SDS

ManualsBrandsRIDGID ManualsHeat Guns18-Volt Cordless Butane Heat Gun-18-Volt OCTANE 3.0 Ah Lithium-Ion Battery Pack

Page 1 of 6

Technical Data Sheet

RIDGID Lithium-Ion Battery Pack

Battery Voltage: 18V

Battery Capacity: 3Ah / 54Wh

SECTION 1: PRODUCT AND COMPANY IDENTIFICATION

Product Name: Lithium-Ion Battery — Rechargeable Model Number: R840088

Issue Date: January 2020

Techtronic Industries Power Equipment Company Phone Number: 1-866-539-1710

P.O. Box 1288

Anderson, SC 29622 Emergency Contact Number:

Chemtrec (United States only): 1-800-424-9300

(International): +1-703-741-5970

SECTION 2: HAZARDS IDENTIFICATION

Refer to battery cell SDS for more information.

No exposure to hazards during routine handling of product.

WARNING:

• To reduce the risk of injury, user must read operator’s manual.

• Risk of fire and burns.

• Donotopen,crush,heatabove50˚C,incinerate,orshortterminals.

• Follow manufacturer’s instructions.

• Use only with charger listed in operator’s manual.

• Remove battery from tool when storing, changing attachments, or making adjustments.

• To reduce the risk of explosion and possible injury, do not place battery near fire or heat.

• Do not crush, drop, or damage battery pack.

• Do not use a battery pack that has been dropped or received a sharp blow. A damaged battery is subject to explosion.

Properly dispose of a dropped or damaged battery immediately.

• Under extreme usage or temperature conditions, battery leakage may occur. If fluid comes in contact with your skin,

wash immediately with soap and water. If fluid gets into your eyes, flush them with clean water for at least 10 minutes,

then seek immediate medical attention. Following this rule will reduce the risk of serious personal injury.

• Battery cells and battery pack assembly will burn if incinerated.

SECTION 3: COMPOSITION/INFORMATION OF INGREDIENTS

Refer to battery cell SDS for more information.

995000600

1-27-20 (REV:03)

Summary of content (17 pages)

PAGE 1
Technical Data Sheet RIDGID Lithium-Ion Battery Pack Battery Voltage: 18V Battery Capacity: 3Ah / 54Wh SECTION 1: PRODUCT AND COMPANY IDENTIFICATION Product Name: Lithium-Ion Battery — Rechargeable Model Number: R840088 Issue Date: January 2020 Techtronic Industries Power Equipment P.O.
PAGE 2
SECTION 4: FIRST AID MEASURES Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 3
SECTION 6: ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS: • Use standard industrial clothing in normal use. • If handling large containers of cells, wear steel‐-toed footwear. ENVIRONMENTAL PRECAUTIONS: No special precautions necessary. METHODS FOR CONTAINMENT: • Transport container outdoors. • Always consult and obey all international, federal, and local environmental laws.
PAGE 4
SECTION 10: STABILITY AND REACTIVITY Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 5
SECTION 12: ECOLOGICAL INFORMATION ECOTOXICOLOGICAL INFORMATION: None in routine handling of product. TOXICITY: No data available PERSISTENCE AND DEGRADABILITY (BIOPERSISTENCY & BIODEGRADABILITY): None in routine handling of product. POTENTIAL OF BIOACCUMULATION: None in routine handling of product. MOBILITY IN SOIL: None in routine handling of product. OTHER ADVERSE EFFECTS: No data available DISPOSAL: Follow guidelines in Section 13.
PAGE 6
SECTION 14: TRANSPORTATION INFORMATION U.S. DOT Hazardous Material Regulations (Re: Ground Transport) Lithium-ion batteries under 101 watt hours or Lithium-ion batteries packed with equipment under 101 watt hours when packaged correctly are not subject to any regulations when traveling by ground in the continental U.S.
PAGE 7
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Safety Data Sheet 1. Product and Company Identification Important Note: As a solid, manufactured article, exposure to hazardous ingredients is not expected with normal use. This battery is an article pursuant to 29 CFR 1910.1200 and, as such, is not subject to the OSHA Hazard Communication Standard requirement.
PAGE 8
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 2. Hazards Identification Classification of the substance or mixture. Preparation Hazards and Classification: The product is a Lithium ion cell or battery and is therefore classified as an article and is not hazardous when used according to the recommendations of the manufacturer. The hazard is associated with the contents of the cell or battery.
PAGE 9
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Labelling If the cell or battery is compromised and starts to leak, based upon the battery ingredients, the contents are classified as Hazardous Symbol: Signal word: Danger GHS precautionary statements Precautionary Statement(s) Prevention P102: Keep out of reach of children. P103: Read label prior to use. P202: Do not handle until all safety precautions have been read and understood.
PAGE 10
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Acute (short term): see Section 8 for exposure controls. In the event that this cell or pack has been ruptured, the electrolyte solution contained within the cell would be corrosive and can cause burns to skin and eyes. Inhalation: Inhalation of materials from a sealed cell is not an expected route of exposure. Vapors or mists from a ruptured cell may cause respiratory irritation.
PAGE 11
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 mechanically, electrically or physically abused/damaged. The hazardous contents are caustic alkaline electrolytes contained in cells with lithium metal oxide cathodes, graphite and carbon anodes and Polyvinylidenfluoride binders. Ingestion: Have victim rinse mouth thoroughly with water. DO NOT INDUCE VOMITING. Quickly transport victim to an emergency care facility.
PAGE 12
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Wear adequate personal protective equipment as indicated in Section 8. Environmental precautions Absorb spilled material with non-reactive absorbent such as vermiculite, clay or earth. Prevent from migration into soil, sewers and natural waterways – inform local authorities if this occurs.
PAGE 13
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 . Hygiene Measures: Do not eat, drink or smoke in work areas. Avoid storing food, drink or tobacco near the product. Practice and maintain good housekeeping. Environmental exposure controls: Avoid release to the environment. 9.
PAGE 14
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 to high temperature or is mechanically, electrically or physically abused/damaged. The following toxicology data is in respect to if a person comes into contact with the electrolyte. Acute Toxicity: Swallowed: The electrolyte contained within the cell or battery is a corrosive liquid. Ingestion of this electrolyte would be harmful.
PAGE 15
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Further information Ecological injuries are not known or expected under normal use. Do not flush into surface water or sanitary sewer system. 13. Disposal Considerations Advice on disposal For recycling consult manufacturer. Contaminated packaging Disposal in accordance with local regulations. 14.
PAGE 16
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T T8 Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Forced Discharge Pass battery only 15. Regulatory Information Canadian Federal Regulations: These products have been classified in accordance with the hazard criteria of the Controlled Products Regulations and the SDS contains all the information required by the Controlled Products Regulations. WHMIS Classification: Not Controlled, manufactured article.
PAGE 17
SAMSUNG SDI Co., Ltd. Date: January 1, 2018 MODEL: INR21700-30T Reference no.: SDI-TTi-30T-I-1 Revision no.: 00 Taiwanese Regulations Regulation of Labelling and Hazard Communication of Dangerous and Harmful Materials: Labeling requirements and other relevant provision of chemicals, this product is not classified as dangerous goods. Toxic Chemicals Substance Control Law: Not Listed. CNS 1030016 Safety of primary and secondary lithium cells and batteries during transport.