Use and Care Manual

ManualsBrandsRIDGID ManualsTools & Hardware18-Volt 2-Amp Hour Hyper Lithium-Ion Battery

18 V LITHIUM-ION

BATTERY PACK

R840083, R840085,

R840086, R840087

SERIES

When battery pack is not in use, keep it away from

other metal objects like: paper clips, coins, keys, nails,

screws, or other small metal objects that can make

a connection from one terminal to another. Shorting

the battery terminals together may cause sparks, burns,

or a fire.

Always remove battery pack from your tool when you

are assembling parts, making adjustments, cleaning,

or when not in use. Removing battery pack will prevent

accidental starting that could cause serious personal

injury.

Always remove battery pack before storing the device.

Always wear eye protection with side shields marked

to comply with ANSI Z87.1. Failure to do so could result

in objects being thrown into your eyes and other possible

serious injuries.

Keep battery pack dry, clean, and free from oil and

grease. Always use a clean cloth when cleaning. Never

use brake fluids, gasoline, petroleum-based products, or

any solvents to clean battery pack.

Save these instructions. Refer to them frequently and

use them to instruct others who may use this tool. If you

loan someone this tool, loan them these instructions also

to prevent misuse of the product and possible injury.

CALIFORNIA PROPOSITION 65

WARNING:

This product contains chemicals, including lead,

known to the State of California to cause cancer, birth

defects and other reproductive harm. Wash hands

after handling.

OPERATION

LITHIUM-ION BATTERY PACKS

Lithium-ion batteries deliver fade free power for their en-

tire run time. Lithium-ion tools will not gradually lose power

due to decreasing battery charge. Instead, power from the

battery pack will drop from full to zero once the full charge

has been drained from the battery. Once this happens, re-

charging of the battery is required. It is not necessary to

drain the battery pack completely before recharging.

BATTERY PROTECTION FEATURES

Lithium-ion battery packs are designed with features that

protect the lithium-ion cells and maximize battery life.

If the tool stops during use, release the trigger to reset and

resume operation. If the tool still does not work, the battery

needs to be recharged.

COLD WEATHER OPERATION

The lithium-ion battery pack can be used in temperatures

down to –4°F (–20°C). Put the battery pack on a tool and use

the tool in a light duty application. After about a minute, the

pack will warm up and begin operating normally.

SAFETY RULES

WARNING!

READ AND UNDERSTAND ALL INSTRUCTIONS.

Failure to follow all instructions listed below, may result

in electric shock, fire and/or serious personal injury.

Battery tools do not have to be plugged into an elec-

trical outlet; therefore, they are always in operating

condition. Be aware of possible hazards when not

using your battery tool or when changing accessories.

Following this rule will reduce the risk of electric shock,

fire, or serious personal injury.

Do not place battery tools or their batteries near fire

or heat. This will reduce the risk of explosion and pos-

sibly injury.

Do not crush, drop or damage battery pack. Do not

use a battery pack or charger that has been dropped

or received a sharp blow. A damaged battery is subject

to explosion. Properly dispose of a dropped or damaged

battery immediately.

Batteries can explode in the presence of a source of

ignition, such as a pilot light. To reduce the risk of seri-

ous personal injury, never use any cordless product in the

presence of open flame. An exploded battery can propel

debris and chemicals. If exposed, flush with water imme-

diately.

Do not charge battery tool in a damp or wet location.

Following this rule will reduce the risk of electric shock.

Charge only with RIDGID 18V dual chemistry battery

chargers. Use of other chargers may result in personal

injury, fire, or damage.

Do not charge in an area of extreme heat or cold. It

will work best at normal room temperature. To reduce

the risk of serious personal injury, do not store outside or

in vehicles.

Under extreme usage or temperature conditions, bat-

tery leakage may occur. If liquid comes in contact with

your skin, wash immediately with soap and water. If

liquid gets into your eyes, flush them with clean water

for at least 10 minutes, then seek immediate medical

attention. Following this rule will reduce the risk of seri-

ous personal injury.

Use this battery pack for RIDGID

® 18V

Lithium-ion cordless products only. Refer to

the Operator’s Manual provided with product.

Always mention the appropriate model number

when communicating with us regarding your

battery pack.

988000-179

11-9-12 (REV:02)

Summary of content (6 pages)

PAGE 1
8 V LITHIUM-ION BATTERY PACK R840083, R840085, R840086, R840087 Series Use this battery pack for RIDGID ® 18V Lithium-ion cordless products only. Refer to the Operator’s Manual provided with product. Always mention the appropriate model number when communicating with us regarding your battery pack. SAFETY RULES WARNING! Read and understand all instructions. Failure to follow all instructions listed below, may result in electric shock, fire and/or serious personal injury.
PAGE 2
R840085, R840086 When a hot battery pack is placed on the charger, the charger may indicate the pack is not ready to charge. Please refer to charger operator’s manual. When the battery pack cools, the charger will automatically begin charging. CHARGING A cold BATTERY PACK R840083, R840087 LEDs CHARGE LEVEL indicator button A cold battery pack may be placed directly onto the charger port but charging will not begin until the battery temperature warms to within acceptable temperature range.
PAGE 3
18 V LITHIUM-ION BLOC-PILES R840083, R840085, R840086, R840087 série Utiliser ce bloc-piles uniquement avec les produits sans fil au lithium ion de 18 V de marque RIDGID ®. Consulter le manuel d’utilisation fourni avec le produit. Toujours mentionner le numéro de modèle ci-dessus lors de toute communication concernant le bloc-piles. RÈGLES DE SÉCURITÉ AVERTISSEMENT ! Lea y comprenda todas las instrucciones.
PAGE 4
R840085, R840086 chargeur, la DEL rouge commencera à clignoter alors que la DEL verte sera éteinte. Une fois le bloc-piles refroidit, le chargeur passe automatiquement en mode de charge. CHARGE D’UN BLOC-PILES FROID R840083, R840087 DÉL Bouton de l’indicateur du niveau de charge Un chargeur froid peut être placé directement sur le port du chargeur, mais la charge ne commencera que lorsque la température de la pile atteindra la plage de température acceptable.
PAGE 5
paquete de baterías 18 V DE IONES DE LITIO R840083, R840085, R840086, R840087 serie Use este paquete de baterías únicamente en productos inalámbricos que usan baterías RIDGID® de iones de litio de 18 V. Consulte el manual del operador suministrado con el producto. Al comunicarse con nosotros en relación con el paquete de baterias, siempre mencione el número correspondiente del modelo. Reglas de seguridad ¡ADVERTENCIA! Lea y comprenda todas las instrucciones.
PAGE 6
R840085, R840086 el cargador indicarán si el paquete de baterías no está listo para cargar. Le suplicamos consultar el manual del operador del cargador. Cuando el paquete de baterías se enfríe, se iniciará la carga de manera automática.