Installation Manual

72 Rinnai I-Series Condensing Boiler Solo Manual
Complete the following checklist when boiler installaon is complete. You should be able to answer YES to each
queson. If you answer NO, installaon is not complete. Refer to the applicable secon in this manual for
addional informaon.
INSTALLATION LOCATION YES NO
Have you veried the unit, vent and air intakes meet the clearance requirements?
 
VENTING YES NO
Have all corrosive compounds been removed from around the combuson air intake of the boiler?
 
Have you followed the combuson air requirements to provide sucient combuson air for the boiler?
 
Are the correct venng products for the installed model being ulized?
 
Have you installed the vent screen(s) for Schedule 40 PVC/CPVC vent applicaons if applicable?
 
Have you veried the vent system does not exceed maximum length?
 
SYSTEM PIPING YES NO
Have the water lines been purged of all debris and the lter cleaned?
 
Have you veried the hot and cold water lines to the boiler are not interchanged?
 
Does the water supply to the boiler have adequate pressure? Is it free of chemicals? Did you verify it
does not exceed total hardness that will damage the heat exchanger?
 
Have you veried that no toxic chemicals were introduced to the potable water?
 
Did you drain the boiler if not intended to be used immediately?  
Have water quality issues (if any) been addressed?
 
Have you performed the leak and pressure test for the boiler and plumbing system?
 
CONDENSATE DRAIN YES NO
If the condensate pump is installed, is it wired to deacvate the boiler in the event of failure?
 
Did you verify the condensate drain pipe is as short as possible and has a downward pitch toward the
drain or condensate pump?
 
Is all condensate drained and disposed of as per local codes?
 
Did you use ONLY corrosion resistant materials for the condensate drain lines?
 
Did you verify the condensate drain pipe along its enre length is at least the same diameter as the
drain line?
 
Did you check to ensure the condensaon drain lines are protected from freezing?
 
Have you veried the condensate drain line is not plumbed with the pressure relief valve?
 
Have you conrmed the condensate drain line is not connected with an air condioning evaporator coil
drain?
 
This boiler has an integrated condensate trap. Have you veried that an external condensate trap is not
installed?
 
Have you conrmed the end of the condensate drain pipe is open to atmosphere?
 
Has an air gap been installed in the condensate drain line?
 
11