Service manual

03-18
✰ Top up, with 1F Endurance Fork Oil
or equivalent, if required
B. OIL CHANGE
(EVERY 12,000 KMS)
✰ Remove the fork ends from the
vehicle.
✰ Check as detailed in the Section 8
DISC BRAKE FLUID LEVEL CHECK
✰ Check brake fluid is above the ‘Min’
level in master cylinder.
✰ Fill 195 ml of 1F Endurance Fork
Oil in each leg .
✰ Bump the fork several times and
then assemble bolt cap with “O” ring
(to release air lock if any).
✰ Assemble back all removed parts.
MAX
MIN
✰ Top up if level is below ‘Min’ mark.
✰ To Top up the fluid, remove the
master cylinder top cover 2 screws
and take out cover, plate &
diaphragm.
✰ Top up brake Fluid DOT 3 or DOT 4
upto “MAX” level.
CAUTION :
As the brake fluid is highly corrosive,
take care that it does not spill over other
parts. It is suggested to wipe brake fluid
immediately, if there is any spill over in
other parts,using a soft cloth (preferably
a wet cloth).
STEERING PLAY ADJUSTMENT
(EVERY 6,000 KMS)
✰ Keep a wooden plank under the
stand.
✰ Rock the front end and feel the play
at stem top end as shown in fig.
Periodical Maintenance
✰ If felt, adjust as follows :
✰ Loosen crown plate bolts as shown
picture ‘A’