ORIGINAL INSTRUCTIONS Petrol Lawn Mower RLM5319SMEB RLM140SP
Important! It is essential that you read the instructions in this manual before operating this machine. Subject to technical modifications.
English GENERAL SAFETY RULES ■ Always mow in the daylight or in good artificial light. ■ Do not operate the machine in explosive atmospheres, such as in the presence of flammable liquids, gases or dust. The tool create sparks which may ignite the dust or fumes. ■ Objects struck by the lawn mower blade can cause severe injuries to persons. Thoroughly inspect the area where the machine is to be used and remove all rocks, sticks, metal, wire, bones, toys, or other foreign objects.
English necessary. If you must back the machine away from a wall or obstruction, first look down and behind to avoid tripping or pulling the machine over your feet. ■ Stop the blade(s) if the machine has to be tilted for transportation when crossing surfaces other than grass, and when transporting the machine to and from the area to be mowed. ■ Never operate the machine with defective guards or shields, or without safety devices, for example deflectors and/or grass collector, in place.
English Keep bystanders a safe distance away from the machine. Keep all body parts and clothing clear of any belts or other moving parts. Fuel and its vapours are explosive and can cause severe burns or death. To avoid injury, stay away from moving parts at all times. Fuel and its vapors are extremely flammable and explosive. Fire can cause severe burns or death. Use unleaded petrol intended for motor vehicle use with an octane rating of 87 [(R + M)/2] or higher. Danger! Keep hands and feet away.
English 18. Pins 19. Side discharge door 20. Hooks of side discharge deflector 21. Side discharge door opening ASSEMBLY WARNING Never operate the mower without the proper safety devices in place and working. Never operate the mower with damaged safety devices. Operation of this product with damaged or missing parts could result in serious personal injury. UNPACKING This product requires assembly. ■ Carefully remove the product and any accessories from the box.
English SETTING BLADE HEIGHT See figure 6. When shipped, the wheels on the mower are set to a lowcutting position. Before using the mower for the first time, adjust the cutting position to the height best suited for your lawn. The average lawn should be between 3 and 6 cm, depending on the season. ■ To raise the blade height, grasp the height adjustment lever and move it toward the back of the mower. ■ To lower the blade height, grasp the height adjustment lever and move it toward the front of the mower.
English the engine and should not be used. To add engine oil: 1. Be sure mower is level and area around oil cap/dipstick is clean. 2. Remove the cap and seal from oil bottle. 3. Unscrew the oil cap/dipstick and remove. 4. Slowly add oil. Fill to the “Full” line on dipstick. Do not overfill. NOTE: When checking the oil level, seat the dipstick in the oil fill hole but do not screw in. 5. Reinstall the oil cap/dipstick and secure. EMPTYING THE GRASS CATCHER See figure 9. 1.
English 5. 6. 7. 8. Run the engine in place for approximately 30 seconds. Shut off the engine. Turn off the water supply. Inspect the underside of the mower deck for cleanliness, and repeat the cleaning procedure if desired. LUBRICATION All of the bearings in this product are lubricated with a sufficient amount of high grade lubricant for the life of the unit under normal operating conditions. Therefore, no further bearing lubrication is required.
English MAINTAINING THE SPARK PLUG See figure 11. The spark plug must be properly gapped and free of deposits in order to ensure proper engine operation. To check: 1. Remove spark plug boot. 2. Clean any dirt from around base of spark plug. 3. Remove spark plug using a 13/16 in. spark plug socket (not provided). 4. Inspect spark plug for damage, and clean with a wire brush before reinstalling. If insulator is cracked or chipped, spark plug should be replaced.
English SPECIFICATIONS Engine Subaru 190cc OHC Drive system Rear wheel self-propelled No-load speed 2,800 / min (RPM) Cutting path 530 mm Height adjustments 7 positions 19 mm−76 mm Wheel size 20.3 cm (8 inch) - Rear 27.9 cm (11 inch) Grass bag capacity 70 litres Measured sound power level LwA 97.28 dB(A), K= 0.88 dB Sound pressure level LpA 81.7 dB(A), K= 3 Vibration level 3.92 m/s², K= 1.5 Guaranteed sound power level 98.0 dB(A) Weight 41.
TROUBLESHOOTING Problem Possible cause Check to be sure that lower part of handle is pushed fully back and snapped into proper position. Handle knobs not tightened. Tighten handle knobs. No spark. Use spark tester to check for proper spark plug operation. Handle not in correct position. Mower is not starting. Mower is hard to push. Mower is vibrating at higher speed. Solution Handle positioned incorrectly. No petrol. Check the fuel valve set to open. Fill mower with petrol.
GUARANTEE In addition to any statutory rights resulting from the purchase, this product is covered by a guarantee as stated below. 1. The guarantee period is 24 months for consumers and commences on the date when the product was purchased. This date has to be documented by an invoice or other proof of purchase. The product is designed and dedicated to consumer and private use only. So there is no guarantee provided in case of professional or commercial use. 2. There is, in some cases (i.e.
DECLARATION OF CONFORMITY Techtronic Industries GmbH Max-Eyth-Strasse 10, D-71364 Winnenden, Germany Herewith we declare that the product Petrol Lawn Mower Model number: RLM5319SMEB Serial number range: 92300402000001 - 92300402999999 is in conformity with the following European Directives and harmonised standards 2006/42/EC, 2004/108/EC, 2000/14/EC, 2005/88/EC, 2011/65/EU, EN 836:1997+A4:2011 Measured sound power level: 97.28 dB(A) Guaranteed sound power level: 98.
