm and Alert Codes ..............40-46
Customer Service
Parts List ........................... 47
Wiring Diagrams ................ 48
How to Obtain Service Assistance ...... 52
Care and Cleaning
Pressure Switch Inspection ............ 37
Venting Inspection .................... 37
Routine Maintenance ............ 37
Anode Inspection .................... 37
Seasonal Operation .................. 37
Venting System Inspection ............. 37
Vent Installation
Information for Pipe and Fittings .........9
General Venting Information ............ 9
Joining Pipe and Fittings ............ 9-10
Vent Length Information ............ 11-12
Vent Terminal Precautions .......... 13-16
Horizontal Vent Installation .......... 17-19
Vertical Vent Installation ............ 20-22
Concentric Vent Installation ......... 23-29
Installation Checklist .................. 30
Quick Guide for Water Heater Operating Conditions:
Min. Inlet Gas Pressure (at gas valve, during ignition to
full input):
Natural Gas: 3.5 In. WC
LP Gas: 11.0 In. WC
Max. Inlet Gas Pressure (at gas valve, during ignition to
full input):
Natural Gas: 10.5 In. WC
LP Gas: 13.0 In. WC
Electrical:
120 Vac, 60 Hz., 7 amp min. powered required
Basic Clearances for Water Heaters:
To combustibles: 0" for sides and back; 6" for top
Recommended for service: 24" for front and top