SDS

ManualsBrandsRyobi ManualsLawn Mowers16 in. 40-Volt Lithium-Ion Cordless Battery Walk Behind Push Lawn Mower - 4.0 Ah Battery/Charger Included

Page 1 of 6

Technical Data Sheet

Ryobi Lithium-Ion Battery Pack

Battery Voltage: 40V

Battery Capacity: 4Ah / 144Wh

SECTION 1: PRODUCT AND COMPANY IDENTIFICATION

Product Name: Lithium-Ion Battery — Rechargeable Model Number: OP4040

Issue Date: April 2016

Techtronic Industries Power Equipment Company Phone Number: 1-800-860-4050

1428 Pearman Dairy Road

Anderson, SC 29625 Emergency Contact Number:

Chemtrec (United States only): 1-800-424-9300

(International): +1-703-741-5970

SECTION 2: HAZARDS IDENTIFICATION

Refer to battery cell SDS for more information.

No exposure to hazards during routine handling of product.

WARNING:

• To reduce the risk of injury, user must read operator’s manual.

• Risk of fire and burns.

• Donotopen,crush,heatabove50˚C,incinerate,orshortterminals.

• Follow manufacturer’s instructions.

• Use only with charger listed in operator’s manual.

• Remove battery from tool when storing, changing attachments, or making adjustments.

• To reduce the risk of explosion and possible injury, do not place battery near fire or heat.

• Do not crush, drop, or damage battery pack.

• Do not use a battery pack that has been dropped or received a sharp blow. A damaged battery is subject to explosion.

Properly dispose of a dropped or damaged battery immediately.

• Under extreme usage or temperature conditions, battery leakage may occur. If fluid comes in contact with your skin,

wash immediately with soap and water. If fluid gets into your eyes, flush them with clean water for at least 10 minutes,

then seek immediate medical attention. Following this rule will reduce the risk of serious personal injury.

• Battery cells and battery pack assembly will burn if incinerated.

SECTION 3: COMPOSITION/INFORMATION OF INGREDIENTS

Refer to battery cell SDS for more information.

991000937

4-26-16 (REV:01)

Summary of content (16 pages)

PAGE 1
Technical Data Sheet Ryobi Lithium-Ion Battery Pack Battery Voltage: 40V Battery Capacity: 4Ah / 144Wh SECTION 1: PRODUCT AND COMPANY IDENTIFICATION Product Name: Lithium-Ion Battery — Rechargeable Model Number: OP4040 Issue Date: April 2016 Techtronic Industries Power Equipment 1428 Pearman Dairy Road Anderson, SC 29625 Company Phone Number: 1-800-860-4050 Emergency Contact Number: Chemtrec (United States only): 1-800-424-9300 (International): +1-703-741-5970 SECTION 2: HAZARDS IDENTIFICATI
PAGE 2
SECTION 4: FIRST AID MEASURES Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 3
SECTION 6: ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS: • Use standard industrial clothing in normal use. • If handling large containers of cells, wear steel‐-toed footwear. ENVIRONMENTAL PRECAUTIONS: No special precautions necessary. METHODS FOR CONTAINMENT: • Transport container outdoors. • Always consult and obey all international, federal, and local environmental laws.
PAGE 4
SECTION 10: STABILITY AND REACTIVITY Refer to battery cell SDS for more information. No exposure to hazards during routine handling of product. WARNING: • To reduce the risk of injury, user must read operator’s manual. • Risk of fire and burns. • Do not open, crush, heat above 50˚C, incinerate, or short terminals. • Follow manufacturer’s instructions. • Use only with charger listed in operator’s manual. • Remove battery from tool when storing, changing attachments, or making adjustments.
PAGE 5
SECTION 12: ECOLOGICAL INFORMATION ECOTOXICOLOGICAL INFORMATION: None in routine handling of product. TOXICITY: No data available PERSISTENCE AND DEGRADABILITY (BIOPERSISTENCY & BIODEGRADABILITY): None in routine handling of product. POTENTIAL OF BIOACCUMULATION: None in routine handling of product. MOBILITY IN SOIL: None in routine handling of product. OTHER ADVERSE EFFECTS: No data available DISPOSAL: Follow guidelines in Section 13.
PAGE 6
SECTION 14: TRANSPORTATION INFORMATION U.S. DOT Hazardous Material Regulations (Re: Ground Transport) UN3480 Lithium-ion batteries over 101 watt hours or UN3481 Lithium-ion batteries packed with equipment over 101 watt hours when packaged correctly can travel under 49 CFR 173.185 when traveling by ground in the continental U.S.
PAGE 7
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 Safety Data Sheet 1. Product and Company Identification Important Note: As a solid, manufactured article, exposure to hazardous ingredients is not expected with normal use. This battery is an article pursuant to 29 CFR 1910.1200 and, as such, is not subject to the OSHA Hazard Communication Standard requirement.
PAGE 8
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 2. Hazards Identification Classification of the substance or mixture. Preparation Hazards and Classification: The product is a Lithium ion cell or battery and is therefore classified as an article and is not hazardous when used according to the recommendations of the manufacturer. The hazard is associated with the contents of the cell or battery.
PAGE 9
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 Other Hazards. Appearance, Color and Odor: Solid object with no odor. Primary Routes(s) of Exposure: These chemicals are contained in a sealed enclosure. Risk of exposure occurs only if the cell or pack is mechanically, thermally, electrically or physically abused to the point of compromising the enclosure.
PAGE 10
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 Because of the cell structure the dangerous ingredients will not be available if used properly. During charge process a lithium graphite intercalation phase is formed. 4. First Aid Measures Description of first aid measures The hazardous components of this cell or battery are contained within a sealed unit.
PAGE 11
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 not flammable but internal organic material will burn if the cell is incinerated. 6. Accidental Release Measures Personal precautions, protective equipment and emergency procedures: As an immediate precautionary measure, isolate spill or leak area for at least 25 meters (75 feet) in all directions. Keep unauthorized personnel away. Stay upwind. Keep out of low areas.
PAGE 12
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 use.PVC gloves are recommended when dealing with a leaking or ruptured cell or battery. Skin (clothing) protection: Skin protection is not required when handling the cell or battery during normal use. Wear long sleeved clothing to avoid skin contact if handling a leaking or ruptured cell or battery. Soiled clothing should be washed with detergent prior to re-use.
PAGE 13
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 No decomposition if stored and applied as directed. 11. Toxicological Information Information on toxicological effects: The hazardous components of the cell or battery are contained within a sealed unit.
PAGE 14
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 Aspiration Hazard: The cells or batteries are not classified as an aspiration hazard, based on the available data and the known hazards of the components. However, due to the corrosive nature of the product if swallowed, do NOT induce vomiting.
PAGE 15
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.: 00 T4 T5 T6 T7 Shock External Short Circuit Impact/Crush Overcharge Pass Pass Pass Pass T8 Forced Discharge Pass For pack and single cell battery only 15.
PAGE 16
SAMSUNG SDI ENERGY MALAYSIA SDN.BHD. Date: January 1, 2016 Reference no.: SDI-TTi-20Q-M-G-1 MODEL: INR18650-20Q M Revision no.