31” COWBOY Grill with Rotisserie Owner’s Manual Assembly and Operating Instructions Model # GR1038-014612 Tools required for assembly: (Not Included) Pliers, Philips & Flathead Screwdrivers, Adjustable Wrench. Keep this manual for future reference.
! WARNING ! z Only use this grill on a hard, level, non-combustible, stable surface (concrete, ground, etc.) capable of supporting the weight of the grill. Never use on wooden or other surfaces that could burn. z When grill is in use, keep clearance of 36” between the hot grill and any combustible materials, such as bushes, trees, wooden decks, wooden fences, buildings, etc. Do not place hot grill under roof overhang or in any other enclosed area. z For outdoor use only.
! WARNING ! z When grilling, grease from meat may drip into the charcoal and cause a grease fire. Do not use water to extinguish grease fires use a fire extinguisher. z Use caution! Keep hands, face and body a safe distance away. z Use caution during assembly and while operating your grill to avoid scrapes or cuts from sharp edges of metal parts. Use caution when reaching into or under grill. z In windy weather, place grill in an outdoor area that is protected from the wind.
ASSEMBLY INSTRUCTIONS THANK YOU FOR PURCHASING THIS COWBOY GRILL Read all safety warnings & assembly instructions carefully before assembling or operating your grill. For missing parts, please contact customer service at customerservice@rankam.com or at 888-837-1380 (U.S. only) (Proof of purchase will be required.) Inspect contents of the box to ensure all parts are included and undamaged. We recommend two people for assembly of this grill.
Replacement Parts List STOP! DO NOT RETURN TO RETAILER. For assembly assistance, missing or damaged parts, please call customer service 888-837-1380, or email customerservice@rankam.
Hardware List GR1038-014612 ENG 6 28072011
Symbol: The following symbols will be shown in each procedure for indication of tightening the bolt and nut if necessary. Hand Tighten only at this time Tighten with tools at this time Some steps may require the assistance of a friend.
Step 3 Step 4 GR1038-014612 ENG 8 28072011
Step 5 Step 6 GR1038-014612 ENG 9 28072011
Step 7 Step 8 GR1038-014612 ENG 10 28072011
Step 9 Step 10 GR1038-014612 ENG 11 28072011
Step 11 Step 12 GR1038-014612 ENG 12 28072011
Step 13 ! WARNING ! WARNING ! WARNING ! DO NOT use grill when the drain pipe cap is removed. DO NOT attempt to remove the drain pipe cap while the grill is hot. ! Place the grill outdoors on a hard, level, non-combustible surface away from roof overhang or any combustible material. Never use on wooden or other surfaces that could burn. Place the grill away from open windows or doors to prevent smoke from entering your house.
PREPARTION FOR USE & LIGHTING INSTRUCTIONS Curing your grill Prior to your first use of the Grill, follow the instructions below carefully to cure your grill. Curing your grill will minimize damage to the exterior finish as well as rid the grill of paint odor that can impart unnatural flavors to the first meal prepared on the grill. IMPORTANT: To protect your grill from excessive rust, the unit must be properly cured and covered at all times when not in use.
Step 3 Saturate charcoal with lighting fluid. Wait 2 to 3 minutes to allow lighting fluid to soak into charcoal. Store charcoal lighting fluid a safe distance from the grill. Step 4 Stand back and carefully light charcoal and allow to burn until covered with a light ash (approximately 20 minutes). ! WARNING ! Charcoal lighting fluid must be allowed to completely burn off (approximately 20 minutes).
! WARNING ! Never add charcoal lighting fluid to hot or even warm coals as flashback may occur causing severe burns. Step 4 When charcoal is burning strong again, wear oven mitts/gloves and carefully return cooking grate to grill body. Extinguish any hot ashes, coals or embers which may have fallen from the grill or beneath and around grill. AFTER-USE SAFETY ! WARNING ! z Always allow grill and all components to cool completely before handling. z Never leave coals and ashes in grill unattended.
LIMITED WARRANTY 1. Manufacturer warrants this Product to be free from defects in workmanship and materials for a period of Ninety (90) days from the date of purchase, PROVIDED claims are submitted, in writing, with proof of purchase. 2.
GR1038-014612 ENG 18 28072011
GR1038-014612 ENG 19 28072011
Should you encounter any problems, CONTACT US FIRST DO NOT return product to the store! RANKAM METAL PRODUCTS MANUFACTORY LTD. 1618 W.Rosecrans Ave., Gardena, CA90249. Toll Free (888) 837 – 1380 Email: CustomerService@rankam.
