Service manual

03-14
✰ After the oil drains out, remove
vehicle from centre stand and tilt
the vehicle to both LH and RH sides
3 to 4 times to drain out maximum
oil.
✰ Quantity of oil that can be drained
in 2.35 Litres approximately.
✰ Two level marks are provided on
the Oil level window in Cover RH
Max. & Min.
✰ If oil level is below the Min mark top
up, till the level in between Max and
Min mark. Do not overfill.
NOTE :
Oil capacity Min to Max mark is approx
350 ml.
OIL CHANGE :
Refer Periodical Maintenance chart (page
No. 03-12) for frequency.
✰ Keep vehicle on level ground.
✰ Start the engine and warm up
sufficiently so that the oil drains
faster.
Max
Min
DRAINING PROCEDURE :
✰ Keep a clean tray under the engine
✰ Remove the two Hex Flange Bolts M5
X 16, Sump drain Cap, “O” ring and
Suction filter Assy.
✰ Remove the Magnetic Plug assy
along with its washer.
Primary Drain Cap
Secondary Drain Plug
TILT VEHICLE
RH & LH
Periodical Maintenance
NOTE :
Replace oil filter element whenever engine
oil is changed.
✰ Remove the old oil filter as shown in
Fig.
FITTING PROCEDURE
✰ Soak the new oil filter in engine oil
for 15 minutes.
✰ Refit the oil filter, “O’’rings and
plate washer.
✰ After cleaning secondary oil drain
magnet bolt assemble the same to
crankcase with washer.