Operation Manual

13
EREN BESEITIGUNG @ 0\mod_1115373523343_1521.docx @ 1904 @ 1 @ 1
19 TROUBLESHOOTING
Pos: 25.3.1 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/1 Tabellenkopf @ 0\mod_1115374760156_1521.docx @ 1884 @ @ 1
Fault Possible cause Remedy
Pos: 25.3.2 /Innenteil/Störungsursachen und deren Beseitigung/Störung stabellenelemente/Motor springt nicht an E-Start 43er, (fixed speed) Quantum+675EXi, neu SA1855,SA1856 @ 50\mod_1488805276362_1521.docx @ 561877 @ @ 1
Engine does not start
up
Control handle not
turned down.
Press the control handle onto
the upper part of the bar D .
Fuel tank empty. Fill up with clean and fresh
fuel.
Spark plug connector
loose.
Push plug connector in place
or have it checked by an
authorised workshop.
Spark plug defective or
soiled or electrodes worn
out.
Replace or clean spark plug,
set electrode distance Y :
0.5 mm (for model
43-VARIO (SA1455), R43V,
R43VE)
0.7 - 0.8 mm
(for model 43-A ECONOMY,
43-VARIO (SA1855), 43-
VARIO E, R43S).
Too much petrol feed to
engine (spark plug wet).
Have it checked by an
authorised workshop.
Air filter soiled. Clean or replace the air filter
insert W .
Battery not charged (only
for electro-start).
Charge battery W1 , X1 .
Start-up takes longer
than 5 seconds or is
repeated too often
(only for electro-start).
If you experience start
difficulties, contrary to
expectations, the battery
must also be charged in
between.
Connection cable
between the ignition key,
battery and engine is
loose or without contact
(only for electro-start).
Connect the battery
connector with the mating
connector on the harness
U1 or check it or have it
checked by an authorised
workshop.
Pos: 25.3.3 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Motorleistung lässt nach @ 33\mod_1408527299785_1521.docx @ 241497 @ @ 1
Engine power
decreasing
Air filter soiled. Clean or replace the air filter
insert W .
Spark plug clogged with
soot.
Have it checked by an
authorised workshop.
Fuel old or soiled Empty the petrol tank and fill
with fresh petrol.
Pos: 25.3.4 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Motor läuft unregelmäßig @ 0\mod_1127909273145_1521.docx @ 1891 @ @ 1
Engine runs irregularly
Air filter dirty. Clean or replace air filter
insert W .
Spark plug contaminated
with soot.
Have it cleaned by an
authorized dealer.
Have it checked by an
authorized dealer.
Pos: 25.3.5 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Mäher fährt nicht (nur bei zuschaltbarem Fahrantrieb) MUSTER @ 17\mod_1334237837356_1521.docx @ 137112 @ @ 1
Mower is not moving
(only with selective
motor drive)
Drive control bar not
pulled.
Pull drive control bar G .
Have it checked by an
authorised workshop.
Pos: 25.3.6 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Fahrgeschwindigkeit kann nicht reguliert werden (nur bei VARIO-Antrieb) MUSTER @ 17\mod_1331728174348_1521.docx @ 134610 @ @ 1
Driving speed cannot
be regulated (only with
VARIO drive)
Have it checked by an
authorised workshop.
Pos: 25.3.7 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabel lenelemente/Starke Erschütterungen (Vibrieren) @ 0\mod_1115377318234_1521.docx @ 1900 @ @ 1
Extreme vibration
Have it checked by an
authorized dealer
Pos: 25.3.8 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabel lenelemente/Schnitt unsauber, Rasen wird gelb, Benzin MUSTER @ 17\mod_1331728299135_1521.docx @ 134627 @ @ 1
Cut not clean,
lawn turns yellow
Cutting blade blunt. Have it sharpened and
balanced by an authorised
workshop Q .
Cutting height too low. Set higher cutting height I .
Motor speed too low. Have it checked by an
authorized dealer
Mowing speed too high. Adapt mowing speed, switch
motor drive off if necessary.
