MSDS

ManualsBrandsSAKRETE ManualsBuilding materials40 lb.Top 'N Bond Concrete Patcher in Gray

10/4/2005 BONSAL® Top N Bond Page 1 of 6

MATERIAL SAFETY DATA SHEET

Date Prepared: September 29, 2005

1. PRODUCT/COMPANY IDENTIFICATION

Product Name:

BONSAL® Top N Bond

Emergency Telephone:

800-424-9300 (Chemtrec) or

703-527-3887 (Outside USA)

Manufacturer’s Name & Address:

Bonsal American/an Oldcastle Company

8201 Arrowridge Blvd.

Charlotte, NC 28273

Telephone Number for Information:

704-525-1621

2. EMERGENCY AND FIRST AID

EMERGENCY INFORMATION:

The product is a cementitious powder blend. When in contact

with moisture in eyes or on skin, or when mixed with water, it

becomes highly caustic (pH > 12) and will damage or burn (as

severely as third-degree) the eyes or skin. Inhalation may cause

irritation to the moist mucous membranes of the nose, throat and

upper respiratory system or may cause or may aggravate certain

lung diseases or conditions. Use exposure controls or personal

protection methods described in Section 12.

EYES:

Immediately flush eye thoroughly with water. Continue flushing

eye for at least 15 minutes, including under lids, to remove all

particles. Call physician immediately.

SKIN:

Wash skin with cool water and pH-neutral soap or a mild

detergent. Seek medical treatment if irritation or inflammation

develops or persists. Seek immediate medical treatment in the

event of burns.

INHALATION:

Remove person to fresh air. If breathing is difficult, administer

oxygen. If not breathing, give artificial respiration. Seek medical

help if coughing and other symptoms do not subside. Inhalation

of large amounts of the product require immediate medical

attention.

INGESTION:

Do not induce vomiting. If conscious, have the victim drink

plenty of water and call a physician immediately.

Summary of content (6 pages)

PAGE 1
MATERIAL SAFETY DATA SHEET Date Prepared: September 29, 2005 1. PRODUCT/COMPANY IDENTIFICATION Product Name: BONSAL® Top N Bond Emergency Telephone: 800-424-9300 (Chemtrec) or 703-527-3887 (Outside USA) Manufacturer’s Name & Address: Bonsal American/an Oldcastle Company 8201 Arrowridge Blvd. Charlotte, NC 28273 Telephone Number for Information: 704-525-1621 2. EMERGENCY AND FIRST AID EMERGENCY INFORMATION: The product is a cementitious powder blend.
PAGE 2
3. COMPOSITION INFORMATION DESCRIPTION: This product consists of a heterogeneous mixture of hydraulic cement and sand. The major compounds are: 3CaO•SiO2 2CaO•SiO2 3CaO•Al2O3 4CaO•Al2O3•Fe2O3 CaSO4•2H2O SiO2 Tricalcium Silicate Dicalcium Silicate Tricalcium Aluminate Tetracalcium aluminoferrite Calcium Sulfate dihydrate (Gypsum) Silica Sand CAS #12168-85-3 CAS #10034-77-2 CAS #12042-78-3 CAS #12068-35-8 CAS #7778-18-9 (CAS #13397-24-5) CAS #14808-60-7 4.
PAGE 3
5. HAZARD IDENTIFICATION POTENTIAL HEALTH EFFECTS: NOTE: Potential health effects may vary depending upon the duration and degree of exposure. To reduce or eliminate health hazards associated with this product, use exposure controls or personal protection methods as described in Section 12. EYE CONTACT: (Acute/Chronic) Exposure to airborne dust may cause immediate or delayed irritation or inflammation of the cornea.
PAGE 4
6. ACCIDENTAL RELEASE MEASURES Contain material to prevent contamination of soil, surface water or ground water. Use dry clean-up methods that do not disperse dust into the air or entry into surface water. Material can be used if not contaminated. Place in an appropriate labeled container for disposal or use. Avoid inhalation of dust and contact with skin and eyes. Use exposure control and personal protection methods as described in Section 12. 7.
PAGE 5
10. PRECAUTIONS FOR HANDLING AND STORAGE Keep dry until used. Handle and store in a manner so that airborne dust does not exceed applicable exposure limits. Use adequate ventilation and dust collection. Use exposure control and personal protection methods as described in Section 12. HANDLING AND STORAGE 11. TOXICOLOGICAL INFORMATION See Section 5 for Hazard Identification. No recognized unusual toxicity to plants and animals.
PAGE 6
Comply with all applicable local, state and federal regulations for disposal of unusable or contaminated materials. Dispose of packaging/containers according to local, state and federal regulations. 14. TRANSPORTATION DATA The product is not hazardous under U.S. DOT or TDG regulations. 15. OTHER REGULATORY INFORMATION Status under US OSHA Hazard Communication Rule 29 CFR 1910.