Insufficient overlap
between mowing lanes.
If grass is long, the mowing
lanes may need to overlap
further.
Lawn matted. A perceptible improvement
can be achieved by using a
scarifier.
Pos: 25.3.9 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Auswurf verstopft, Benzin, TurboSignal MUSTER @ 17\mod_1331728502002_1521.docx @ 134644 @ @ 1
Ejector blocked
TurboSignal ignored
J + K .
Empty the collecting bag L .
Engine speed too low. Have it checked by an
authorized dealer
Cutting height too low
with grass too high.
Set higher cutting height I .
Mowing speed too fast. Adapt mowing speed, switch
motor drive off if necessary.
Grass is damp. Allow the lawn to dry.
Pos: 25.3.10 /Innenteil/Störungsursachen und deren Beseitigung/Störungstabellenelemente/Gemulchte Gras sieht schlecht aus Heckauswurf MUSTER @ 17\mod_1331728621432_1521.docx @ 134661 @ @ 1
The mulched grass
does not look good:
clumps, excessive cut
material, coarse cut
Cutting blade blunt. Have it sharpened and
balanced by an authorised
workshop.
Mulching rule ignored
(cut max. 1/3 of grass
height; the grass height
to be cut must be less
than 10 cm)
Set higher cutting height I .
Convert mower to rear
ejection U2 + S1 and mow
lawn with high cutting height
first.
Driving speed too high. Adapt driving speed, switch
motor drive off if necessary.
Grass accumulation
under the mower blade.
Set higher cutting height I .
Insufficient overlap
between mowing lanes.
If grass is long, the mowing
lanes may need to overlap
further.
Grass is damp. Set higher cutting height I .
Allow the lawn to dry.
Pos: 25.4 /Innenteil/Störungsursachen und deren Beseitigung/Störungsursachen und deren Beseitigung Text Benzin @ 0\mod_1115378183390_1521.d ocx @ 1905 @ @ 1
In case of faults and defects which have not been listed here, please contact the
nearest authorized dealer.
Repairs which require specialized knowledge should only be performed by a qualified
expert. Your authorized dealer will naturally also be glad to help if you do not wish to
perform the maintenance work described here yourself.
Pos: 26.1 /---------- 1 Leerzeile ---------- @ 0\mod_1114611787140_1521.docx @ 2070 @ @ 1
Pos: 26.2 /Innenteil/Technische Daten/ 1 TECHNISCHE DATEN @ 26\mod_1377505215393_1521.docx @ 193414 @ 1 @ 1
20 TECHNICAL DATA
Pos: 26.3 /Innenteil/Technische Daten/1.1 Motor Benzin @ 26\mod_1377506244877_1521.docx @ 193446 @ 2 @ 1
Engine
Pos: 26.4 /Innenteil/Beschrei bung der Bauteile/43-VARIO (SA1455), R43V, R43VE @ 50\mod_1488789973726_0.docx @ 561653 @ @ 1
43-VARIO (SA1455), R43V, R43VE
Pos: 26.5 /Innenteil/Technische Daten/Motor SAU12675, SAU12676 (für Elektro-Start Modelle) 5,4 Ah @ 44\mod_1469431031346_1521.docx @ 506165 @ @ 1
Motor B&S 4-stroke motor, 650 Quantum
Capacity 190 cm
3
Rotation speed 2800 min
-1
Power of Device 2.4 kW
Electrode gap 0,5 mm
Battery (only for electro-start models) 12 V / 5.4 Ah
Fuel Unleaded standard petrol,
with max.10% ethanol
Tank capacity approx. 1.2 litres
Lubricating oil SAE 30, SAE 10W30, SAE 5W30
or similar brand name oil,
Minimum quality SF
Oil quantity 0.5 - 0.6 litres
Pos: 26.6 /Innenteil/Beschreibung der Bauteile/43-A ECONOMY, 43-VARIO (SA1855), 43-VARIO E, R43S @ 50\mod_1488789171995_0.docx @ 561625 @ @ 1